1
HAZARDOUS MATERIAL INFORMATION
PRODUCT TRADE NAME: SYSTEM
1
HEALTH
HOMAX PRODUCTS, INC.
10-YEAR POLYMER SEALER
2
FLAMMABILITY
ITEM #93205-30,93206-30
0
REACTIVITY
(HAZARD RATING: 0=LEAST, 1=SLIGHT, 2=MODERATE, 3=HIGH,
4=EXTREME) (I=SAFETY GLASSES, GLOVES, & VAPOR RESPIRATOR) C
PROTECTIVE EQUIPMENT
SECTION I - MANUFACTURER IDENTIFICATION
MANUFACTURER'S NAME: 24 HOUR EMERGENCY PHONE NUMBER:
HOMAX PRODUCTS, INC. CHEMTREC 1-800-424-9300
468 W. HORTON ROAD
BELLINGHAM WA 98226 NFORMATION PHONE NUMBER: 1-800-729-9029
DATE OF PREPARATION: 9/24/04
SECTION II A - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
CHEMICAL NAME CAS NUMBER % PEL SKIN TLV CARCINOGEN
Proprietary Mixture None 100% N/A N/A N/A No
(Aromatic and Isoparaffin Solvent-Based Perfluoro Sealer)
All ingredients used in this proprietary mixture are listed on the TSCA Inventory List and none is listed as carcinogenic by OSHA, IARC or NTP.
SECTION III- PHYSICAL/CHEMICAL CHARACTERISTICS
APPEARANCE AND ODOR: Orange 鈥? Yellow Liquid with Mild Petroleum Odor
BOILING POINT: Approximately 320F
WATER SOLUBILITY: Insoluble
VAPOR PRESSIRE: 43.7 mm Hg
EVAPORATION RATE: <1(H2O=1)
CALCULATED V.O.C. .08 LB/GL (10GR/LT) 99% VOC (by CARB)
SECTION IV-FIRE AND EXPLOSION DATA
Flash Point: 110F (43C) (Pensky-Marten Closed Cup)
Explosive Hazard; N/D
Extinguishing Media: Foam, dry chemical, carbon dioxide, and water spray or fog
Special Fire Fighting Procedures: Use self-contained breathing apparatus for respiratory protection in enclosed areas when
fighting a fire or when heated material becomes highly flammable.
Unusual Fire and Explosion Hazards: Not an oxidizer.
SECTION V 鈥? REACTIVITY DATA
STABILITY: MATERIAL IS STABLE
INCOMPATIBILTY (MATERIALS TO AVOID): Keep away from oxidizing materials(i.e., chlorine, strong acids).
HAZARDOUS DECOMPOSITION PRODUCTS: Carbon dioxide, carbon monoxide and unidentified organic compounds may
be formed during combustion.
2
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
SECTION VI 鈥? HEATLTH HAZARD DATA
PRIMARY ROUTES OF ENTRY AND EFFECTS OF OVEREXPOSURE
EYES; According to the Federal Hazardous Substance Act testing protocol 16CFR 1500.42, this product is expected to be an
eye irritant in laboratory test. Therefore this material is considered an eye irritant.
SKIN ABSORPTION: According to the Federal Hazardous Substance Act testing protocol 16CFR 150.41, this product is not
considered not to be a primary skin irritant in laboratory tests. Therefore, this product is considered not to be a primary skin
irritant .
INHALATION; Not expected to be an inhalation hazard.
INGESTION; According to the Federal Hazardous Substance Act testing protocol 16CFR 1500.3漏(2)(i), this product is
considered to be non-toxic by the oral route of exposure. This material is not considered an ingestion hazard. However, this
product does contain petroleum distillates and is an aspiration hazard.
CHRONIC EFFECTS FROM LONG TERM /REPEATED EXPOSURE:
No long term effects expected.
EMERGENCY AND FIRST AID PROCEDURES:
INGESTION; This material can enter the lungs during swallowing or vomiting and cause lung inflammation and damage.
Therefore, do not induce vomiting if ingestion occurs. Seek medical attention immediately.
INHALATION: Remove person to fresh air.
EYE: If applicable, remove contact lenses. Flush eyes with plenty of water for at least 15minutes. Contact a physician if
irritation persists.
SKIN: Avoid repeated, excessive and prolonged daily skin contact. Wash with plenty of soap and large quantities of water.
Contact a physician if irritation persists.
OTHER: N/A
SECTION VIII 鈥? PERSONAL PROTECTION
RESPIRATORY PROTECTION:
This product is not expected to be an inhalation hazard. In areas of inadequate ventilation, organic vapor cartridges
are appropriate if respiratory protection is preferred by the handler.
VENTILATION:
Mechanical (general) ventilation is usually adequate.
HAND PROTECTION
Chemically resistant gloves (neoprene) are recommended for prolonged use.
EYE PROTECTION:
Splash goggles are recommended where usage creates significant splashing.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT:
EYES - WASH FOUNTAIN AND SAFETY SHOWER.
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE RE-USE.
WORK/HYGIENIC PRACTICES:
3
WASH HANDS AFTER USING AND BEFORE EATING, DRINKING OR USING TOBACCO PRODUCTS.
THROUGHLY CLEAN CONTAMINATED CLOTHING AND SHOES BEFORE REUSE.
SPILL OR LEAKAGE PROCEDURES:
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Ventilate area. Spilled material can be picked up with sorbant material. Use caution where surfaces may become
slippery from spilled material.
WASTE DISPOSAL:
Promptly Sweep or vacuum up and place in empty steel container and close. Dispose of according to local, state and federal
regulations.
WASTE DISPOSAL CAUTION;
Hazardous substances cleaned with this product may create hazardous waste that must be properly characterized and
disposed of in accordance with RCRA, states and local regulations.
SPECIAL PRECAUTIONS:
HANDLING PRECAUTIONS:
USE PROPER METHODS OF VENTILATION TO PREVENT VAPOR BUILD-UP. AVOID SPRAYING HOT
SURFACES. DO NOT HEAT, PUNCTURE OR INCINERATE CONTAINERS. CONTENTS ARE UNDER
PRESSURE AND MAY CONTAIN VAPORS, EVEN WHEN EMPTY. DO NOT REMOVE OR DEFACE LABEL.
SHIPPING AND STORAGE PRECAUTIONS:
KEEP OUT OF THE REACH OF CHILDREN
Store in a cool, dry area away from heat or open flame.
Do not store at temperatures above 120F or below 32F
SECTION IX - DISCLAIMER
TO THE BEST OF OUR KNOWLEDGE, THE INFORMATION CONTAINED HEREIN IS ACCURATE, OBTAINED FROM
SOURCES BELIEVED BY HOMAX PRODUCTS, INC. TO BE ACCURATE. SINCE THE CONDITIONS AND METHODS OF
USE OF OUR PRODUCTS ARE BEYOND OUR CONTROL, WE DISCLAIM ANY AND ALL LIABILITY ARISING OUT OF
THE IMPROPER USE OF THESE PRODUCTS OR THE INFORMATION PROVIDED HEREWITH.
PROPER SHIPPING NAME: CONSUMER COMMODITY
HAZARD CLASS NUMBER: ORM-D
|