===================== Product Identification =====================
MSDS NAME:03801 UTILITY YELLOW UPSIDE DOWN MARKING PAINTS-2 WATER BASE
NIIN:00F053053
MSDS Number: CDQZD
=== Responsible Party ===
Company:SHERWIN WILLIAMS CO THE SPECIALTY DIV
Address:31500 SOLON ROAD
City:SOLON
State:OH
ZIP:44139-5000
Country:US
Info Phone Num:800-777-2966/800-247-3266
Emergency Phone Num:800-777-2966/216-292-7400
CAGE:54626
=== Contractor Identification ===
Company:SHERWIN WILLIAMS COMPANY
Address:101 PROSPECT AVE NW
City:CLEVELAND
State:OH
ZIP:44115
Country:US
Phone:216-566-2902
CAGE:54626
Company:SHERWIN-WILLIAMS DIVERSIFIED BRANDS, INC.
Address:26300 FARGO AVENUE
Box:City:BEDFORD HEIGHTS
State:OH
ZIP:44146
Country:US
Phone:216-292-7400 OR 216-595-8634
CAGE:09800
============= Composition/Information on Ingredients =============
Name:CARBONIC ACID, CALCIUM SALT (1:1), CALCIUM CARBONATE,
DURAMITE * 96-4 *
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 6%
Other REC Limits:10 MG/CUM (DUST)
Name:PROPANE (DIMETHYLMETHANE) *96-4*
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 14%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT
Name:HEXANE, N-HEXANE *96-4*
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 14%
Other REC Limits:50 PPM
OSHA PEL:1800 MG/CUM
ACGIH TLV:176 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Name:V M & P NAPHTHA, LIGROINE, MINERAL SPIRITS *96-4*
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 3%
Other REC Limits:STEL 400 PPM
ACGIH TLV:300 PPM
Name:TOLUENE (IARC CARC- GROUP 3) *96-4*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 13%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-4*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:ISOPROPYL ACETATE * 96-4 *
CAS:108-21-4
RTECS #:AI4930000
Fraction by Wt: 1%
Other REC Limits:250 PPM
OSHA PEL:250 PPM
ACGIH TLV:1040 MG/CUM
Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE *96-4*
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 6%
OSHA PEL:2 MG/CUM (RESP DUST)
ACGIH TLV:2 MG/CUM (RESP DUST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN & RESPIRATORY
SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION, DEATH. HEXANE: MAY
CAUSE DAMAGE TO NERVE TISSUE OF THE ARMS & LEGS. PROLONGED
OVEREXPOSURE TO SOLVENTS MAY CAUSE ADV ERSE EFFECTS TO THE LIVER,
URINARY, BLOOD-FORMING, CARDIOVASCULAR & REPRODUCTIVE SYSTEMS. (SEE
SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, UNCONSCIOUSNESS, HEADACHE,
DIZZINESS, NAUSEA, LOSS OF COORDINATION, REDNESS, ITCHING, BURNING.
HEXANE: MUSCULAR WEAKNESS, LOSS OF SENSATION.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM & QUIET. SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: FLUSH
W/LARGE AMOUNTS OF WATER FOR 15 MINS. INGESTION: NEVER GIVE
ANYTHING BY MOUTH IF UNCONSCIOUS. DON'T INDUCE VOMITING GIVE
SEVERAL GLASSES OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F
Lower Limits:0.7
Upper Limits:12.8
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIPMENT & SCBA. WATER
SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERRED. WATER MAY BE USED TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. VAPORS WILL ACCUMULATE READILY & IGNITE
EXPLOSIVELY. HEAT/IGNITION COULD CAUSE CONTAINERS TO BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT/SPARKS/OPEN FLAME
& OTHER IGNITION SOURCES. USE APPROVED BONDING/GROUNDING
PROCEDURES. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DON'T PUNCTURE, INCINERATE/EXPOSE TO TEMPS >120F.
DURING USE & UNTIL ALL VAPORS ARE GONE; KEEP AREA VENTILATED. DON'T
SMOKE. DON'T TAKE INTERNALLY. AVOID BREATHING VAPOR/SPRAY MIST.
AVOID CONTACT W/SK IN & EYES. USE W/ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE CAN'T BE CONTROLLED 1
Volatile Org Content %:47
Evaporation Rate & Reference:FASTER THAN ETHER
Percent Volatiles by Volume:>75
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
PILOT LIGHTS, ELECTRIC TOOLS/APPLIANCES, RADIATORS, STOVES, HOT WATER
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, ELECTRICAL
EQUIPMENT, TEMPS >120F, SUNLIGHT & OTHER IGNITION SOURCES
Hazardous Decomposition Products:BY FIRE: CO, CO2, OXIDES OF METALS
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MUST BE TESTED FOR IGNITABILITY TO
DETERMINE THE EPA HAZARDOUS WASTE NUMBERS. WASTE MUST BE TREATED
FOR EXTRACTABILITY. DON'T INCINERATE. DEPRESSURIZE CONTAINER.
DISPOSE OF IAW/LOCAL, STATE & FE DERAL REGULATIONS.
======================= Other Information =======================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|