===================== Product Identification =====================
MSDS NAME:TUB FAS CONTACT BOND CEMENT 82-40
NIIN:00N006715
MSDS Number: BCNKZ
=== Responsible Party ===
Company:H.B. FULLER COMPANY-FOSTER PRODUCTS DIVISION
Emergency Phone Num:713-926-3125
CAGE:9R359
=== Contractor Identification ===
Company:H.B. FULLER COMPANY-FOSTER PRODUCTS DIVISION
CAGE:9R359
============= Composition/Information on Ingredients =============
Name:METHYLENE CHLORIDE (SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 83%
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:MILD NARCOTIC.EFTS INCLUDE
HDACH,GIDDINESS,STUPOR,IRRITABILITY,NUMBNESS + TINGLING IN LIMBS.
======================= First Aid Measures =======================
Eyes:FLUSH W/PLENTY OF H*2O FOR @ LEAST 15 MIN.SEE DR IF
IRRIT PERSISTS.SKIN:WASH W/SOAP + H*2O.APPLY LANOLIN SKIN
LOTION.RMV + WASH CONTAM CLTHG BEFORE REUSE.INHAL:RMV TO FRESH
AIR.KEEP WARM,QUIET.CA LL DR.GIVE ARTF RESP IF NECESSARY.(SEE SUPP
DATA)
===================== Fire Fighting Measures =====================
Flash Point:NONE TO BOILING
Extinguishing Media:CO*2, FOAM, DRY CHEMICAL
Fire Fighting Procedures:NOT CONSIDERED FLAMMABLE UNDER NORMAL
CONDITIONS.
Unusual Fire/Explosion Hazard:PROT AGAINST THERMAL DECOMP
PROD-HCL,CHLORINE,HYDROCARBONS,PHOSGENE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. WEAR RUBBER GLOVES + WIPE UP
W/ABSORBENT MATL. IF NEEDED WEAR SCBA.
====================== Handling and Storage ======================
Handling and Storage Precautions:CAUTION.HANDLE W/CARE.AVOID BREATHING
VAP.HARMFUL IF SWALLOWED.AVOID CONT W/SKIN + EYES.CLOSED CNTNR
AFTER USE + STORE IN COOL AREA.
Other Precautions:OVER EXPOSURE TO CHLORINATED SOLVENT,ESPECIALLY
W/ANOXIA,MAY TEMP INCREASE CARDIAC IRRITABILITY.PRACTICE GOOD
PERSONAL HYGIENE.KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT REQUIRED(MFR).
Ventilation:LOCAL EXHAUST/GENL DILUTION OF SUF VOL TO KEEP BELOW TLV.
Protective Gloves:IMPERVIOUS GLVS
Eye Protection:CHEM SPLASH GOGGLES.
Other Protective Equipment:EYE WASH,SAFETY SHOWER.NORMAL INDUSTRIAL
WORK CLOTHES.
Supplemental Safety and Health
VAP DENSITY: HEAVIER THAN AIR. EMER + FIRST AID PROC: INGEST- DILUTE
W/MILK OR H*2O.DO NOT INDUCE VOMIT.NO SPECIFIC ANTIDOTE KNOWN.CALL
DR.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:104F+, 40C+
Spec Gravity:1.3101
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:83
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:THERMAL DECOMP PROD
HYDROCARBONS,HCL,CO,CO*2,PHOSGENE,CL.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR LANDFILL IAW FEDERAL,STATE + LOCAL
REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|