|
Page 1
MATERIAL SAFETY DATA SHEET
Printed: 4/4/07
N-BUTYLDIETHANOLAMINE
PRODUCT IDENTIFICATION AND USE
MANUFACTURER: ARKEMA CANADA INC.
700 THIRD LINE
OAKVILLE, ONTARIO
L6J 5A3
EMERGENCY PHONE NUMBER: (905) 827-9841 (ARKEMA)
(613) 996-6666 (CANUTEC)
PRODUCT IDENTIFIER: N-BUTYLDIETHANOLAMINE
PRODUCT CODE: ORG001029
PRODUCT USE: NA
WHMIS CLASSIFICATION: D2B 鈥? TOXIC MATERIAL CAUSING OTHER TOXIC EFFECTS.
HAZARDOUS INGREDIENTS
%W/W CAS # TLV
N-BUTYLDIETHANOLAMINE 99% 102-79-4 NE
LD50: 4,250 MG/KG (ORAL-RAT)
LD50: >2,000 MG/KG (DERMAL-RABBIT)
LC50: > SATURATED VAPOUR CONCENTRATION
(8 HR INHALATION RATS)
ADDITIONAL INGREDIENT INFORMATION (WHMIS NOT CONTROLLED):
NA
PHYSICAL DATA
PHYSICAL STATE: LIQUID
ODOUR AND APPEARANCE: YELLOW LIQUID WITH AMINE ODOUR.
ODOUR THRESHOLD: NE
SPECIFIC GRAVITY/DENSITY (G/ML): 0.97 @ 20掳C
VAPOUR PRESSURE: <0.1 MM @ 20掳C
VAPOUR DENSITY (AIR=1): 5.5 KG/M3
VOLATILITY/VOL(%): 100
SOLUBILITY IN H20: COMPLETELY SOLUBLE @ 20掳C
EVAPORATION RATE: NE
BOILING POINT: 274 掳C
FREEZING POINT: -70掳C (-94掳F)
PH: NE
LOG KOW: 0.48 (CALC) (LOG POW)
SHIPPING INFORMATION
THIS PRODUCT IS NOT TDG REGULATED.
FIRE AND EXPLOSION HAZARD
FLAMMABILITY: NOT FLAMMABLE
CONDITIONS: WILL BURN ABOVE FLASH POINT
MEANS OF EXTINCTION: WATER SPRAY, CARBON DIOXIDE, FOAM, DRY CHEMICAL.
DO NOT USE SOLD STREAM OF WATER.
FLASHPOINT: 146掳C (295掳F) (TOC)
UPPER EXPLOSION LIMIT (% V): NE
LOWER EXPLOSION LIMIT (%V): NE
AUTO-IGNITION TEMPERATURE: NE
HAZARDOUS COMBUSTION PRODUCTS: OXIDES OF CARBON, OXIDES OF NITROGEN, AMMONIA.
EXPLOSION DATA: NE
NA - NOT APPLICABLE NE - NOT ESTABLISHED
Page 2
MATERIAL SAFETY DATA SHEET
Printed: 4/4/07
N-BUTYLDIETHANOLAMINE
SENSITIVITY TO IMPACT: NO
SENSITIVITY TO STATIC DISCHARGE: NO
REACTIVITY
CHEMICAL STABILITY: STABLE
INCOMPATIBLE MATERIALS: OXIDIZERS, PERCHLORATES, NITRATES, PEROXIDES.
CONDITIONS OF REACTIVITY: NE
HAZARDOUS DECOMPOSITION NE
PRODUCTS:
HEALTH HAZARD INFORMATION
ROUTE OF ENTRY
SKIN CONTACT: MAY CAUSE SLIGHT IRRITATION.
SKIN ABSORPTION: MAY BE ABSORBED
EYE: MAY CAUSE SEVERE IRRITATION.
INGESTION: NE
INHALATION: MAY CAUSE RESPIRATORY TRACT IRRITATION.
