JSDYL MATERIAL SAFETY DATA SHEET Printed: 07/30/2002
SUMA ALU PAK P9 4X9CS Emergency
Product Name (800)831-9889
I Medical(Collect) (303)592-1024
57242410 UPC-A 774205557057 SCC 10774205557054
Product Code
Chemical Product Chemtree (800)424-9300
Manufacturer JOHNSONDIVERSEY INC.
and Company
3630 E. KEMPER RD Date 06/08/2002
Indentification
CINCINNATI, OH 45241-2046
MECHANICAL WAREWASHING DETERGENT
Chemical Family
Chemical Name of Hazardous Ingredient % Exposure Limits Units
SODIUM METASILICATE 6834-92-0 22 OSHA PEL (C) : 2 MG/M3
ACGIH TLV (C) : 2 MG/M3
II
Composition/
Information
on Ingredients
EYES: SEVERE BURNS, TISSUE DAMAGE, OR IRRITATION WITH
A
PAIN, SWELLING, BLURRED OR IMPAIRED VISION, BLINDNESS.
C
Signs SKIN: SEVERE BURNS, TISSUE DESTRUCTION, BLISTERS OR
U
RASH WITH SWELLING AND PAIN. INGESTION: MAY BE FATAL.
T
and E
SEVERE BURNS TO MOUTH AND THROAT MAY RESULT WITH PAIN,
Symptoms C
of GASTRIC PERFORATION AND DIFFICULTY IN SWALLOWING OR
H
BREATHING. INHALATION: SPRAY OR MISTS CAUSE BURNS OR
R
Exposure
III O SEVERE IRRITATION TO NOSE, THROAT AND RESPIRATORY
N
TRACT WITH PAIN, CHOKING, AND EXPERIENCE DIFFICULTY IN
I
BREATHING. CHRONIC: SAME AS ACUTE EFFECTS.
C
Hazards
Health 3
Identification HMIS: Flammability 0 Reactivity 1 Personal Protection B
Conditions Aggravated DERMATITIS OR SENSITIVE SKIN.
Carcinogen Info NONE NTP IARC OSHA
Target Organs or System EYES, SKIN, MOUTH AND ESOPHAGUS.
Routes of Exposure: Inhalation x Skin x Ingestion x
REMOVE TO FRESH AIR AND SEEK MEDICAL ATTENTION.
Inhalation
INGESTION CONT:
NEVER GIVE FLUIDS BY MOUTH TO AN UNCONSCIOUS PERSON.
IV Eyes IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MIN.
HOLD EYELIDS APART TO COMPLETELY FLUSH ALL CHEMICALS FROM ENTIRE
EYE SURFACE. GET IMMEDIATE MEDICAL ATTENTION.
First Aid Measures FLUSH THOROUGHLY WITH PLENTY OF WATER. WASH WITH MILD SOAP AND
Skin
WATER. REMOVE CONTAMINATED CLOTHES AND SHOES AND CLEAN BEFORE
REUSE. GET MEDICAL ATTENTION FOR ANY PAINFUL, RED OR INJURED SKIN
Ingestion IF SWALLOWED, RINSE MOUTH WITH WATER. DILUTE BY DRINKING SEVERAL
GLASSES OF WATER. DO NOT INDUCE VOMITING: IF PATIENT VOMITS, RE
RINSE MOUTH. GET IMMEDIATE MEDICAL ATTENTION.
WEAR FULL PROTECTIVE GEAR AND POSITIVE PRESSURE BREATHING
Fire Control
APPARATUS (SCBA) IN FIRE AREA.
Measures/
Equipment
V
Flammable Property Info NONE
Fire Fighting
NONE KNOWN.
Explosion Info
Measures
Extinguishing Media WATER, WATER SPRAY, CO2, FOAM OR DRY POWDER.
NONE
Gases
JohnsonDiversey Material Safety Data Sheet: SUMA ALU PAK P9 4X9CS - 57242410 1 of 2
Institutional
Spill and CONTAIN SPILL. WEAR PROTECTIVE CLOTHING. SOAK UP OR ABSORB LIQUID
ON SUITABLE ABSORBENT MATERIAL. COLLECT AND PLACE IN CHEMICAL
Leak
VI WASTE CONTAINER. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
Clean UP
FEDERAL REGULATIONS. FLUSH SPILL AREA WITH WATER.
