CANON INC -- A-30 CARTRIDGE TONER BLACK
=======================================================
Material Safety Data Sheet
=======================================================
NIIN: 01-323-6114
MSDS Num: CJKSV
MSDS NAME: A-30 CARTRIDGE TONER BLACK
Responsible Party
Name: CANON INC
Address: 30-2 SHIRMOMARUKO 3 CHOME
City: TOKYO, JAPAN NK 00000
Info Phone: 03-3758-2111
Emergency Phone Number: (800)424-9300
Resp. Party Other MSDS No.: CPY-0176-003
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: TONER,DIRECT ELECTROSTATIC PROCESS
Unit of Issue: EA
UI Container Qty: 0
Type of Container: UNKNOWN
=======================================================
Ingredients
=======================================================
Name: *** PROPRIETARY ***
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: TWA/PEL: 15 MG/M3 TOTAL DUST, OSHA
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: CHRONIC-BASED UPON AVAILABLE DATA, HUMAN EXPOSURE TO TONER
HAS BEEN SHOWN TO CAUSE MINIMAL RESPIRATORY TRACT IRRITATION AS MAY OCCUR
WITH LARGE AMOUNTS OF ANY NONTOXIC DUSTS.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: INHALATION-EXPECTED TO BE A LOW HAZARD FOR
RECOMMENEDED HANDLING. EYE-NO SPECIFIC HAZARDS KNOWN. MAY CAUSE TRANSIENT
IRRITATION. SKIN-EXPECTED TO BE LOW HAZARD FOR RECOMMENDED HANDLING.
INGESTION-EXPE CTED TO BE LOW INGESTION HAZARD.
First Aid: INHALATION-IF SYMPTOMATIC, MOVE TO FRESH AIR. GET MEDICAL ATTENTION
IF SYMPTOMS PERSISTS. EYES-ANY MATERIAL THAT CONTACTS THE EYE SHOULD BE
WASHED OUT IMMEDIATELY WITH WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
SKIN-WASH WITH SOAP AND WATER. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
INGESTION-DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SWEEP MATERIAL ONTO PAPER AND PLACE IN A FIBER
CARTON. DO NOT USE A VACUUM CLEANER TO CLEAN-UP SPILLS OF POWDERED TONER. THE
FINE PARTICLES CAN CAUSE A FIRE OR EXPLOSION.
Waste Disposal Methods: INCINERATE OR LANDFILL, CAN BE INCINERATEED WHEN IN
COMPLIANCE WITH LOCAL REGULATIONS. DISCHARGE, TREATMENT, OR DISPOSAL MAY BE
SUBJECT TO FEDERAL, STATE OR LOCAL LAWS.
Handling And Storage Precautions: KEEP CONTAINER CLOSED. AVOID BREATHING DUST.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDING.
Other Precautions: KEEP FROM CONTACT WITH OXIDIZING MATERIALS. MINIMIZE DUST
GENERATION & ACCUMULATION. REFER TO PAMPHLET NO. 654. "PREVENTION OF FIRE
AND DUST EXPLOSIONS INTHE CHEMICAL, DYE, PHARMACEUTICAL AND PLASTICS
INDUSTRIES." USE ADEQUATE VENTILATION.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: WATER SPRAY, CARBON DIOXIDE (CO2), DRY CHEMICAL.
Fire Fighting Procedures: NONE
Unusual Fire/Explosion Hazard: TONER MATERIAL, LIKE MOST ORGAIC MATERIAL IN
POWDER FORM, IS CAPABLE OF CREATING A DUST EXPLOSION.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED WHEN USED IN INTENDED FASHION.
Ventilation: GOOD VENTILATION (TYPICALLY 4-6 ROOM VOLUMES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD E MATCHED TO CONDITIONS.
Protective Gloves: IMPERVIOUS
Eye Protection: IT IS GOOD INDUSTRIAL HYGIENE PRATICE TO MINIMIZE EYE CONTACT.
Other Protective Equipment: WASHING FACILITIES.
