MATERIAL SAFETY DATA SHEET
EMERGENCY TELEPHONE 800-424-9300 (Chemtrec) Health : 3
Lonza Inc.90 Boroline Road Allendale NJ 07401 Flammability : 1
800-777-1875 (9am - 5pm) 309-697-7200 (After 5pm) Reactivity : 0
97636 Bio-Surf I-20 PAGE 1 OF 6
************************************************************************************
MATERIAL DATE ISSUED DOT HAZARD CLASSIFICATION
Bio Surf I-20 10/31/04 - Rev. 8, PG II
DOT SHIPPING NAME
CAS NO. 11096-42-7 Disinfectants, Liquid, Corrosive, N.O.S.
SUPERSEDES
10/18/99 DOT LABEL Corrosive
.
(C2H4O)nC15H24O xI2 (n=average of 12; x=1.48)
FORMULA
Mixture
CHEMICAL NAME
****************************** I - INGREDIENTS *************************************
APPROXIMATE
WEIGHT % TWA/TLV
Nonylphenol, ethoxylated iodine complex
(CAS No. 11096-42-7) 92 None established
* Provides 20% titratable iodine *For iodine:
0.1 ppm (OSHA ceiling limit)
0.1 ppm (ACGIH ceiling limit)
Water (CAS No. 7732-18-5) 8 None established
********************** II - PHYSICAL AND CHEMICAL PROPERTIES ***********************
APPEARANCE Dark red-brown viscous liquid pH 1.68 (10% in water)
o
VISCOSITY 580 cps @ 25 C ODOR Mild, halogen-like
O
MELTING OR FREEZING POINT < 0oC
BOILING POINT Decomposes @ 91-101 C
VAPOR DENSITY (Air=1) Not known VAPOR PRESSURE (mm Hg) <1.7 mm Hg
PERCENT VOLATILE (by weight) 8 (Water) SOLUBILITY IN WATER Soluble
o
EVAPORATION RATE (Butyl Acetate=1) Not SPECIFIC GRAVITY (WATER = 1) 1.34 @ 25 C
known
*********************** III - FIRE AND EXPLOSION INFORMATION ***********************
o
FLASH POINT >200 F AUTO IGNITION TEMPERATURE Not known
LOWER EXPLOSION LIMIT (%) Not applicable UPPER EXPLOSION LIMIT (%) Not applicable
FOAM X ALCOHOL FOAM X
EXTINGUISHING MEDIA CO2
DRY CHEMICAL X WATER X OTHER
SPECIAL FIRE FIGHTING PROCEDURES:
Must wear NIOSH approved self-contained breathing apparatus and protective clothing.
Cool fire-exposed containers with water spray.
The information provided herein is compiled form internal reports and data form professional publications. IT IS FURNISHED WITHOUT WARRANTY OF ANY
KIND, EXPRESSED OR IMPLIED. It is intended to assist in evaluating the suitability and proper use of the material in manufacturing and in the development and
implementation of safety precautions and procedures.
MATERIAL SAFETY DATA SHEET
EMERGENCY TELEPHONE 800-424-9300 (Chemtrec)
Lonza Inc. 90 Boroline Road Allendale NJ 07401 800-777-1875 (9am - 5pm) 309-697-7200 (After 5pm)
97636 Bio-Surf I-20 PAGE 2 OF 6
*********************** III - FIRE AND EXPLOSION INFORMATION (continued) ***********
UNUSUAL FIRE AND EXPLOSION HAZARDS:
Products of combustion are toxic. Heating this material may release iodine
vapors/fumes.
************************ IV - HEALTH EFFECTS INFORMATION ***************************
ROUTES OF ENTRY - SKIN CONTACT X EYE CONTACT X
INHALATION X INGESTION
EFFECTS OF OVEREXPOSURE
Based upon animal toxicity information available for this material, direct skin or eye
contact can produce skin or eye damage and/or burns. Mists of product can produce
irritation of mucous membranes. May be harmful or fatal if swallowed.
OVEREXPOSURE MAY AGGRAVATE EXISTING CONDITIONS:
No effects indicated.
