SUPPLIER: METPREP LTD.
CURRIERS CLOSE
CHARTER AVENUE
COVENTRY CV4 8AW
TELEPHONE: PRODUCT INFORMATION: 024 7642 1222
FAX: 024 7642 1192
CHEMICAL NAME:
PRODUCT: METPREP BLUE LUBRICANT
PRODUCT NUMBERS: 15 50 09
2. COMPOSITION / INFORMATION ON INGREDIENTS
DESCRIPTION: Lubricant for use with MetPrep diamond suspensions containing aliphatic chemical solve nt & water.
INGREDIENT (S): CAS NUMBER % Risks
1-Methoxy-2-Propanol 107-98-2 30-40% F R10
3. HAZARDS IDENTIFICATION
Fire and Explosion Hazards: Moderate/high hazard. Liquid can release vapours that can readily form flammable
mixtures at or above the flash point.
4. FIRST AID MEASURES
EMERGENCY AND FIRST AID PROCEDURES:
INHALATION: Move the exposed person to fresh air at once. Get medical attention. Administer artificial respiration if
breathing has stopped.
EYES: Irrigate thoroughly with water for at least 10 minutes. Seek medical attention..
SKIN: Remove soaked clothing. Wash the skin immediately with soap and water. Seek medical attention if
symptoms occur after washing.
INGESTION: DO NOT INDUCE VOMITING! If vomiting occurs, keep head low so that stomach content does not get
into the lungs. Drink plenty of water. Seek medical attention immediately
5. FIRE FIGHTING MEASURES
EXTINGUISHING MEDIA: Foam, Dry Chemical or sand
SPECIAL RISKS: Fire creates acrid smoke/fumes of carbon monoxide and carbon dioxide.
6. ACCIDENTAL RELEASE MEASURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: As appropriate to the quantity handled.
Behavior in water: Miscible in water
Spillage: Wear necessary protective equipment. Absorb in cat litter, dry sand or earth and
place into containers. Dispose of according to recognized method of chemical disposal.
Ref.: C:\MSDS\BLUELUB.DOC Prepared May 2005
Page 2 of 3
MATERIAL SAFETY DATA SHEET
7. HANDLING AND STORAGE
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Avoid spilling, skin and eye contact. Ventilate well, avoid
breathing vapours. Use approved respirator if air contamination exceeds accepted level.
STORAGE: Keep in cool, dry ventilated storage and closed containers. Container remains hazardous even when empty
OTHER PRECAUTIONS: As appropriate to quantity handled
8. EXPOSURE CONTROL / PERSONAL PROTECTION
RESPIRATORY PROTECTION (SPECIFY TYPE): No specific recommendation . If OEL exceeded respiration protection
must be used.
VENTILATION: Provide adequate general and local exhaust ventilation
o
BOILING POINT: 100 C SPECIFIC GRAVITY (H2O=1): 1.00
VAPOUR PRESSURE: NA PERCENT VOLATILE W/W%: NA
DENSITY: 0.95 g/cm 3 EVAPORATION RATE: NA
FLASHPOINT: 32 o C
AUTOIGNITION TEMPERATURE: NA FLAMMABLE LIMIT, AIR VOL % LOWER: NA
UPPER: NA
SOLUBILITY IN WATER: miscible
10. STABILITY AND REACTIVITY
STABILITY: Stable under normal conditions.
CONDITIONS TO AVOID: None
INCOMPATIBILITY (MATERIALS TO AVOID): Avoid Strong acids and oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS: NA.
Ref.: C:\MSDS\BLUELUB.DOC Prepared May 2005
Page 3 of 3
MATERIAL SAFETY DATA SHEET
HAZARDOUS POLYMERIZATION: NA
11. TOXICOLOGICAL INFORMATION
INHALATION: Gas or vapour is harmful on prolonged exposure or in high concentrations. Narcotic effect.
LC50/Inhalation/Rat 6mg/ 录 hr
SKIN CONTACT: Skin resorption hazard. Frequent or prolonged contact may irritate and cause dermatitis.
EYE CONTACT: Irritating but does not injure eye tissue.
INGESTION: Toxic dose 5000mg/kg (Oral Rat).
REPRODUCTIVE TOXICITY DATA: Not known.
TOXICITY DATA: NA.
12. ECOLOGICAL INFORMATION
GENERAL: Biological degradability: Good.
ECOLOGICAL TOXICITY: Toxicity to fish
LC50/ Leusiscus idus: >4600mg/l/96hr.
BEHAVIOUR AND ENVIROMENTAL FATE: Inhibition of degradation in activated sludge is not to be anticipated during
correct introduction of low concentrations.
13. DISPOSAL CONSIDERATIONS
WASTE DISPOSAL METHODS: Dispose of in accordance with local authority requirements .
14. TRANSPORTATION INFORMATION
UN NAME: NA
UN NUMBER: NA
IMDG CODE/CLASS 3363
IICAO/IATA CLASS 3
RID/ADR CLASS: 3.31C
HAZCHEM CODE: NA
15. REGULATORY INFORMATION
EXPOSURE LIMITS: Recommended 100 mg/m3.
RISK PHRASE: R10 Flammable
SAFETY PHRASES S 24 Avoid contact with skin
16. OTHER INFORMATION
None
The data sheet was prepared in accordance with Directive 91/155/EEC
The above information has been gathered from reliable sources and is believed to be correct. However, the information is
provided without any warranty, either expressed or implied. MetPrep Ltd. shall not be held liable for any damage resulting from
the handling of or contact with the above product.
Ref.: C:\MSDS\BLUELUB.DOC Prepared May 2005
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP