===================== Product Identification =====================
MSDS NAME:DOW CORNING (R) Q4-2817 FLUOROSILICONE SEAL
NIIN:01-244-4372
MSDS Number: BKKHH
=== Responsible Party ===
Company:DOW CORNING CORP
Address:3901 SOUTH SAGINAW ROAD
Box:997
City:MIDLAND
State:MI
ZIP:48686
Country:US
Info Phone Num:517-496-6000/6315/8577 (DISP/TRANS)
Emergency Phone Num:517-496-5900/800-424-9300(CHEMTREC)
Preparer's Name:JACK L. SHENEBERGER
CAGE:5D028
=== Contractor Identification ===
Company:DOW CORNING CORP
Address:3901 S SAGINAW RD
Box:997
City:MIDLAND
State:MI
ZIP:48686-0997
Country:US
Phone:517-496-6000/517-496-6315
CAGE:5D028
Company:DOW CORNING CORP
Address:2200 W SALZBURG RD
Box:City:AUBURN
State:MI
ZIP:48611
Country:US
Phone:517-496-4388
CAGE:71984
============= Composition/Information on Ingredients =============
Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE/SKIN:IRRITATION. INHALE: VAPOR
OVEREXPOSURE MAY IRRITATE EYES, NOSE & THROAT. INGEST: SMALL AMTS
TAKEN BY MOUTH ON FINGERS DURING USE, ETC, SHOULD NOT INJURE.
SWALLOWING LARGE AMTS MAY INJURE SERI OUSLY. NO KNOWN ADVERSE
CHRONIC HEALTH EFFECTS BUT AVOID UNNECESSARY EXPOSURE. NO INJURY
FROM DUST WITH REASONABLE USE.
Effects of Overexposure:EYE: REDNESS, SWELLING, CORNEAL INJURY. IF USE
CREATES RESPIRABLE PATRTICLES, SOME RESPIRATORY SYSTEM INJURY MAY
OCCUR.
Medical Cond Aggravated by Exposure:NO KNOWN MEDICAL CONDITIONS
AGGRAVATED BY EXPOSURE TO THIS PRODUCT. THIS PRODUCT, AS WITH ANY
CHEMICAL, MAY ENHANCE ALLERGIC CONDITIONS ON CERTAIN PEOPLE.
======================= First Aid Measures =======================
Eyes: FLUSH IMMEDIATELY WITH WATER FOR 15 MINUTES. GET
MEDICAL ATTENTION. SKIN: WIPE OFF AND FLUSH WITH WATER. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS. INHALE: REMOVE TO FRESH AIR.
ORAL: GET MEDI CAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>212F,>100C
Lower Limits:ND
Upper Limits:ND
Extinguishing Media:WATER FOG, CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING SHOULD BE WORN IN FIGHTING FIRES INVOLVING
CHEMICALS.
Unusual Fire/Explosion Hazard:TOXIC FLUORINE GASES FORM. EVACUATE AREAN
IN CASE OF OVERHEATING OR FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT MATERIAL TO COLLECT & CONTAIN
FOR SALVAGE/DISPOSAL. USE PROPER EYE PROTECTION (SAFETY GLASSES AS
MIN), & RESPIRATORY PROTECTION UNLESS LOCAL EXHAUST VENTILATION IN
ADEQUATE OR AIR SAMPLI NG DATA SHOW EXPOSURES ARE WITHIN TLV/PEL
LIMITS.
====================== Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 90F. USE CARE/CAUTION.
KEEP CLOSED WHEN NOT IN USE. DO NOT TAKE INTERNALLY. FORMS ACETIC
W/WATER OR HUMIDITY,MAY FORM HIGHLY TOXIC VAPORS
Other Precautions:(TRIFLUOROPROPRIONALDEHYDE) W/TEMP >300F. AVOID
PROLONG BREATHING OF VAPORS. USE ONLY IN AREAS W/SUFFICIENT VENTIL
TO KEEP VAPOR CONCENTRATIONS BELOW EXPOSURE LIMITS. PROVIDE LOCAL
EXHAUST VENTING IF NECESSARY. AVOID CONTACT W/SKIN & EYES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRATORY PROTECTION UNLESS LOCAL EXHAUST
VENTILATION IS ADEQUATE OR AIR SAMPLING DATA SHOWS EXPOSURE LIMITS
ARE WITHIN TLV/PEL GUIDELINES. INHALATION GUIDELINES HAVE NOT BEEN
ESTABLISHED FOR TO XIC VAPORS OF TRIFLUOROPROPRIONALDEHYDE.
Ventilation:LOCAL EXHAUST: MAY BE NEEDED. MECHANICAL (GENERAL):
RECOMMENDED. ONLY USE PRODUCT WITH ADEQUATE VENTILATION.
Eye Protection:SAFETY GLASSES AS A MINIMUM.
Work Hygienic Practices:WASHING AT MEALTIME AND SHIFT END IS ADEQUATE.
REMOVE CONTAMINATED CLOTHES/SHOES WHEN PRACTICAL & CLEAN BEFORE
REUSE.
Supplemental Safety and Health
GOOD PRACTICE REQUIRES THAT GROSS AMOUNTS OF ANY CHEMICAL BE REMOVED
FROM SKIN AS SOON AS PRACTICAL, ESPECIALLY BEFORE EATING OR
SMOKING. DATASHEET PRECAUTIONS ARE FOR ROOM TEMP HANDLING; USE AT
ELEVA TED TEMPS, OR AEROSOL/SPRAY APPLICATION, MAY REQUIRE ADDED
PRECAUTION. AVOID BREATHING VAPORS AND EYE OR SKIN CONTACT.
================== Physical/Chemical Properties ==================
HCC:C3
Boiling Pt:B.P. Text:NA@760MM HG
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NA @ 77F
Vapor Density:NA @ 77F
Spec Gravity:1.8 @ 77F
Evaporation Rate & Reference:NA (ETHER=1)
Solubility in Water:LESS THAN 0.1
Appearance and Odor:ACETIC ACID-LIKE, PASTE, RED
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION.
Stability Condition to Avoid:EXPOSURE TO AIR OR MOISTURE UNTIL READY TO
USE-CAUSES CURING AND ACETIC ACID VAPORS FORM.
Hazardous Decomposition Products:IRON OXIDES, FLUORINE COMPOUNDS,
SILICONE DIOXIDE, CARBON DIOXIDE AND TRACES OF INCOMPLETELY BURNED
CARBON PRODUCTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:REVIEW ALL FEDERAL, STATE AND LOCAL REGULATIONS
CONCERNING HEALTH AND POLLUTION TO DETERMINE APPROVED DISPOSAL
PROCEDURES.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|