MATERIAL SAFETY DATA SHEET
Page 1 of 4
1. PRODUCT AND COMPANY IDENTIFICATION
NAME: SURPASS/SW
USE: MECHANICAL DISH DETERGENT
MSDS # 101866S
U S CHEMICAL, 316 HART STREET, WATERTOWN, WI 53094 USA
MEDICAL EMERGENCY #: 1-800-851-7145 EXT. 075 USA
SPILL EMERGENCY #: 1-800-424-9300 USA
PRODUCT INFORMATION #: 1-800-558-9566 (8 A.M. TO 5 P.M. CST MONDAY TO FRIDAY)
INTERNET ADDRESS: WWW.USCHEMICAL.COM
REVIEWED 10-16-05 REVISED 10-16-05 SECTION REVISED: 1
2. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW:
DANGER. CORROSIVE TO EYES. CAUSES EYE BURNS. HARMFUL OR FATAL IF SWALLOWED.
PRINCIPLE ROUTES OF EXPOSURE: EYES, SKIN, INGESTION, INHALATION.
POTENTIAL ACUTE HEALTH EFFECTS
EYES: CORROSIVE. CAUSES EYE BURNS. MAY CAUSE PERMANENT DAMAGE INCLUDING BLINDNESS
WITHOUT IMMEDIATE FIRST AID TREATMENT.
SKIN: MAY BE SEVERELY IRRITATING TO SKIN.
INHALATION: DUST MAY CAUSE IRRITATION TO NOSE, THROAT, AND RESPIRATORY SYSTEM.
INGESTION: CORROSIVE. MAY CAUSE BURNS TO MOUTH, THROAT AND STOMACH.
MEDICAL CONDITIONS AGGRAVATED: NONE KNOWN.
3. COMPOSITION / INFORMATION ON INGREDIENTS
% BY WT LC50/LD50
HAZARDOUS INGREDIENT CAS #
SODIUM METASILICATE 6834-92-0 10.0 鈥? 30.0 SEE 11.
SODIUM DICHLORO-S-TRIAZINETRIONE 2893-78-9 1.0 鈥? 5.0 N.AV.
SODIUM CARBONATE 497-19-8 30.0 鈥? 60.0 N.AV.
STATE RIGHT TO KNOW: THIS PRODUCT CONTAINS:
SODIUM CARBONATE/497-19-8, SODIUM METASILICATE/6834-92-0, SODIUM CHLORIDE/7647-14-5,
SODIUM TRIPOLYPHOSPHATE/7758-29-4, SODIUM DICHLORO-S-TRIAZINETRIONE/2893-78-9
SURPASS/SW MSDS # 101866S
462
4. FIRST AID MEASURES Page 2 of 4
EYES: FLOOD WITH LUKEWARM (NOT HOT) WATER POURED FROM A LARGE GLASS 2 OR 3
INCHES FROM EYES. REMOVE CONTACTS. HAVE PATIENT BLINK AS MUCH AS POSSIBLE
WHILE FLOODING THE EYES. CONTINUE FOR AT LEAST 15 MINUTES.
SKIN: REMOVE CONTAMINATED CLOTHES, THEN FLOOD WITH WATER FOR 15 MINUTES.
INHALATION: MOVE VICTIM TO FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF PATIENT IS
NOT BREATHING.
INGESTION: DO NOT INDUCE VOMITING. IF PATIENT IS CONSCIOUS AND CAN SWALLOW,
ADMINISTER MILK OR WATER.
ADMINISTER FIRST AID TREATMENT AS STATED ABOVE, THEN CALL 1-800-851-7145 EXT.
075 OR CONTACT PHYSICIAN FOR FURTHER MEDICAL INSTRUCTIONS.
NOTE TO PHYSICIAN: CALL 1-800-851-7145 EXT. 075 FOR ASSISTANCE WITH THE MANAGEMENT OF EXPOSURES.
5. FIRE-FIGHTING MEASURES
FLAMMABILITY: NO HAZARD.
FLASH POINT: N.AP.
PRODUCTS OF COMBUSTION: SEE SECTION 10.
SUITABLE EXTINGUISHING MEDIA: FOR FIRES IN AREA, USE APPROPRIATE MEDIA.
FOR EXAMPLE: WATER SPRAY, DRY CHEMICAL, CARBON DIOXIDE, OR ALCOHOL FOAM.
