*Estimated
N/A-Not Applicable
N/R-Not Restricted
N/E-Not Established
MATERIAL SAFETY DATA SHEET
NOTE: BLANK SPACES ARE NOT PERMITTED. IF ANY ITEM IS NOT APPLICABLE, THE SPACE MUST BE MARKED TO INDICATE THAT.
IDENTITY PART NO.
(As shown on Label or package) INSUL-COAT F-910 IF APPLICABLE: 29980217
SECTION I
MANUFACTURER'S EMERGENCY PHONE No.
NAME USA only: 1-800-424-9300 INT鈥橪: 703-527-3887
Formulated Specifically for Bronz-Glow
ADDRESS (NUMBER, STREET, CITY, STATE AND ZIP CODE) REVISION # 0001
175 Bronz-Glow Way
MANUFACTURER'S PHONE
No. FOR INFORMATION
St. Augustine, FL 32095 904-825-0175
DATE MSDS
WAS PREPARED March 10, 2005
SECTION II - HAZARDOUS INGREDIENTS INFORMATION. All Health Hazards which comprise 1% or greater of the composition and all
carcinogens if 0.1% of the composition or greater.
HAZARDOUS COMPONENTS CHEMICAL and % Wt. CAS NO. OSHA ACGIH OTHER LIMITS
(OPTIONAL) PEL TLV RECOMMEND
IDENTITY AND COMMON NAME (S)
Acetone 29 - 37 67-64-1 1000 ppm 500 ppm None
Toluene 20 - 26 108-88-3 200 ppm 50 ppm None
Methyl Ethyl Ketone 8 - 13 78-93-3 200 ppm 200 ppm None
Xylene 5 - 10 1330-20-7 100 ppm 100 ppm None
Ethylbenzene 1-3 100-41-4 100 ppm 100 ppm None
SECTION III - PHYSICAL / CHEMICAL CHARACTERISTICS
BOILING SPECIFIC GRAVITY (H20 =1) APPROXIMATE WEIGHT PER GALLON (LBS)
7.45 鈥? 7.58
0.89 - 0.91
POINT 133 - 279掳F
VAPOR PRESSURE VAPOR DENSITY EVAPORATION RATE
(AIR = 1) (BUTYL ACETATE =1) > 1.0
Heavier than air
185 mmHg @ 20掳C
SOLUBILITY IN WATER % VOLATILE OTHER
34 鈥? 52%
(IF ANY)
VOC LBS./GAL 2.5 鈥? 3.9
Slight None
APPEARANCE
AND ODOR Characteristic solvent odor - clear liquid
SECTION IV-FIRE AND EXPLOSION HAZARD DATA
FLAMMABLE LIMITS LEL UEL
FLASH POINT - 4.0掳F
1.0 12.8
(METHOD USED) TCC
EXTINGUISHING
MEDIA Carbon Dioxide, Dry Chemical, or Foam
SPECIAL FIRE
FIGHTING PROCEDURES Self contained breathing apparatus with a full face piece, operated in pressure demand or other positive pressure mode.
UNUSUAL FIRE AND
EXPLOSION HAZARDS This material is flammable and may be ignited by heat, sparks, flame or static electricity.
HAZARDOUS PRODUCTS FORMED BY
FIRE OR THERMAL DECOMPOSITION Carbon Dioxide and/or Carbon Monoxide. Hydrogen Bromide and Chloride, and other organic hydrocarbons.
EXPLOSIVE LIMITS
(% BY VOLUME IN AIR) 1.0 鈥? 12.8
SECTION V - OPTIONAL HAZARD RATINGS IDENTIFICATION
HAZARD RATING National Fire Protection Association (NFPA)
4-EXTREME
3-HIGH FIRE REACTIVITY 0.
3
2-MODERATE
1-SLIGHT
0-INSIGNIFICANT HEALTH SPECIAL HAZARDS
2 None .
**SEE SECTION IV
This is the "front" when printed in duplex. Page 1 of 2 pages if not duplex.
SECTION VI - REACTIVITY AND STABILITY DATA
STABILITY UNSTABLE STABLE X CONDITIONS TO AVOID Temperatures over 350掳F for over 10 minutes.
INCOMPATIBILITY Oxidizing Materials
HAZARDOUS DECOMPOSITION OR BY PRODUCTS Carbon Monoxide, Carbon Dioxide, Hydrogen Chloride, and other organic hydrocarbons.
