1
HAZARDOUS MATERIAL INFORMATION
PRODUCT TRADE NAME: SYSTEM
1
HEALTH
HOMAX PRODUCTS, INC.
TILE GROUT COATING
0
FLAMMABILITY
ITEM #93100-30
0
REACTIVITY
N
PROTECTIVE EQUIPMENT
(HAZARD RATING: 0=LEAST, 1=SLIGHT, 2=MODERATE, 3=HIGH,
4=EXTREME) (I=SAFETY GLASSES, GLOVES, & VAPOR RESPIRATOR)
SECTION I - MANUFACTURER IDENTIFICATION
MANUFACTURER'S NAME: 24 HOUR EMERGENCY PHONE NUMBER:
HOMAX PRODUCTS, INC. CHEMTREC 1-800-424-9300
468 W. HORTON ROAD
BELLINGHAM WA 98226 NFORMATION PHONE NUMBER: 1-800-729-9029
DATE OF PREPARATION: 9/24/04
SECTION II A - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
CHEMICAL NAME CAS NUMBER % PEL SKIN TLV CARCINOGEN
Proprietary Mixture None 100% N/A N/A N/A No
(PIGMENTED RESIN BASE IN WATER)
All ingredients used in this proprietary mixture are listed on the TSCA Inventory List and none is listed as carcinogenic by OSHA, IARC or NTP.
SECTION III- PHYSICAL/CHEMICAL CHARACTERISTICS
APPEARANCE AND ODOR: White liquid with mild latex paint odor
BOILING POINT: N/D
WATER SOLUBILITY: Partial
VAPOR PRESSIRE: N/D
PH: N/D
EVAPORATION RATE: <1(H2O=1)
CALCULATED V.O.C. .08 LB/GL (10GR/LT) Zero% VOC by CARB
SECTION IV-FIRE AND EXPLOSION DATA
Flash Point: None
Explosive Hazard; Not an explosive.
Extinguishing Media: Water fog, foam, carbon dioxide, dry chemical
Special Fire Fighting Procedures: None known.
Unusual Fire and Explosion Hazards: None
SECTION V 鈥? REACTIVITY DATA
STABILITY: MATERIAL IS STABLE
INCOMPATIBILTY (MATERIALS TO AVOID): None known
2
HAZARDOUS DECOMPOSITION PRODUCTS: None known
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
SECTION VI 鈥? HEATLTH HAZARD DATA
PRIMARY ROUTES OF ENTRY AND EFFECTS OF OVEREXPOSURE
EYES; According to the Federal Hazardous Substance Act testing protocol 16CFR 1500.42, this product is expected to be an
eye irritant in laboratory test. Therefore this material is considered an eye irritant.
SKIN ABSORPTION: According to the Federal Hazardous Substance Act testing protocol 16CFR 150.41, this product is not
expected to be a primary skin irritant skin irritant. However, avoid contact with open wounds.
INHALATION; Not expected to be an inhalation hazard.
INGESTION; Not expected to be an ingestion hazard.
CHRONIC EFFECTS FROM LONG TERM /REPEATED EXPOSURE:
No long term effects expected.
EMERGENCY AND FIRST AID PROCEDURES:
INGESTION; Rinse mouth and then drink a large glass of water and seek immediate medical attention.
INHALATION: Remove person to fresh air. Seek medical attention if effects are persistent.
EYE: If applicable, remove contact lenses. Flush eyes with plenty of water for at least 15minutes. Contact a physician if
irritation persists.
SKIN: Wash with plenty of soap and large quantities of water. Contact a physician if irritation persists.
OTHER: N/A
SECTION VIII 鈥? PERSONAL PROTECTION
RESPIRATORY PROTECTION:
This product is not expected to be an inhalation hazard. In areas of inadequate ventilation, organic vapor cartridges
are appropriate if respiratory protection is preferred by the handler.
VENTILATION:
Mechanical (general) ventilation is usually adequate.
HAND PROTECTION
Chemically resistant gloves (neoprene) are recommended for prolonged use.
EYE PROTECTION:
Splash goggles are recommended where usage creates significant splashing.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT:
EYES - WASH FOUNTAIN AND SAFETY SHOWER.
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE RE-USE.
WORK/HYGIENIC PRACTICES:
WASH HANDS AFTER USING AND BEFORE EATING, DRINKING OR USING TOBACCO PRODUCTS.
THROUGHLY CLEAN CONTAMINATED CLOTHING AND SHOES BEFORE REUSE.
SPILL OR LEAKAGE PROCEDURES:
3
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Spilled material can be picked up with sorbant material. Use caution where surfaces may become slippery from spilled
material.
WASTE DISPOSAL:
Sweep up and place in empty container and close. Dispose of according to local, state and federal regulations.
WASTE DISPOSAL CAUTION;
Hazardous substances cleaned with this product may create hazardous waste that must be properly characterized and
disposed of in accordance with RCRA, states and local regulations.
SPECIAL PRECAUTIONS:
HANDLING PRECAUTIONS:
USE PROPER METHODS OF VENTILATION TO PREVENT VAPOR BUILD-UP. AVOID SPRAYING HOT
SURFACES. DO NOT HEAT, PUNCTURE OR INCINERATE CONTAINERS. CONTENTS ARE UNDER
PRESSURE AND MAY CONTAIN VAPORS, EVEN WHEN EMPTY. DO NOT REMOVE OR DEFACE LABEL.
SHIPPING AND STORAGE PRECAUTIONS:
KEEP OUT OF THE REACH OF CHILDREN
Store in a cool, dry area away from heat or open flame.
Do not store at temperatures above 120F or below 32F
SECTION IX - DISCLAIMER
TO THE BEST OF OUR KNOWLEDGE, THE INFORMATION CONTAINED HEREIN IS ACCURATE, OBTAINED FROM
SOURCES BELIEVED BY HOMAX PRODUCTS, INC. TO BE ACCURATE. SINCE THE CONDITIONS AND METHODS OF
USE OF OUR PRODUCTS ARE BEYOND OUR CONTROL, WE DISCLAIM ANY AND ALL LIABILITY ARISING OUT OF
THE IMPROPER USE OF THESE PRODUCTS OR THE INFORMATION PROVIDED HEREWITH.
PROPER SHIPPING NAME: CONSUMER COMMODITY
HAZARD CLASS NUMBER: ORM-D
|