===================== Product Identification =====================
MSDS NAME:BROWNELLS T.F.E. DRY LUBE & MOLD RELEASE, 083056016
NIIN:00N091083
Status Code:A
MSDS Number: CJFZT
=== Responsible Party ===
Company:BROWNELLS INC
Address:200 SO. FRONT ST
City:MONTEZUMA
State:IA
ZIP:50171
Country:US
Info Phone Num:515-623-5401
Emergency Phone Num:800-457-4280
Resp. Party Other MSDS Num.:190
CAGE:12238
=== Contractor Identification ===
Company:BROWNELLS INC
Address:200 SO. FRONT ST
Box:City:MONTEZUMA
State:IA
ZIP:50171
Country:US
Phone:515-623-5401
CAGE:12238
============= Composition/Information on Ingredients =============
Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
= Wt:12.
OSHA PEL:1800 MG/M3;1000 PPM
Name:2-METHYLPROPANE
CAS:75-28-5
RTECS #:TI4300000
= Wt:15.
Name:HEPTANE
CAS:142-82-5
RTECS #:MI7700000
= Wt:60.
OSHA PEL:2000 MG/M3;500 PPM
ACGIH TLV:1640 MG/M3;400 PPM
ACGIH STEL:2050 MG/M3;500 PPM
Name:2-PROPANOL
CAS:67-63-0
RTECS #:NT8050000
= Wt:11.
OSHA PEL:980 MG/M3;400 PPM
ACGIH TLV:983 MG/M3;400 PPM
ACGIH STEL:1230 MG/M3;500 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERV SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
POSSIBLY DEATH. HEADACHE, DIZZ, NAUS, & LOSS OF COORDINATION ARE
INDICATIONS OF EXCESS EXPOS TO V APS OR SPRAY MISTS. REDNESS &
ITCHING OR BURNING SENSATION MAY INDICATE EYE OR EXCESS SKIN
EXPOSURE. CHRONIC: NO INGRED IN THIS PROD IS IARC, NTP/OSHA LISTED
CARCINOGEN. PRLNGD OVEREXP TO SOLV INGREDS MAY CAUSE ADVERSE EFTS
TO LIVER & URINARY SYSTEMS. RPTS HAVE ASSOC RPTD & PRLNGD OVEREXP
TO SOLVENTS W/PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE FROM EXPOSURE. RESTORE BRTHG. KEEP WARM & QUIET.
SKIN: WASH AREA THOROUGHLY W/SOAP & WATER. REMOVE CONTAMD CLTHG &
LAUNDER BEFORE REUSE. EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR AT
LEAST 1 5 MINUTES. CONSULT PHYS. INGEST: NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON. CONSULT PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:<-17.8C, 0.F
Lower Limits:1.1%
Upper Limits:12.7%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL. FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG
NOZZLES ARE PREFERABLE. WATER MAY BE USED TO COOL CLOSED CONTAINERS
TO PREVENT PRESS B UILDUP & POSSIBLE AUTOIGNITION/EXPLOSION WHEN
EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELECTRICAL EQUIP, SPKS
& OEPN FLAME. CLOSED CNTNRS MAY EXPLODE WHEN EXPOSED TO EXTREME
HEAT. APPLICATION TO HOT SURFACES REQS SPEC PRECAUTIONS. DURING
EMER CONDITIONS OVEREXP TO DEC OMPOSITION PRODS MAY CAUSE A HEALTH
HAZARD. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MEDICAL ATTENTION.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPKS & OPEN
FLAME. VAPS WILL ACCUM READILY & MAY IGNITE EXPLOSIVELY. DURING USE
& UNTIL ALL VAPS ARE GONE; KEEP AREA VENTILATED DO NOT SMOKE.
EXTING ALL FLAMES, PILOT LIGHTS & HEA TERS - TURN OFF STOVES, ELEC
TOOLS & APPLIANCES & ANY OTHER SOURCES OF IGNIT. CONSULT NFPA CODE.
Other Precautions:USE APPRVD BONDING & GROUNDING PROCEDURES. CONTENTS
UNDER PRESS. DO NOT PUNCTURE, INCIN/EXPOS TO TEMP >120D.F. HEAT
FROM SUNLIGHT, RADIATORS, STOVES, HOT WATER & OTHER HEAT SOURCES
COULD CAUSE CNTNR T O BURST. DO NOT TAKE INTERNALLY. KEEP OUT OF
REACH OF CHILDREN. INTENTIONAL MISUSE BY DELIB (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENT, WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH FOR PROTECTION
AGAINST MATERIALS IN INGREDIENT SECTION.
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOSURE TO MATLS
IN INGRED SECTION IS MAINTAINED BELOW APPLICABLE (SUPDAT)
Protective Gloves:NONE REQD FOR NORM APPLIC OF AEROSOL PRODS WHERE
MINIMAL (SUPDAT)
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
OTHER PREC: CONC & INHALING CONTENTS CAN BE HARMFUL/ FATAL. VENT: EXPOS
LIMITS. REFER TO OSHA STDS 1910.94, 1910.107, 1910.108. USE ONLY
W/ADEQ VENT. AVOID BRTHG VAP & SPRAY MIST. AVOID CONT W/SKIN &
EYES. PROT GLOVES: SKIN CONT IS EXPECTED FOR LONG/RPTD CONT, WEAR
CHEM RESIST GLOVES. IMPERVIOUS GLOVES .
================== Physical/Chemical Properties ==================
Boiling Pt:<-17.8C, 0.F
B.P. Text:<0-212F
Vapor Density:>AIR
Spec Gravity:0.66000 (H*2O =1)
Evaporation Rate & Reference:>ETHER (BUTYL ACETATE =1)
Appearance and Odor:DRY LUBE - AEROSOL LUBRICANT.
Percent Volatiles by Volume:99
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE; CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FRO THIS PRODUCT MAY BE HAZARDOUS AS
DEFINED UNDER RESOURCE CONSERVATION & RECOVERY ACT (RCRA) 40 CFR
261. DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS .
===================== Regulatory Information =====================
Federal Regulatory Information:HMIS RATINGS: HEALTH: 3, FIRE: 4,
REACTIVITY: 0.
======================= Other Information =======================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|