Work Hygienic Practices: GOOD INDUSTRIAL HYGIENE PRACTICE SHOILD BE FOLLOWED
WHICH INCLUDES PREVENTIN EYE CONTACT, MINIMIZING SKIN CONTACT, INHALATION.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
M.P/F.P Text: 100 - 150 F
Spec Gravity: 1.4-1.6
Evaporation Rate & Reference: NEGLIGIBLE
Solubility in Water: NEGLIGIBLE
Appearance and Odor: BLACK, SOLD FINE POWDER, SLIGHT PLASTIC ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: COMBUSTION WILL PRODUCE CARBON DIOXIDE AND
POSSIBLY TOXIC CHEMICALS SUCH AS CARBON MONXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR
=======================================================
Toxicological Information
=======================================================
Toxicological Information: THE RESULTS OF ONE ANIMAL STUDY WHERE RATS INHALED
TONER THAT WAS TEN TIMES MORE RESPIRABLE THAN COMMERCIALLY AVAILBLE TONER
WERE OBSERVED TO HAVE NO LUNG CHANGES AT LOW EXPOSURES (THE MOST RELEVANT L
EVEL TO POTENTIAL HUMAN EXPOSURES). AT HIGHER LEVELS A SLIGHT DEGREE OF LUNG
FIBROSIS WAS OBSERVED DUE TO EXCESSIVE AMOUNTS OF DUST RETAINED IN THE LUNG
FOR A PROLONGED INTERVAL. MUTAGENICITY: SALMONE LLA TYPHIMURIUM ASSAY (AMES
TEST): NEGATIVE.
=======================================================
Ecological Information
=======================================================
Ecological: THIS MATERIAL HAS NOT BEEN TESTED FOR ENVIRONMENTAL EFFECTS. IN A
SPILL SITUATION THIS MATERIAL MAY BE VISUALLY UNPLESANT; HOWEVER, IT IS NOT
EXPECTED TO CAUSE ANY ADVERSE ENVIRONMENTAL EFFECTS.
=======================================================
MSDS Transport Information
=======================================================
Transport Information: D.O.T SHIPPING NAME: NOT REGULATED.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: NONE
Federal Regulatory Information: NONE
State Regulatory Information: NONE
=======================================================
Other Information
=======================================================
Other Information: U.S./CANADA LABEL STATEMENT: LOW HAZARD FOR RECOMMENDED
HANDLING. MINIMIZE DUST GENERATION AND ACCUMULATION. USE WITH ADEQUATE
VENTILATION.
=======================================================
Transportation Information
=======================================================
Trans ID NO: 147482
MSDS NAME: A-30 CARTRIDGE TONER BLACK
MSDS Prepared Date: 09/01/1997
Review Date: 08/23/1999
Multiple KIT Number: 0
Unit Of Issue: EA
Container QTY: 0
Type Of Container: UNKNOWN
Additional Data: PC CARTRIDGE ASSEMBLY COMPOSED OF A PHOTO-SENSITIVE DRUM,
TONER POWDER, DEVELOPER UNIT, CORONA UNIT AND CLEANER BLADE. TONER POWDER IS
NOT ACCESSIBLE, UNLESS THE CARTRIDGE IS FORCED OR BROKEN.
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: A-30 CARTRIDGE TONER BLACK
Assigned IND: Y
Company: CANON INC
Street: 30-2 SHIMOMARUKO 3-CHOME, OHTA-KU
City: TOKYO NK
Zipcode: 00000
Country: JA
Health Emergency Phone: (800)424-9300
Label Required IND: Y
Date Of Label Review: 08/23/1999
Status Code: A
Year Procured: 1999
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Health Hazard: None
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: CHRONIC-BASED UPON AVAILABLE DATA, HUMAN EXPOSURE TO
TONER HAS BEEN SHOWN TO CAUSE MINIMAL RESPIRATORY TRACT IRRITATION AS MAY
OCCUR WITH LARGE AMOUNTS OF ANY NONTOXIC DUSTS.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.