SPECIFIC HAZARDS: N.AP.
SPECIFIC METHODS: NORMAL FIRE FIGHTING PROCEDURES MAY BE USED.
6. ACCIDENTAL RELEASE MEASURES
PERSONAL PRECAUTIONS: SEE SECTION 8.
SPILL RESPONSE: EVACUATE UNPROTECTED PERSONNEL FROM AREA. WEAR PROPER
PROTECTIVE EQUIPMENT. CAREFULLY SWEEP UP AND SHOVEL INTO DRY CONTAINERS WITHOUT
RAISING DUST. COVER CONTAINERS AND MOVE CONTAINERS OUT OF SPILL AREA. AFTER SPILL
COLLECTION, FLUSH AREA WITH WATER AND FOLLOW WITH NORMAL CLEAN-UP PROCEDURES. BE
CAREFUL AS SPILLS ARE SLIPPERY.
7. HANDLING AND STORAGE
HANDLING: FOLLOW ALL LABEL DIRECTIONS. INSTRUCT PERSONNEL ABOUT
PROPER USE, HAZARDS, PRECAUTIONS, AND FIRST AID MEASURES.
AVOID INGESTION AND CONTACT WITH EYES. DO NOT TASTE OR SWALLOW.
REMOVE AND WASH CONTAMINATED CLOTHING AND FOOTWEAR BEFORE RE-USE.
PRODUCT RESIDUE MAY REMAIN ON OR IN EMPTY CONTAINERS.
HANDLE CAREFULLY TO AVOID DAMAGING CONTAINER.
STORAGE: ROTATE STOCK REGULARLY. KEEP CONTAINER CLOSED WHEN NOT IN USE.
AVOID TEMPERATURES ABOVE 120掳F. STORAGE AT AMBIENT TEMPERATURES IN A DRY
AREA OUT OF DIRECT SUNLIGHT IS RECOMMENDED. KEEP AWAY FROM FOOD AND DRINK.
KEEP OUT OF CHILDREN鈥橲 REACH.
SURPASS/SW MSDS # 101866S
8. EXPOSURE CONTROLS / PERSONAL PROTECTION Page 3 of 4
EXPOSURE LIMITS:
SODIUM DICHLORO-S-TRIAZINETRIONE = 0.5 PPM TWA AS CHLORINE, 1 PPM STEL AS CHLORINE (ACGIH),
1 PPM CEILING LIMIT (OSHA)
ENGINEERING CONTROLS: NONE REQUIRED. GENERAL ROOM VENTILATION IS ADEQUATE.
PERSONAL PROTECTION
EYES: SPLASH PROOF SAFEY GLASSES, SAFETY GOGGLES AND AN EYE WASH STATION.
HANDS: CHEMICAL RESISTANT GLOVES: RUBBER OR NEOPRENE.
RESPIRATORY: WEAR DUST MASK IF HANDLING CREATES AIR-BORNE DUST.
FEET: WEAR PROTECTIVE FOOTWEAR DURING SPILL CLEAN-UP.
BODY: IF MAJOR EXPOSURE IS POSSIBLE, WEAR PROTECTIVE CLOTHING.
9. PHYSICAL AND CHEMICAL PROPERTIES
COLOR: WHITE FLASH POINT: N.AP.
ODOR : SLIGHT CHLORINE UEL: N.AP.
pH CONCENTRATE: N.AP. LEL: N.AP.
pH @ 2500 PPM SOLUTION: 11.1 (BASIC) EVAPORATION RATE: N.AP.
pH @ USE DILUTION: N.AV. ODOR THRESHOLD: N.AP
PHYSICAL STATE: GRANULAR POWDER VAPOR PRESSURE: N.AP
SPECIFIC GRAVITY: N.AP. VAPOR DENSITY: N.AP.
VISCOSITY: N.AP. COEFF. OIL/WATER: N.AP.
BOILING POINT: N.AP. WATER SOLUBILITY: MODERATE
MELTING POINT: N.AP. OTHER: N.AP.
10. STABILITY AND REACTIVITY
STABLE: YES
CONDITIONS TO AVOID: AVOID TEMPERATURES ABOVE 120掳F AND HIGH HUMIDITY TO
PREVENT CAKING.