EMERGENCY AND FIRST AID PROCEDURES:
Eyes: Flush eyes with large amounts of running water for at least 15 minutes. Hold
eyelids apart to ensure rinsing of the entire surface of the eye and lids with water.
Get immediate medical attention. If physician not available, flush for additional 15
minutes and then transport victim to medical care.
Skin: Wash with large amounts of running water, and soap if available, for 15 minutes.
Remove contaminated clothing and shoes. Get immediate medical attention. Wash
clothing and decontaminate shoes before reuse.
Ingestion: If swallowed, immediately give 3-4 glasses of milk (if unavailable, give
water). DO NOT induce vomiting. If vomiting occurs, give fluids again. Get immediate
medical attention. Have physician determine if patient's condition allows for
induction of vomiting or evacuation of the stomach. Do not give anything by mouth to a
convulsing or unconscious person.
Inhalation: Remove from area to fresh air. If not breathing, clear airway and start
artificial respiration. If victim is having trouble breathing, give supplemental
oxygen, if available. Get immediate medical attention.
CHEMICALS LISTED AS CARCINOGEN BY: (YES OR NO)
NATIONAL TOXICOLOGY PROGRAM - No
- No
I.A.R.C. MONOGRAPHS
- No
OSHA
*************************** V - REACTIVITY INFORMATION ******************************
X
STABILITY: STABLE CONDITIONS TO AVOID
None known
UNSTABLE
The information provided herein is compiled form internal reports and data form professional publications. IT IS FURNISHED WITHOUT WARRANTY OF ANY
KIND, EXPRESSED OR IMPLIED. It is intended to assist in evaluating the suitability and proper use of the material in manufacturing and in the development and
implementation of safety precautions and procedures.
MATERIAL SAFETY DATA SHEET
EMERGENCY TELEPHONE 800-424-9300 (Chemtrec)
Lonza Inc. 90 Boroline Road Allendale NJ 07401 800-777-1875 (9am - 5pm) 309-697-7200 (After 5pm)
97636 Bio-Surf I-20 PAGE 3 OF 6
*************************** V - REACTIVITY INFORMATION (continued) ******************
HAZARDOUS DECOMPOSITION PRODUCTS
Thermal decomposition may produce toxic vapors/fumes of iodine, organic materials and
oxides of carbon.
HAZARDOUS POLYMERIZATION CONDITIONS TO AVOID
WILL NOT X None known
MAY
OCCUR OCCUR
INCOMPATIBILITY (MATERIALS TO AVOID)
OTHER X Reducing agents such as sodium sulfite and bases
WATER
************************ VI - SPILL AND DISPOSAL INFORMATION ***********************
STEPS TO BE TAKEN IN CASE OF MATERIAL SPILL OR RELEASE
DANGER! Corrosive material. Wear appropriate protective equipment and NIOSH approved
respirator where mists or vapors of unknown concentrations may be generated (self-
contained breathing apparatus preferred).
Dike and contain spill with inert material (sand, earth, etc.) and transfer the liquid
and solid separately to containers for recovery or disposal. Keep spill out of sewers
and open bodies of water.
WASTE DISPOSAL METHODS
Dispose of in compliance with all Federal, state and local laws and regulations.
Incineration is the preferred method.
*********************** VII - PERSONAL PROTECTION INFORMATION **********************
ENGINEERING CONTROLS
In processes where mists or vapors may be generated, proper ventilation must be
provided in accordance with good ventilation practices.
RESPIRATORY PROTECTION
In processes where mists or vapors may be generated, a NIOSH approved respirator is
advised in the absence of proper environmental controls.
PROTECTIVE GLOVES
Rubber or neoprene, to prevent skin contact.
EYE PROTECTION
Wear chemical splash goggles where there is a potential for eye contact. Use safety
glasses with side shields under normal use conditions.
OTHER PROTECTIVE EQUIPMENT
Eye wash; safety shower; protective clothing (long sleeves, coveralls or other, as
appropriate), to prevent skin contact.
