Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: 813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: HIGH TEMPERATURE THREADLOCKER RED 10ML
Item No: 27200
Product Type: Anaerobic
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH TLV: TWA OSHA PEL:
ETHOXYLATED BISPHENOL A 55-75 Not listed Not Listed
DIMETHACRYLATE
24448-20-2
HYDROXYALKYL METHACRYLATE 10-30 Not listed Not Listed
27813-02-1
N,N-M-PHENYLENE DIMALEIMIDE 10-30 Not listed Not Listed
3006-93-7
10 mg/m3 total dust TLV 10 mg/m3 total dust
TREATED SILICON DIOXIDE, <3
SYNTHETIC, CRYSTALLINE-FREE
67762-90-7
DIMETHYLBENZYL <3 Not listed Not Listed
HYDROPEROXIDE
80-15-9
3. HAZARDS IDENTIFICATION
At elevated temperatures may cause irritation of the respiratory tract. Irritates mucous membranes.
Toxicity:
Ingestion may irritate digestive tract and cause nausea, vomiting and diarrhea. High concentrations may
cause central nervous system (CNS) depression. May cause eye and skin irritation. May cause skin
sensitization. Note: This product does not contain microcyrstalline silica.
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
Repeated skin contact may cause allergic skin reactions. Skin redness. Ingestion may cause nausea and
Signs and Symptoms of Exposure:
vomiting. Inhalation overexposure may cause irritation, coughing and flu-like symptoms. May cause pain,
redness or swelling of the eyes and excessive blinking and tear production.
Preexisting skin disorders.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapours. Obtain medical attention.
Inhalation:
Wash off with soap and water. If skin irritation persists, call a physician.
Skin Contact:
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
>200掳F
Flash Point (掳F/C):
Water fog, carbon dioxide, foam, dry chemical.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus. Water spray
Special Fire-Fighting Procedures:
may be ineffective on flames but should be used to keep fire-exposed
containers cool.
Oxides of carbon
Hazardous Products of Combustion:
Closed containers may rupture or explode when exposed to extreme heat.
Unusual Fire/Explosion Hazards:
May polymerize exothermically.
Not determined
Lower Explosive Limit:
Not determined
Upper Explosive Limit:
1 of 3
Product Name: HIGH TEMPERATURE THREADLOCKER Item No: 27200
RED 10ML
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
Spill Procedures:
disposal.
7. HANDLING AND STORAGE
Store in a cool, dry area.
Storage:
Avoid prolonged skin contact. Keep away from eyes.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses
Eyes:
Rubber or plastic gloves.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this
product.
An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Red liquid
Appearance:
MUSTY
Odor:
Not determined
Boiling Point:
Does not apply
pH:
Negligible
Solubility in Water:
1.1 @ 20掳C
Specific Gravity:
<2% by weight
VOC Content(Wt.%):
Not determined
Vapor Pressure:
Heavier than air
Vapor Density (Air=1):
Not determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
MAY OCCUR.
Hazardous Polymerization:
Strong oxidizers, free radical initiators, inert gases, Peroxides, Reducing
Incompatabilities:
agents, Oxygen scavengers
Heat.
Conditions to Avoid:
Oxides of carbon
Hazardous Products of Combustion:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
Unrestricted
DOT Shipping Name:
None
Hazard Class:
None
UN/ID Number:
None
Marine Pollutant:
IATA
Not regulated
Proper Shipping Name:
None
Class or Division:
None
UN/ID Number:
IMDG
2 of 3
Product Name: HIGH TEMPERATURE THREADLOCKER Item No: 27200
RED 10ML
Unrestricted
Proper Shipping:
None
Hazard Class:
None
UN Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
DIMETHYLBENZYL HYDROPEROXIDE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present at or above the No Significant Risk Level.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 1 , REACTIVITY 0.
Estimated NFPA Rating:
HEALTH 2, FLAMMABILITY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Manager-Environmental, Health & Safety
Prepared By: Revision Date: February/06/2008
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 1
Company: Revision
Number:
1-87-Permatex (877) 376-2839
Telephone No.:
3 of 3
|