MATERIALS TO AVOID: AVOID MIXING DIRECTLY WITH ANY OTHER CLEANING
PRODUCT. AVOID OXIDIZING AGENTS. MIX ONLY WITH WATER BELOW 150掳F.
DECOMPOSITION PRODUCTS: FIRE OR MIXING WITH INCOMPATIBLE MATERIALS MAY
PRODUCE OXIDES OF CARBON AND OTHER TOXIC OR IRRITATING FUMES.
POSSIBILITY OF HAZARDOUS REACTIONS: AVOID MIXING DIRECTLY WITH ACIDS.
11. TOXICOLOGICAL INFORMATION
ACUTE EFFECTS: SEE SECTION 2.
CHRONIC EFFECTS: NONE KNOWN. NO REPORTABLE CARCINOGENS, MUTAGENS,
SENSITIZERS, SYNERGISTIC MATERIALS, TERATOGENS, OR REPRODUCTIVE TOXINS.
LC50/LD50: N.AV.
TARGET ORGANS: EYES, SKIN, RESPIRATORY SYSTEM.
OTHER TOXIC EFFECTS: NONE KNOWN.
SURPASS/SW MSDS # 101866S
12. ECOLOGICAL INFORMATION Page 4 of 4
NOT AVAILABLE.
13. DISPOSAL CONSIDERATIONS
DISPOSAL METHOD: COMPLY WITH ALL FEDERAL, STATE, PROVINCIAL AND LOCAL
LAWS AND REGULATIONS. CONSULT STATE AND LOCAL AUTHORITIES FOR
RESTRICTIONS ON DISPOSAL OF CHEMICAL WASTE. MANAGE CHEMICAL WASTES
THROUGH AN APPROVED WASTE TREATMENT FACILITY. DO NOT REUSE EMPTY
CONTAINER. RINSE EMPTY CONTAINER THOROUGHLY WITH WATER BEFORE
DISCARDING CONTAINER IN ACCORDANCE WITH CURRENT LOCAL COMMUNITY
CODES. PLEASE RECYCLE EMPTY CONTAINER WHENEVER POSSIBLE.
14. TRANSPORT INFORMATION
DOT/TDG: NOT REGULATED
DOT RQ: N.AP.
DOT ERG #: N.AP.
15. REGULATORY INFORMATION
EPA CERCLA RQ: N.AP.
EPA REGISTERED: NO
EPA %VOC: 0.00
EPA VOC RULE: THIS PRODUCT DOES NOT CONTAIN VOLATILE ORGANIC COMPOUNDS.
KOSHER (CRC): YES
OSHA HAZARDOUS: YES
PHOSPHORUS CONTENT: SEE LABEL
PROPOSITION 65: N.AP.
SARA 311/312 HAZARDS: ACUTE
SARA 313 CHEMICALS: N.AP.
STATE RIGHT TO KNOW: SEE SECTION 3 FOR STATE RTK CHEMICAL NAMES.
TSCA INVENTORY STATUS: ALL COMPONENTS ARE LISTED ON THE INVENTORY.
WHMIS CLASS: D-2B
16. OTHER INFORMATION
NFPA RATING: HEALTH-3/FLAMMABILITY-0/REACTIVITY-0/SPECIAL HAZARD-N.AP.
HMIS RATING: HEALTH-3/FLAMMABILITY-0/REACTIVITY-0/PERSONAL PROTECTION-SEE 8.0
N.AV. = NOT AVAILABLE N.AP. = NOT APPLICABLE PREPARED BY: HEALTH AND SAFETY
NOTICE TO READER
THIS DOCUMENT HAS BEEN PREPARED USING DATA FROM SOURCES CONSIDERED TECHNICALLY
RELIABLE. IT DOES NOT CONSTITUTE A WARRANTY, EXPRESS OR IMPLIED, AS TO THE ACCURACY
OF THE INFORMATION CONTAINED WITHIN. ACTUAL CONDITIONS OF USE AND HANDLING ARE
BEYOND SELLER鈥橲 CONTROL. USER IS RESPONSIBLE FOR EVALUATING ALL AVAILABLE
INFORMATION WHEN USING PRODUCT FOR ANY PARTICULAR USE AND TO COMPLY WITH ALL
FEDERAL, STATE, PROVINCIAL AND LOCAL LAWS AND REGULATIONS.
|