1
PRODUCT TRADE NAME:
HOMAX PRODUCTS, INC.
TILE GUARD SILICONE GROUT SEALER
ITEM #9320,9322,9324,9325,9326,9413,9425
SECTION I - MANUFACTURER IDENTIFICATION
MANUFACTURER'S NAME: 24 HOUR EMERGENCY PHONE NUMBER:
HOMAX PRODUCTS, INC. CHEMTREC 1-800-424-9300
468 WEST HORTON ROAD
BELLINGHAM, WA 98226 INFORMATION PHONE NUMBER: 1-800-729-9029
DATE OF PREPARATION: 03/27/03
SECTION II - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
CAS NUMBER DESCRIPTION % EXPOSURE LIMITS
016589438 SODIUM SILICONATE 3 SAME LIMITS AS FOR SODIUM
HYDROXIDE OSHA PEL AND ACGIH
TLV 2 MG/M3 CEILING
NOTE: ALL OTHER INGREDIENTS HAVE BEEN DEFINED AS NON-HAZARDOUS BY OSHA STANDARDS
29CFR1910.1200
SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS
APPEARANCE AND ODOR: SEMI CLEAR LIQUID, NO ODOR
BOILING POINT: 212F
PH: 11.85
VAPOR PRESSURE ( MMHG) APPROX. 24@77
WATER SOLUBILITY (%): 100%
VAPOR DENSITY: SAME AS MOIST AIR
SPECIFIC GRAVITY: APPROX. 1
MELTING POINT: 32F
VOC CONTENT: <0.1%
SECTION IV 鈥? FIRE AND EXPLOSION DATA
FLASH POINT (METHOD USED): NONE
FLAMMABLE LIMITS IN AIR % BY N/A
VOL:
EXTINGUISHING MEDIA: WATER, CO2, DRY CHEMICAL, FOAM
SPECIAL FIRE FIGHTING PRODUCT DOES NOT BURN
PROCEDURES:
UNUSUAL FIRE AND EXPLOSION PRODUCT DOES NOT BURN
HAZARD:
2
SECTION V 鈥? REACTIVITY DATA
STABILITY:
STABLE.
INCOMPATIBILITY (MATERIALS TO AVOID):
STRONG OXIDIZERS
HAZARDOUS DECOMPOSITION PRODUCTS:
CARBON MONOXIDE
HAZARDOUS POLYMERIZATION:
SHOULD NOT OCCUR
SECTION VI 鈥? HEALTH HAZARD DATA
PRIMARY ROUTE OF ENTRY:
SKIN,INHALATION
EFFECTS OF OVEREXPOSURE:
INHALATION: MIST MAY IRRITATE NOSE AND THROAT
EYES: DIRECT CONTACT BURNS EYES WITH POSSIBLE INJURY.
SKIN: BURNS SKIN UPON LONG PERIODS OF CONTACT.
INGESTION: SMALL AMOUNTS SHOULD NOT INJURE. SWALLOWING LARGE AMOUNTS MAY BE HARMFUL.
EMERGENCY AND FIRST AID PROCEDURES:
INGESTION: DO NOT INDUCE VOMITING. TREAT SAME AS FOR SODIUM HYDROXIDE, 3% SOLUTION. GET
IMMEDIATE MEDICAL ATTENTION.
INHALATION: REMOVE TO FRESH AIR. GET IMMEDIATE MEDICAL ATTENTION.
EYES: FLUSH IMMEDIATELY WITH WATER FOR 15 MINUTES. GET IMMEDIATE MEDICAL ATTENTION.
SKIN: FLUSH IMMEDIATELY WITH WATER FOR 15 MINUTES. GET IMMEDIATE MEDICAL ATTENTION.
SECTION VII 鈥? PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN INCASE MATERIAL IS RELEASED OR SPILLED:
USE ABSORBENT MATERIAL TO COLLECT, CONTAIN FOR DISPOSAL.
WASTE DISPOSAL METHOD:
DISPOSE ACCORDING TO APPLICABLE REGULATIONS.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE:
STORE IN COOL, DRY PLACE.
SHIPPING INFORMATION:
THIS PRODUCT IS NOT HAZARDOUS MATERIAL OR HAZARDOUS SUBSTANCE DEFINED BY THE
DEPARTMENT OF TRANSPORTATION, NOR IS IT A DANGEROUS GOOD AS DEFINED BY IATA FOR AIR
TRANSPORTATION.
SECTION VIII 鈥? CONTROL MEASURES
RESPIRATORY PROTECTION:
USE A NIOSH APPROVED MIST FILTER IF MISTING IS LIKELY.
VENTILATION RECOMMENDATIONS:
AS NECESSARY TO KEEP EXPOSURE WITHIN TLV AND PEL GUIDELINES.
SKIN:
AVOID CONTACT BY WEARING IMPERVIOUS CLOTHING. RUBBER GLOVES, APRON, BOOTS ARE
REQUIRED.
EYE PROTECTION:
USE CHEMICAL WORKER GOGGLES.
3
SECTION XI - DISCLAIMER
TO THE BEST OF OUR KNOWLEDGE, THE INFORMATION CONTAINED HERE IN IS ACCURATE, OBTAINED FROM
SOURCES BELIEVED BY HOMAX CORPORATION TO BE ACCURATE. SINCE THE CONDITIONS AND METHODS OF
USE OF OUR PRODUCTS ARE BEYOND OUR CONTROL, WE DISCLAIM ANY AND ALL LIABILITY ARISING OUT OF
THE IMPROPER USE OF THESE PRODUCTS OR THE INFORMATION PROVIDED HEREWITH.
SHIPPING INFORMATION:
THIS PRODUCT IS NOT A HAZARDOUS MATERIAL OR HAZARDOUS
|