ACUTE OVER EXPOSURE EFFECTS: NE
CHRONIC OVER EXPOSURE EFFECTS: NE
SENSITIZATION: DOES NOT MEET WHMIS CRITERIA
CARCINOGENICITY: DOES NOT MEET WHMIS CRITERIA
TERATOGENICITY: DOES NOT MEET WHMIS CRITERIA
MUTAGENICITY: DOES NOT MEET WHMIS CRITERIA
REPRODUCTIVE TOXICITY: DOES NOT MEET WHMIS CRITERIA
PREVENTIVE MEASURES
PERSONAL PROTECTIVE EQUIPMENT: WEAR SAFETY GOGGLES AND USE IMPERVIOUS
GLOVES. WHERE AIRBORNE EXPOSURE IS LIKELY,
WEAR A NIOSH APPROVED RESPIRATOR.
SPECIFIC ENGINEERING CONTROLS: LOCAL EXHAUST IS RECOMMENDED.
LEAK AND SPILL PROCEDURES: SOAK UP WITH AN ABSORBENT MATERIAL.
WASTE DISPOSAL: CONSULT FEDERAL OR LOCAL AUTHORITIES.
HANDLING PROCEDURES AND EQUIPMENT: WASH BEFORE EATING, DRINKING, USING TOBACCO
PRODUCTS OR REST ROOMS.
STORAGE REQUIREMENTS: KEEP IN A CLOSED, LABELED CONTAINER IN A
VENTILATED AREA.
FIRST AID MEASURES
EYE FLUSH EYES WITH LARGE AMOUNT OF WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. SEEK MEDICAL ATTENTION.
SKIN WASH SKIN WITH WATER AND SOAP. SEEK MEDICAL ATTENTION IF IRRITATION
OCCURS OR PERSISTS.
INGESTION DO NOT GIVE LIQUIDS IF PERSON IS UNCONSCIOUS OR VERY DROWSY. DO NOT
INDUCE VOMITING. SEEK IMMEDIATE MEDICAL ATTENTION.
INHALATION REMOVE PERSON TO FRESH AIR IMMEDIATELY. IF BREATHING HAS STOPPED, APPLY
ARTIFICIAL RESPIRATION AND ADMINISTER OXYGEN IF NECESSARY. SEEK MEDICAL
ATTENTION
PREPARATION DATE
PREPARED BY: TECHNICAL DEPARTMENT.
PHONE NUMBER OF PREPARER: 905-827-9841
DATE PREPARED: (MM/DD/YY) 02/14/01
NA - NOT APPLICABLE NE - NOT ESTABLISHED
Page 3
MATERIAL SAFETY DATA SHEET
Printed: 4/4/07
N-BUTYLDIETHANOLAMINE
DATE REVISED: (MM/DD/YY) 04/04/07
MINIMUM CONTACT WITH THIS AND ALL CHEMICALS IS RECOMMENDED AS A GOOD GENERAL POLICY TO
FOLLOW
THE INFORMATION PRESENTED HEREIN HAS BEEN COMPILED FROM SOURCES CONSIDERED TO BE
DEPENDABLE AND IS ACCURATE TO THE BEST OF OUR KNOWLEDGE. HOWEVER, SINCE DATA, SAFETY
STANDARDS, AND GOVERNMENT REGULATIONS ARE SUBJECT TO CHANGE AND THE CONDITIONS OF
HANDLING AND USE, OR MISUSE ARE BEYOND OUR CONTROL, ARKEMA CANADA MAKES NO WARRANTY
EXPRESSED OR IMPLIED, WITH RESPECT TO COMPLETENESS OR CONTINUING ACCURACY OF THE
INFORMATION CONTAINED HEREIN AND DISCLAIMS ALL LIABILITY FOR RELIANCE THEREON. USER
SHOULD SATISFY HIMSELF THAT HE HAS ALL CURRENT DATA RELEVANT TO HIS PARTICULAR USE.
NA - NOT APPLICABLE NE - NOT ESTABLISHED