HAZARDOUS MAY OCCUR CONDITIONS TO AVOID
POLYMERIZATION WILL NOT OCCUR X None
SECTION VII - HEALTH HAZARD DATA
ROUTES OF ENTRY INHALATION? Yes SKIN? Yes INGESTION? Yes EYES? Yes
HEALTH ACUTE X See Signs and Symptoms of Exposure below.
HAZARDS CHRONIC X
CARCINOGENICITY: IARC 2B
SIGNS AND
SYMPTOMS OF Inhalation: Headache, nausea, and irritation of nose, throat and lungs. Skin: Irritation upon repeat or
EXPOSURE prolonged contact. Eyes: Slightly irritation to eyes.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE None known
EMERGENCY AND Ingestion: Contact Physician or Poison Control Immediately.
FIRST AID Inhalation: Remove to fresh air. Administer Oxygen or Artificial Respiration if Necessary.
PROCEDURES Eye Contact: Flush with large amounts of water. If irritation persists, contact Physician.
Skin: Wash with soap and water.
SECTION VIII - PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN Wipe up with floor absorbent. Transfer to hood. Prevent run-off to sewers.
IN CASE MATERIAL IS Eliminate all sources of ignition. Ventilate to maintain exposure below PEL's. Use sand or other material
RELEASED OR SPILLED to dam or contain spills. If large spill, notify appropriate state and local agencies.
WASTE DISPOSAL METHODS Dispose of product in accordance with local, county, state and federal regulations.
PRECAUTIONS TO BE Keep away from sparks, flame and heat sources. Store in cool ventilated area.
TAKEN IN HANDLING Avoid contact with eyes. Keep container closed. Use with adequate ventilation. Avoid inhalation of vapors
AND STORAGE and personal contact with liquid product. Use good personal hygiene practices.
OTHER Keep container closed when not in use. All containers should be disposed in an environmentally safe manner
PRECAUTIONS accordance with governmental regulations.
SECTION IX - CONTROL MEASURES
RESPIRATORY PROTECTION (SPECIFY TYPE) Depending on the Airborne concentration, use a Respirator PROTECTIVE GLOVES
Impervious gloves
or Gas Mask with appropriate NIOSH approved cartridge and cannister, or supplied air equipment.
VENTILATION LOCAL EXHAUST Supplemental (if needed) SPECIAL None
MECHANICAL (GENERAL) To maintain exposure below PEL's OTHER Chemical Apron/Eye bath/Safety shower
EYE PROTECTION OTHER PROTECTIVE CLOTHING OR EQUIPMENT
Chemical splash goggles or approved eye protection. None
WORK HYGIENIC PRACTICES Wash thoroughly after handling.
SECTION X - TRANSPORTATION INFORMATION (Optional)
DOT PROPER SHIPPING NAME Coating Solution DOT HAZARD CLASS 3
DOT UN NUMBER UN 1139 DOT PACKING GROUP II
IATA PROPER SHIPPING NAME Coating Solution IATA HAZARD CLASS 3
IATA UN NUMBER UN 1139 IATA PACKING GROUP II
SECTION XI - 313 SUPPLIER NOTIFICATION
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICALS SUBJECT TO REPORTING REQUIREMENTS OF SECTION 313 OF THE
EMERGENCY PLANNING AND COMMUNITY RIGHT -TO-KNOW ACT OF 1986, 40 CFR 372, (see table on page 1 for CAS # and percent by weight).
Toluene, Methyl Ethyl Ketone, Xylene, and Ethylbenzene
WARNING: THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER AND BIRTH
DEFECTS, OR OTHER REPRODUCTIVE HARM.
This is the "back" when printed in duplex. Page 2 of 2 pages if not duplex.
Andrew Stooksbury
Prepared By:
THE INFORMATION PROVIDED HEREIN IS BASED ON DATA CONSIDERED ACCURATE. NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THE DATA OR THE RESULTS OBTAINED FROM
ITS USE. SINCE THE INFORMATION CONTAINED HEREIN MAY BE APPLIED UNDER CONDITIONS BEYOND THE VENDORS CONTROL AND SINCE SUBSEQUENT DATA MAY SUGGEST MODIFICATION OF THE
INFORMATION. VENDOR ASSUMES NO RESPONSIBILITY FOR THE RESULTS OF ITS USE.
|