Cleaner
Approved on 11/08/07
Page: 1 of 4
MATERIAL SAFETY DATA SHEET
1. PRODUCT and COMPANY IDENTIFICATION
Manufacturer
Selena USA, Inc.
21715 Beck Drive
Elkhart, Indiana 46516
Non Emergency Information
Telephone: (574) 523-0400
Emergency Information
Transportation Emergency Telephone: CHEMTREC 1-800-424-9300. The product listed below is registered by the
manufacturer, SELENA USA, INC.
International Transportation Emergency: CHEMTREC (703) 527-3887
Product Name: TYTAN庐 Cleaner
Chemical Name: Acetone in aerosol container
2. COMPOSITION (Information on Ingredients)
Component CAS No Weight %
Chemical Name (common names)
Acetone 67-64-1 77 - 78
Butane (Butane) 106-97-8 9 - 11
Propane (Propane) 74-98-6 6.5 - 8
Isobutane (Isobutane) 75-28-5 6.5 - 8
See Section 8 of this MSDS for Exposure Guidelines
3. HAZARDS INDENTIFICATION
Physical Hazards
ATTENTION! Aerosol. Flammable gas and liquid. Container is pressurized and storing temperature should not exceed
120掳 (49 掳C) in order to avoid pressure build-up and possible container rupture.
F
Potential Health Effects
The primary adverse health effect(s) of this material are related to an acute or chronic overexposure to Acetone. This
material can be harmful or even fatal is inhaled or ingested. Therefore, adequate ventilation should be provided to avoid
exceeding the exposure limits of these components (See Section 8).
Exposure Routes
Inhalation: Vapors may irritate mucous membranes and upper airways. Extensive overexposure to solvent may cause
light headedness, headaches, or lethargy and physiological injury. Exposure to extremely high vapor
concentrations can cause death.
Skin Contact: May cause localized irritation, reddening and/or swelling. Prolonged or repeated exposure may lead to
sensitization blistering, and/or dermatitis.
Eye Contact: May irritate eyes causing pain, lacrimation and general inflammation.
Ingestion: May cause irritation of mucous membranes in oral cavity and in digestive system.
The medical conditions, if any that may deteriorate through the contact with product are not known.
4. FIRST AID MEASURES
Inhalation: If breathing difficulty is experienced, move to a fresh air place. If necessary, provide oxygen or artificial
respiration by trained personnel and obtain medical attention.
1
Cleaner
Approved on 11/08/07
Page: 2 of 4
Skin Contact: Remove by washing affected area thoroughly with soap and water. Apply a delicate skin cream if irritation
develops. If symptoms persist, in case of redness seek medical attention.
Eye Contact: Bath eye immediately with a large amount of water for at least 15 minutes. See medical attention immediately.
Ingestion: DO NOT INDUCE VOMITING! Drink 1- 2 glasses of water or milk. Do not give anything orally to an unconscious
person. Contact a physician immediately.
Caution: The long-term contact with the skin may cause non carcinogenic dermatitis.
5. FIRE FIGHTING MEASURES
Flash Point: -4掳 (-20掳 for acetone
F C)
Flammable Limits: Acetone Propane/Butane
Lower Explosive Limit 2.6% 1.5%
Upper Explosive Limit 13% 10%
High temperatures will raise the pressure in the container, which may cause container rupture.
Extinguishing media: CO2, dry chemical foam, halon 1211, normal foam, water spray, if a large quantity is used.
Special Fire-fighting Procedures: Wear self-contained breathing apparatus (SCBA) to protect against inhalation of smoke and
toxic decomposition by-products. Flammable gases and liquids can migrate down (gas has four times the density of air).
Neutralize through controlled combustion.
6. ACCIDENTAL RELEASE MEASURES
Personal Precautions: Ensure adequate ventilation and wear recommended protective clothing (face protection,
protective clothes and gloves. Vapors can accumulate in low areas. Do not smoke and avoid
ignition from sparking.
Environmental Precautions: Before disposing of containers, relieve container of any remaining foam and pressure. Dispose of
empty containers as pressurized containers. Clean out contaminated area.
Clean-up Methods: Use an absorbent material such as sawdust or vermiculite.
7. HANDLING AND STORAGE
Handling: Warning Flammable Contents! Contents are under pressure. Keep away from heat, open flame
and all sources of ignition. Do not pierce containers. Do not mix with other chemicals.
Storage: Store in a cool, dry place. Recommended storage temperature is between 40掳 to 90掳 (4.4掳 to
F F C
25.5掳 Do not store above 120掳 (49掳 will short en shelf life. Protect containers from heat.
C). F C)
Contents are under pressure, do not pierce the containers. Protect from freezing. Keep away
from food, drinks, animal food. Keep out of the reach of children.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Read all product instructions before using. Personal protective equipment should include safety eye wear, chemical resistant
gloves, and long sleeve work clothes. Adequate ventilation should used to avoid exceeding recommended vapor level
guidelines. If vapor levels are expected to exceed these guidelines, use NIOSH/MSHA approved, positive pressure supplied air
respiratory apparatus (SCBA). Employ good personal hygiene, wash thoroughly after each use.
