aromatic hydrocarbon. vp: 5 octylphenoxypolyethoxyethanol (non-ionic surfactant) efts of overexp: consciousness. causes eye corr & perm ing 6: irrit. rptd/prlngd liq cont may cause skin irrit & ing 7: naus & loss of consciousness. rpts have assoc rptd & ing 8: (ing 5) cont may cause skin irrit w/discomfort/rash. ing 9: baking temps. baking ovens must be properly vent. at ing 10: fluoride can be evolved; amts incr as temp incr. ing 11: irrit (3 ppm ceiling - acgih). high conc can cause ing 12: particularly sensitive to dmg by hf & attn must be ing 13: metals reported in ients section, if any. fluoropolymer solids msds toxicity property">
ethanol,2,2',2"-nitrilotri- (triethanolamine). vp: 0.01 aromatic hydrocarbon. vp: 5 octylphenoxypolyethoxyethanol (non-ionic surfactant) efts of overexp: consciousness. causes eye corr & perm ing 6: irrit. rptd/prlngd liq cont may cause skin irrit & ing 7: naus & loss of consciousness. rpts have assoc rptd & ing 8: (ing 5) cont may cause skin irrit w/discomfort/rash. ing 9: baking temps. baking ovens must be properly vent. at ing 10: fluoride can be evolved; amts incr as temp incr. ing 11: irrit (3 ppm ceiling - acgih). high conc can cause ing 12: particularly sensitive to dmg by hf & attn must be ing 13: metals reported in ients section, if any. fluoropolymer solids msds toxicity property">
MSDS
:
TEFLON TOPCOATS (455-160)
CAS
:
112-34-5 102-71-6 64742-95-6
NAME
:
ethanol, 2-(2-butoxyethoxy)-. vp: 0.01. ethanol,2,2',2"-nitrilotri- (triethanolamine). vp: 0.01 aromatic hydrocarbon. vp: 5 octylphenoxypolyethoxyethanol (non-ionic surfactant) efts of overexp: consciousness. causes eye corr & perm ing 6: irrit. rptd/prlngd liq cont may cause skin irrit & ing 7: naus & loss of consciousness. rpts have assoc rptd & ing 8: (ing 5) cont may cause skin irrit w/discomfort/rash. ing 9: baking temps. baking ovens must be properly vent. at ing 10: fluoride can be evolved; amts incr as temp incr. ing 11: irrit (3 ppm ceiling - acgih). high conc can cause ing 12: particularly sensitive to dmg by hf & attn must be ing 13: metals reported in ients section, if any. fluoropolymer solids
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL: NORMALLY NOT A HAZ. THESE PRODS
CONTAIN SM AMTS OF SOLV AS DESCRIBED BELOW. SKIN/EYE: MAY CAUSE
IRRIT/BURNING OF EYES. RPTD/PRLNGD LIQ CONT MAY CAUSE SKIN IRRIT
W/DISCOMFORT & DERMAT. OTHER POT ENTIAL HAZ INCL: (ING 1) SEE HAZ
DECOMPPRODS. (ING 2) MAY CAUSE EYE IRRIT W/DISCOMFORT, TEARING (SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:NONE.
Effects of Overexposure:HLTH HAZ: OR BLURRED VISION. CONT MAY CAUSE
SKIN IRRIT W/DISCOMFORT/RASH. CAN BE ABSORBED THRU SKIN IN HARMFUL
AMTS. MAY CAUSE ABNORMAL KIDNEY FUNC. (ING 3) OVEREXP MAY CAUSE
EYE, NOSE & THROAT IRRIT. RPTD/PRLNGD LIQ CONT MAY CAUSE SKIN
IRRIT & DERMAT. MAY CAUSE CNS EFTS SUCH AS DIZZ, HDCH, NAUS & LOSS
OF (SEE ING 6)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: IF AFFECTED BY INHAL OF VAP/SPRAY MIST, REMOVE TO
FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP, PREF MOUTH-TO-MOUTH. IF
BRTHG DIFFICULTY PERSISTS/OCCURS LATER, CALL MD. SKIN/EYE: EYE:
IMMED FLUSH W/ PLENTY OF WATER FOR AT LEAST 15 MIN; CALL MD. SKIN:
WASH W/SOAP & WATER. IF IRRIT OCCURS, CALL MD. INGEST: GI DISTRESS.
IN UNLIKELY EVENT OF INGEST, CALL MD IMMED & HAVE NAMES OF INGRED
AVAIL.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
WATER FROM FOG NOZZLES MAY BE USED TO COOL CLSD CNTNRS TO PVNT
PRESS BUILD-UP.
Unusual Fire/Explosion Hazard:HYDROGEN FLUORIDE IS RELEASED DURING A
FIRE.
Spill Release Procedures:VENT AREA. REMOVE SOURCES OF IGNIT. AVOID SKIN
CONT & BRTHG OF VAPOR. CONFINE & REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:OBSERVE LABEL PREC. KEEP AWAY FROM
HEAT, SPARKS & FLAME. CLOSE CNTNR AFTER EACH USE. GROUND CNTNRS
WHEN POURING. DO NOT STORE ABOVE 120F.
Other Precautions:EXPLOS RXN MAY OCCUR ABOVE 796F WITH FINELY DIVIDED
FLUOROCARBON & METAL POWDER (ALUMINUM/MAGNESIUM). OPERATIONS SUCH
AS GRINDING, BUFFING/GRIT BLASTING MAY GENERATE SUCH MIXTURES. KEEP
WET. USE ADEQU ATE VENTILATION TO CONTROL.
Respiratory Protection:DO NOT BREATHE VAP/MISTS. WEAR A PROPERLY FITTED
NIOSH/MSHA APPRVD VAPOR/PARTICULATE RESP FOR USE W/PAINTS DURING
APPLICATN & UNTIL ALL VAPS & SPRAY MIST ARE EXHAUSTED. FOLLOW RESP
MFR DIRECTIONS FOR RESP USE.
Ventilation:PROVIDE SUFFICIENT VENT IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING AND SMOKING.
Supplemental Safety and Health
% VOLAT: 46.3-49.1 (WT) HAZ DECOMP PRODS: THESE SYMP DO NOT ORDINARILY
OCCUR UNTIL SEV HRS AFTER EXPOS & PASS WITHIN 36-48 HRS. EFTS ARE
NOT CUMULATIVE. EXPOS USUALLY RESULTS FROM SMOKING TOBACCO/CIGA
RETTES CONTAM W/FLUOROCARBON DURING HANDLING/FROM BRTHG VAPS
EMITTED DURING BAKING. DO NOT EXCEED REC (SEE ING 9)
HCC:N1
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:APPRECIABLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:EXPOS TO TEFLON DECOMP PRODS CAN
CREATE INFLUENZA-LIKE SYMP, COMMONLY REFERRED TO AS POLYMER FUME
FEVER. (SEE SUPP DATA)
Waste Disposal Methods:DO NOT ALLOW MATL TO CONTAM GROUND WATER
SYSTEMS. SEND TO HAZ WASTE WATER TREATMENT PLANT/INCINERATE
ABSORBED MATL IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REQUIREMENTS. DO NOT INCINERATE IN CLSD C NTNRS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.