Procedures
Accidental Measures THIS PRODUCT DOES NOT CONTAIN A REPORTABLE QUANTITY (RQ) UNDER
CERCLA.
Environmental Precautions
Ventilation Required? NONE Instructions NONE REQUIRED.
Safe Storage, WEAR PROTECTIVE GEAR WHEN USING OR HANDLING. PRODUCT FREEZES
VII Handling BELOW 50 DEG.F. THAW BY WARMING TO 70 DEG.F & MIX FOR USE. ADD
and Use PRODUCT SLOWLY WITH MIXING TO WATER OR LIQ.TO AVOID HEAT. DO NOT
Handling and
Instructions LET PRODUCT COLLECT ON BOTTOM OF TANK & DO NOT PRESSURE TO EMPTY.
Storage
Imcompatible Materials ACIDS
ALKALI RESISTENT.
Protective Gloves
CHEMICAL GOGGLES IF CONTACT OR SPLASH HAZARD EXISTS.
VIII Eye Protection
Respiratory USE NIOSH/MSHA APPROVED RESPIRATOR WHERE TLV/PEL MAY BE EXCEEDED.
Exposure Controls/
Protection
Personal Protection
Other Protective RUBBER BOOTS & CHEMICAL RESISTANT APRON IF CONTACT OR SPLASH HZRD
EXISTS. EYEWASH & SAFETY SHOWER IN AREA IF CONTACT OR SPLASH EXIS
Clothing Equipment
Characteristics o of Hazardous Chemcial
Vapor Pressure N/A MmHg@ NA 掳C Vapor Density(Air=1) N/A pH N/A Water Solubility SOL %
IX Appearance & Odor WHITE POWDER, CHLORINE ODOR.
Physical and Chemical Boiling Point 掳F Melting Point 掳F Flammability Limits in Air By Volume: Upper N/A Lower N/A
N/A
Properties Flash Point NONE 掳F Auto Ignition 掳F Oxidizing Properties
Specific Gravity 1.07 Volatile by Volume N/A %
Evaporation Rate(n-Butyl Acetate=1)
Peroxide, Pyrophoric, Unstable or Water Reactive STABLE
Reactivity and Hazardous Polymerization NONE KNOWN.
X Possible Hazardous Reactions NONE
Conditions to Avoid NONE
Stability and
Materials ACIDS
Reactivity
To Avoid
Hazardous INCOMPLETE COMBUSTION FORMS; HYDROGEN CHLORIDE; CHLORINE AND
Decomposition Products CHLORINATED COMPOUNDS; OXIDES OF PHOSPHORUS.
XI NO DATA AVAILABLE.
Toxicological Information
XII Possible Effects and Environmental Fate NO DATA AVAILABLE
Ecological Degradability
Information Aquatic Toxicity
Method of ADJUST PH OF DILUTED PRODUCT AND DISCHARGE TO INDUSTRIAL SEWER IN
ACCORDANCE WITH DISCHARGE PERMIT OR LOCAL POTW REGULATIONS. USE
Disposal,
PRODUCT IN CONTAINER UNTIL EMPTY. TRIPLE RINSE CONTAINER WITH
Residues and WATER AND ADD TO PROCESS. RECYCLE OR DISPOSE OF CONTAINER ACCORD-
XIII Safe ING TO PRODUCT LABELING OR FEDERAL, STATE OR LOCAL REGULATIONS.
Handling
Disposal
Consideration
INCOMPLETE COMBUSTION FORMS; HYDROGEN CHLORIDE; CHLORINE AND
Disposal of
Contaminated Material CHLORINATED COMPOUNDS; OXIDES OF PHOSPHORUS.
DISODIUM TRIOXOSILICATE, MIXTURE, CLASS 8, UN3253, PG III, NAERG NO. 154.
XIV
Transport Information
XV-Regulatory Information
XVI-Other Information
NONE
S.A.R.A.
Title III
Section 313
SODIUM CARBONATE - CAS #497-19-8
State
SODIUM TRIPOLYPHOSPHATE - CAS #7758-29-4
Right to Know NONIONIC SURFACTANT - CAS #9003-11-6
Information SODIUM METASILICATE - CAS #6834-92-0
SODIUM DICHLOROISOCYANURATE - CAS #2893-78-9
JohnsonDiversey Material Safety Data Sheet: SUMA ALU PAK P9 4X9CS - 57242410 2 of 2
Institutional
|