The information provided herein is compiled form internal reports and data form professional publications. IT IS FURNISHED WITHOUT WARRANTY OF ANY
KIND, EXPRESSED OR IMPLIED. It is intended to assist in evaluating the suitability and proper use of the material in manufacturing and in the development and
implementation of safety precautions and procedures.
MATERIAL SAFETY DATA SHEET
EMERGENCY TELEPHONE 800-424-9300 (Chemtrec)
Lonza Inc. 90 Boroline Road Allendale NJ 07401 800-777-1875 (9am - 5pm) 309-697-7200 (After 5pm)
97636 Bio-Surf I-20 PAGE 4 OF 6
*************************** VIII - STORAGE AND HANDLING ****************************
PRECAUTIONS FOR STORAGE AND HANDLING:
May be stored in glass, fiberglass or plastic containers. Metal containers should be
avoided. Keep container closed until used.
Empty containers retain product residues and can be dangerous. Do not pressurize, cut
weld, braze, solder, drill, grind or expose such containers to heat or flame. They may
explode and cause injury. Follow all MSDS precautions in handling empty containers.
************************** IX - TOXICOLOGY INFORMATION *****************************
No information found for this material. The information below is for the closely
related material, Bio-Surf I-20:
- oral LD50 (male rat): 1520 mg/kg
- oral LD50 (female rat): 1480 mg/kg
- dermal LD50 (female rabbits): greater than 2000 mg/kg
- skin irritation (rabbit): 0.5 ml applied to the abraded and non-abraded skin of
rabbits for 24 hours under occlusion caused defined redness at 72 hours, post-dose.
(primary irritation index 1.0)
- eye irritation (rabbit): 0.1 ml instilled to the eye with washing produced moderate
to severe eye irritation that did not totally clear by day 14, post-dose
- in rabbits, 0.2 and 1.0 grams/kg applied to the skin five days per week for three
weeks was found to cause dose-related skin irritation and decreased weight gain
- in rats, oral administration of 27 to 587 mg/kg/day on days 5 to 14 gestation was
not teratogenic but was lethal to 50% of the females treated at the highest dose
level
For Iodine (ACGIH information):
Iodine is highly irritating to the skin, eyes and mucous membranes. Signs and symptoms
include irritation and burning of the eyes, tearing, coughing and irritation of the
nose and throat. Oral overdose causes stomach pain, nausea, vomiting and diarrhea.
******************* X - MISCELLANEOUS AND REGULATORY INFORMATION ********************
FEDERAL LEVEL REGULATIONS:
TOXIC SUBSTANCES CONTROL ACT (TSCA INVENTORY) STATUS:
The components in this product are currently listed on the EPA TSCA 8(b) inventory.
TSCA Section 12(b) Export Notification:
Components present in this product which, if exported, could require either annual
or one-time reporting under this regulation are as follows:
Typical Maximum
Chemical Name CAS Number Concentration
None known
EPA REGULATION ON PESTICIDES:
This product is an EPA FIFRA registered pesticide, EPA Registration No. 6836-184.
This product can only be used commercially in the EPA FIFRA registered
application(s) noted on the product label.
The information provided herein is compiled form internal reports and data form professional publications. IT IS FURNISHED WITHOUT WARRANTY OF ANY
KIND, EXPRESSED OR IMPLIED. It is intended to assist in evaluating the suitability and proper use of the material in manufacturing and in the development and
implementation of safety precautions and procedures.
