Toxicity: Eye irritant. Moderately toxic by ingestion and
inhalation.
Primary Routes of Entry: Skin, ingestion, inhalation.
Signs and symptoms
of Exposure: Headache, nausea, dizziness, irritation of mucous
membranes. Liquid may cause eye injury and may
cause dermatitis.
Existing Conditions
Aggravated by Exposure: None known
LOCTITE CORPORATION 09/11/96
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
Literature Referenced Carcinogen
Ingredients Target Organ and Other Health Effects NTP IARC OSHA
ACETONE BLO CNS IRR NO NO NO
Synthetic rubber No Data NO NO NO
Phenolic resin No Data NO NO NO
COPPER BLO CNS GAS IMM IRR KID LIV MUT NO NO NO
SEN SKI
ZINC OXIDE BLO GAS IMM IRR KID PAN RES SKI NO NO NO
-------------------------------------------------------------------------------
Abbreviations
BLO Blood CNS Central nervous system
GAS Gastrointestinal IMM Immune system
IRR Irritant KID Kidney
LIV Liver MUT Mutagen
PAN Pancreas RES Respiratory
SEN Sensory SKI Skin
ADDITIONAL INFORMATION:
Inhalation of phenolic resin dust has been shown to cause pulmonary
effects.
It is our best technical judgment that, with proper precautions,
normal use of the is product poses no such hazards.
4. FIRST AID MEASURES
Ingestion: Do not induce vomiting. Keep individual calm.
Obtain medical attention.
Inhalation: Remove to fresh air. If symptoms persist, obtain
medical attention.
Skin Contact: Wash with soap and water.
Eye Contact: Flush with water for at least 15 minutes. Obtain
medical attention.
5. FIRE FIGHTING MEASURES
Flash Point: Approximately -4掳F Method: Open Cup
Recommended
Extinguishing Agents: Carbon dioxide, foam, dry chemical
Hazardous Products formed
by Fire or Thermal Decomp Metal fumes
Unusual Fire or
Explosion Hazards: None
LOCTITE CORPORATION 09/11/96
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
Explosive Limits:
(% by volume in air)Lower Approximately 2%
(% by volume in air)Upper Approximately 13%
6. ACCIDENTAL RELEASE MEASURES
Steps to be taken in case
of spill or leak: Remove sources of ignition. Allow solvent to
evaporate with adequate ventilation. Scrape up
remainder and store in a closed container until
disposal.
7. HANDLING AND STORAGE
Safe Storage: Store away from heat or flame.
(Contact Loctite Customer Service 1-800-243-4874 for shelf Life information)
Handling: Avoid prolonged breathing of vapors. Keep away
from eyes. Avoid skin contact. Do not use use
near heat or flame.
8. EXPOSURE CONTROLS, PERSONAL PROTECTION
Eyes: Safety glasses or goggles.
Skin: Impervious rubber or plastic gloves.
Ventilation: Sufficient to maintain vapor concentration below
TLV.
See Section 2 for Exposure Limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Brown liquid
Odor: Acetone
Boiling Point: Approximately 133掳F
pH: Does not apply
Solubility in Water: Slightly
Specific Gravity 0.91 at 60掳F
Volatile Organic Compound
(EPA Method 24) 65.9%
Vapor Pressure: 400mm at 100掳F
Vapor Density: 2.0
Evaporation Rate
(Ether = 1) Not available
LOCTITE CORPORATION 09/11/96
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
Stability: Stable
Hazardous Polymerization: Will not occur
Incompatibility: Strong oxidizers.
Hazardous Decomposition
Products (non-thermal): None
11. TOXICOLOGICAL INFORMATION
See Section 3.
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended methods of
disposal: Incinerate following EPA and local regulations.
EPA Hazardous Waste
Number D001 - Hazardous waste per 40CFR 261.21
14. TRANSPORT INFORMATION
DOT (49 CFR 172)
Domestic Ground Transport
Proper Shipping Name: Consumer Commodity (Not more than one liter);
Resin solution (More than one liter)
Hazard Class or
Division: ORM-D (Not more than one liter);
Class 3, Packing Group II (More than one liter)
Identification Number: None (Not more than one liter);
UN 1866 (More than one liter)
Marine Pollutant: None
IATA
Proper Shipping Name: Resin Solution
Class or Division: Class 3, Packing Group II
UN or ID Number: UN 1866
15. REGULATORY INFORMATION
CA Proposition 65: Warning: This product contains a chemical known to
the State of California to cause cancer.
16. OTHER INFORMATION
Estimated NFPA(R) Code:
Health Hazard: 2
Fire Hazard: 3
LOCTITE CORPORATION 09/11/96
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100