Page 1
MATERIAL SAFETY DATA SHEET
Printed: 3/14/06
PENNAD 150
PRODUCT IDENTIFICATION AND USE
MANUFACTURER: ARKEMA CANADA INC.
700 THIRD LINE
OAKVILLE, ONTARIO
L6J 5A3
EMERGENCY PHONE NUMBER: (905) 827-9841 (ARKEMA)
(613) 996-6666 (CANUTEC)
PRODUCT IDENTIFIER: PENNAD 150
PRODUCT CODE: ORG0150
PRODUCT USE: CHEMICAL INTERMEDIATE
WHMIS CLASSIFICATION: B3 - COMBUSTIBLE LIQUID.
D2A 鈥? VERY TOXIC MATERIAL CAUSING OTHER EFFECTS.
E - CORROSIVE MATERIAL.
HAZARDOUS INGREDIENTS
% W/W CAS # TLV
DIETHYLAMINOETHANOL 99 100-37-8 TWA = 2 PPM (SKIN)
LD50: 1,260 MG/KG (ORAL-RATS)
LD50: 1,110 鈥? 1,260 MG/KG (DERMAL-RABBITS)
LDlo: 4.5 MG/L (4HR.-INHALATION-RATS)
ADDITIONAL INGREDIENT INFORMATION (WHMIS NOT CONTROLLED):
NA
PHYSICAL DATA
PHYSICAL STATE: LIQUID
ODOUR AND APPEARANCE: CLEAR, COLOURLESS LIQUID, AMMONIA-LIKE ODOUR.
ODOUR THRESHOLD: 0.05-0.20 MG/M3
SPECIFIC GRAVITY/DENSITY (G/ML): 0.88 鈥? 0.89 @ 20掳C
VAPOUR PRESSURE: 1.4 MMHG
VAPOUR DENSITY (AIR=1): 4.0
VOLATILITY/VOL(%): 100
SOLUBILITY IN H20: COMPLETELY SOLUBLE @ 20掳C
EVAPORATION RATE: 0.2
BOILING POINT: 158 鈥? 163.5掳C
FREEZING POINT: -56掳C
PH: NA
LOG KOW: 0.43 (LOG POW)
SHIPPING INFORMATION
UN 2686, 8(3), II, 2-DIETHYLAMINOETHANOL.
FIRE AND EXPLOSION HAZARD
FLAMMABILITY: COMBUSTIBLE
CONDITIONS: WILL BURN ABOVE FLASHPOINT.
MEANS OF EXTINCTION: WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY
CHEMICAL. DO NOT PERMIT WATER TO ENTER CONTAINER.
FLASHPOINT: 50掳C (SETA CC)
UPPER EXPLOSION LIMIT (% V): 12
LOWER EXPLOSION LIMIT (%V): 7
AUTO-IGNITION TEMPERATURE: NE
NA - NOT APPLICABLE NE - NOT ESTABLISHED
Page 2
MATERIAL SAFETY DATA SHEET
Printed: 3/14/06
PENNAD 150
HAZARDOUS COMBUSTION PRODUCTS: OXIDES OF CARBON, NITROGEN OXIDES
EXPLOSION DATA: NE
SENSITIVITY TO IMPACT: NO
SENSITIVITY TO STATIC DISCHARGE: NO
REACTIVITY
CHEMICAL STABILITY: STABLE
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS, PERCHLORATES, NITRATES,
PEROXIDES.
CONDITIONS OF REACTIVITY: NE
HAZARDOUS DECOMPOSITION NE
PRODUCTS:
HEALTH HAZARD INFORMATION
ROUTE OF ENTRY
SKIN CONTACT: CORROSIVE.
SKIN ABSORPTION: MAY BE HARMFUL.
EYE: CORROSIVE. MAY CAUSE BLINDNESS.
INGESTION: MAY CAUSE NAUSEA AND SEVERE IRRITATION.
INHALATION: VAPOUR MAY CAUSE SEVERE IRRITATION OF MUCOUS
MEMBRANES.
ACUTE OVER EXPOSURE EFFECTS: NE
CHRONIC OVER EXPOSURE EFFECTS: NE
SENSITIZATION: DOES NOT MEET WHMIS CRITERIA.