MATERIAL SAFETY DATA SHEET
EMERGENCY TELEPHONE 800-424-9300 (Chemtrec)
Lonza Inc. 90 Boroline Road Allendale NJ 07401 800-777-1875 (9am - 5pm) 309-697-7200 (After 5pm)
97636 Bio-Surf I-20 PAGE 5 OF 6
******************* X - MISCELLANEOUS AND REGULATORY INFORMATION (continued) ********
FEDERAL LEVEL REGULATIONS (continued):
US FDA Regulation on Food Contact:
This product is regulated under the following section(s) of the Code of
Federal Regulations (CFR) as an incidental food additive:
21 CFR 178.1010
CERCLA (Comprehensive Environmental Response, Compensation and Liability Act of
1980 requires notification of the National Response Center
(Telephone 800-424-8802) in the event of a release of quantities of the
following hazardous materials contained in this product, if the release is
equal to or greater than the Reportable Quantities (RQs) listed in
40 CFR 302.4:
Typical Maximum
Chemical Name CAS Number Concentration
None known
SARA Title III, Sections 302/304 (Superfund Amendments and Reauthorization act of
1986) - This act requires emergency planning, including agency notification, for
possible release of the following components of this material, based upon the
Threshhold Planning Quantities (TPQs) and release Reportable Quantities (RQs)
listed for the Components in 40 CFR 355:
Typical Maximum
Chemical Name CAS Number Concentration
None known
SARA Title III Sections 311/312 - This act requires reporting under the Community
Right-to-Know provisions due to the inclusion of the following components of this
material in one or more of the five hazard categories listed in 40 CFR 370:
Hazard *)
Chemical Name CAS Number Categories
Nonylphenol, ethoxylated iodine complex 11096-42-7 A
*) The five hazard categories are as follows: F=FIRE HAZARD; S= SUDDEN RELEASE OF
PRESSURE; R=REACTIVE; A=IMMEDIATE (ACUTE) HEALTH HAZARD; C=DELAYED (CHRONIC)
HEALTH HAZARD
SARA Title III Section 313 - This act requires submission of annual reports of the
releases of the following components of this material if the threshold reporting
quantities, as listed in 40 CFR 372, are met or exceeded:
Typical Maximum
Chemical Name CAS Number Concentration
None known
The information provided herein is compiled form internal reports and data form professional publications. IT IS FURNISHED WITHOUT WARRANTY OF ANY
KIND, EXPRESSED OR IMPLIED. It is intended to assist in evaluating the suitability and proper use of the material in manufacturing and in the development and
implementation of safety precautions and procedures.
MATERIAL SAFETY DATA SHEET
EMERGENCY TELEPHONE 800-424-9300 (Chemtrec)
Lonza Inc. 90 Boroline Road Allendale NJ 07401 800-777-1875 (9am - 5pm) 309-697-7200 (After 5pm)
97636 Bio-Surf I-20 PAGE 6 OF 6
******************* X - MISCELLANEOUS AND REGULATORY INFORMATION (continued) ********
STATE RIGHT-TO-KNOW REGULATIONS:
CALIFORNIA PROPOSITION 65 - Components present in this material which the State of
California has found to cause cancer, birth defects or other reproductive harm
are as follows:
AS A CANCER HAZARD Typical Maximum
Chemical Name CAS_Number Concentration
Acetaldehyde 75-07-0 1 ppm
Ethylene oxide 75-21-8 1 ppm
1,4-Dioxane 123-91-1 10 ppm
AS A REPRODUCTIVE HAZARD Typical Maximum
Chemical Name CAS_Number Concentration
Ethylene oxide 75-21-8 1 ppm
MASSACHUSETTS Right-to-Know - The following components of this material are included
in the Massachusetts Substance List and are present at or above reportable
levels:
Typical Maximum
Chemical Name CAS Number Concentration
Acetaldehyde 75-07-0 1 ppm
Ethylene oxide 75-21-8 1 ppm
1,4-Dioxane 123-91-1 10 ppm
MICHIGAN Critical Materials - The following components of this material are included
in the Michigan Critical Materials List:
Chemical Name CAS Number
None known
NEW JERSEY Right-to-Know - The following components of this material are included in
the New Jersey Hazardous Substance List and are present at or above reportable
levels:
Typical Maximum
Chemical Name CAS Number Concentration
Nonylphenol, ethoxylated iodine complex 11096-42-7 92%
PENNSYLVANIA Right-to-Know - The following components of this material are included
in the Pennsylvania Hazardous Substance List and are present at or above
reportable levels:
Typical Maximum
Chemical Name CAS Number Concentration
None known
The information provided herein is compiled form internal reports and data form professional publications. IT IS FURNISHED WITHOUT WARRANTY OF ANY
KIND, EXPRESSED OR IMPLIED. It is intended to assist in evaluating the suitability and proper use of the material in manufacturing and in the development and
implementation of safety precautions and procedures.
|