Exposure Guidelines OSHA ACGIH
Acetone 750 ppm 1,000 ppm TWA
Butane (Butane) 10,000 ppm 2,500 ppm TWA
Propane (Propane) 10,000 ppm 2,500 ppm TWA
Isobutane (Isobutane) 10,000 ppm 2,500 ppm TWA
None of the components in this product are listed by IARC, NTP, OSHA or ACGIH as a carcinogen.
2
Cleaner
Approved on 11/08/07
Page: 3 of 4
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Thin liquid
Appearance: Clear
Color: Clear
Odor: Characteristic smell of Acetone.
Specific Gravity: Approximately 0.79 g/cm鲁 (H20 = 1)
Boiling Point: 35.6掳 (2掳 acetone
F C)
Flash Point: -4掳 (-20掳 for acetone
F C)
Self-Flammability: Extremely flammable (propane/butane/isobutane)
Auto-Flammability: over 1004掳 (540掳
F C)
pH: 5-6
Vapor Pressure: In the pressurized container the vapor pressure exceeds 500 kPa. After spraying, the vapor
pressure is 233 kPa (20掳 C)
Solubility in Water: Soluble
VOC 6.18 lb/gal
Explosion data: Acetone Propane/Butane
a) lower 2.6 1.5
b) upper 13 10
10. STABILITY AND REACTIVITY
This product is stable in normal storing conditions. Avoid storing temperatures exceeding 120掳 (50掳 . Protect against
F C)
mechanical shocks. Avoid heat and moisture. Strongly reacts with substances such as oxidizing agents. Dangerous
decomposition product is peroxide. Avoid contact with oxidizing agent, sparks, open flame, ignition sources.
11. TOXICOLOGICAL INFORMATION
Acute toxicity: Short term oral toxicity. LD 50 = 5800 mg/kg (rat).
Skin contact: LD 50 = 20000 mg/kg (rat)
Inhalation: LD 50 = 0.76 mg/l (rat 鈥? 4 hours inhalation).
Irritating action: Irritates eyes, contact with eyes may cause cornea damage.
Allergies: Prolonged contact with skin may cause an allergic reaction. Prolonged toxicity close to acute and
chronic vapor inspiration may result in irritation of airways, mucous membranes causing cough,
breathing difficulties, and headache. Symptoms may appear with delay. Prolonged skin contact
may cause drying and scouring reaction.
Additional toxicological
Information: None
12. ECOLOGICAL INFORMATION
Biodegradation: Type Aerobic inoculum: domestic savage, not adapted.
84% after 20 days. BOD5 = 1.85 g/g
Chemical degradation: COD = 2.07 g/g
Bioaccumulation: Not Established
Agility: Not Established
Toxicity influence on
Organisms: For fish: Limnea macrochirus CL50: 8300 mg/l/96 hr
Toxicity in water: For daphnia: Daphnia magna UE50: 12600 - 12700 mg/l/48 hr
Other toxicity: The highest permissible toxic concentration:
Toxicity for algae: Scenedesmus quadricauda KI5 : 7500 mg/l/8 d
Toxicity for bacteria: Macrocystis aeruginosa UE5: 530 mg/l/ 8 d
Pseudomonas putida UE5: 1700 mg/l/ 16 hr
13. DISPOSAL CONSIDERATIONS
Before disposing of containers, relieve container of contents and pressure. Dispose of containers in accordance with all
applicable guidelines and regulations. Avoid discharge to natural waters.
14. TRANSPORTATION INFORMATION
Shipping Information
Containers Less than 1,000 cu. cm. (1 litre) i.e. 12 oz.
DOT (Ground): Aerosol, Consumer Commodity, ORM-D, Limited Quantity
3
Cleaner
Approved on 11/08/07
Page: 4 of 4
Air: Aerosols, Class 2.1 UN 1950 (Flammable Gas Label)
Water: Aerosols, Class 2.1 UN 1950 (Flammable Gas Label)
Exceptions: N/A
Note: Emergency Response Guide Number 鈥? Consumer Commodity #171
15. REGULATORY INFORMATION
Toxic Substances Control Act (TSCA) Designated Substances List (DSL):
All ingredients are listed on the TSCA inventory, as well as the Canadian Designated Substances List. This product has
been classified according to the hazard criteria of the CPR and the MSDS contains all the information required by the CPR.
SARA Title III:
Contains no materials which are subject to the reporting requirements of SARA Title III.
Proposition 65:
Based on information currently available, this product is not known to contain detectable amounts of any chemicals
currently listed under California Proposition 65.
16. OTHER
NFPA: Fire 3; Health 2; Reactivity 1
HMIS: Flammability 3; Health 2; Reactivity 1
The information and recommendations contained herein are presented in good faith and believed to be correct as of the date
hereof. The manufacturer makes no representations as to the completeness or accuracy thereof. Information supplied upon the
condition that the persons receiving said information will make their own determination as to its suitability for their particular
purpose prior to use. In no event will the manufacturer be responsible for damages of any nature whatsoever resulting from the
use of or reliance upon information. No representations or warranties, either expressed or implied, including the merchantability
or fitness for a particular purpose are made herein with respect to this information or the product to which information refers.
Information contained herein is deemed to be reliable, conservative and accurate. SELENA USA, Inc. reserves the right to
change the design, specification or any other features at any time, without notice, while otherwise maintaining regulatory
compliance.
4
|