CARCINOGENICITY: DOES NOT MEET WHMIS CRITERIA.
TERATOGENICITY: DOES NOT MEET WHMIS CRITERIA.
MUTAGENICITY: DOES NOT MEET WHMIS CRITERIA.
REPRODUCTIVE TOXICITY: LONG TERM INGESTION HAS CAUSED TESTICULAR ATROPHY
IN ANIMALS.
PREVENTIVE MEASURES
PERSONAL PROTECTIVE EQUIPMENT: WEAR SAFETY GOGGLES AND USE IMPERVIOUS
GLOVES. AN NIOSH APPROVED RESPIRATOR IS
ADVISED.
SPECIFIC ENGINEERING CONTROLS: LOCAL EXHAUST IS RECOMMENDED.
LEAK AND SPILL PROCEDURES: SOAK UP WITH AN ABSORBENT MATERIAL AND PLACE IN
A CLOSED CONTAINER.
WASTE DISPOSAL: HAZARDOUS WASTE. DO NOT ALLOW PRODUCT TO
ENTER THE ENVIRONMENT. CONSULT FEDERAL OR
LOCAL AUTHORITIES FOR APPROVED DISPOSAL
METHODS.
HANDLING PROCEDURES AND EQUIPMENT: WASH BEFORE EATING, DRINKING, USING TOBACCO
PRODUCTS OR REST ROOMS. KEEP AWAY FROM HEAT,
SPARKS, AND OPEN FLAME. AVOID EYE AND SKIN
CONTACT. WHEN TRANSFERRING FROM CONTAINERS,
GROUND AND BOND BOTH CONTAINERS.
STORAGE REQUIREMENTS: KEEP IN A CLOSED, LABELED CONTAINER IN A
VENTILATED AREA
FIRST AID MEASURES
EYE FLUSH EYES WITH LARGE AMOUNT OF WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. SEEK MEDICAL ATTENTION..
NA - NOT APPLICABLE NE - NOT ESTABLISHED
Page 3
MATERIAL SAFETY DATA SHEET
Printed: 3/14/06
PENNAD 150
SKIN WASH SKIN WITH WATER AND SOAP. SEEK MEDICAL ATTENTION IF IRRITATION
OCCURS OR PERSISTS.
INGESTION DO NOT GIVE LIQUIDS IF PERSON IS UNCONSCIOUS OR VERY DROWSY. DO NOT
INDUCE VOMITING. SEEK IMMEDIATE MEDICAL ATTENTION.
INHALATION REMOVE PERSON TO FRESH AIR IMMEDIATELY. IF BREATHING HAS STOPPED, APPLY
ARTIFICIAL RESPIRATION AND ADMINISTER OXYGEN IF NECESSARY. SEEK MEDICAL
ATTENTION.
PREPARATION DATE
PREPARED BY: TECHNICAL DEPARTMENT.
PHONE NUMBER OF PREPARER: 905-827-9841
DATE PREPARED (MM/DD/YY): 07/06/94
DATE REVISED (MM/DD/YY): 03//14/06
MINIMUM CONTACT WITH THIS AND ALL CHEMICALS IS RECOMMENDED AS A GOOD GENERAL POLICY TO
FOLLOW.
THE INFORMATION PRESENTED HEREIN HAS BEEN COMPILED FROM SOURCES CONSIDERED TO BE
DEPENDABLE AND IS ACCURATE TO THE BEST OF OUR KNOWLEDGE. HOWEVER, SINCE DATA, SAFETY
STANDARDS, AND GOVERNMENT REGULATIONS ARE SUBJECT TO CHANGE AND THE CONDITIONS OF
HANDLING AND USE, OR MISUSE ARE BEYOND OUR CONTROL, ARKEMA CANADA MAKES NO WARRANTY
EXPRESSED OR IMPLIED, WITH RESPECT TO COMPLETENESS OR CONTINUING ACCURACY OF THE
INFORMATION CONTAINED HEREIN AND DISCLAIMS ALL LIABILITY FOR RELIANCE THEREON. USER
SHOULD SATISFY HIMSELF THAT HE HAS ALL CURRENT DATA RELEVANT TO HIS PARTICULAR USE.
NA - NOT APPLICABLE NE - NOT ESTABLISHED
|