DATA SHEET
FEAST WATSON Quickstep
PRODUCT CODE 703-94839 Data Sheet No. AUDW0705
APPROVALS AS2311: 20
Description
FEAST WATSON Quickstep is a fast-drying, aromatic, moisture-cured polyurethane.
Features Benefits
Xylene free Less flammable
Aromatic Economic
No T.D.I. Lower health risk
Moisture-cured Performs over a wide temperature range
Polyurethane resin Excellent abrasion resistance
Quick dry (1 hour) Improved productivity. Reduced risk of rejection
Uses
Use FEAST WATSON Quickstep on timber, parquetry and cork flooring and masonry
Performance Guide
Weather For interior use only. Salt Good resistance
Heat Up to 120掳C. Yellowing and embrittlement will Water Excellent resistance except to continuous
occur if subjected to continuous heat. immersion (ponding)
Solvent Resists splashes of most common solvents and Abrasion Excellent abrasion and mar resistance
cleaners
Alkali Good resistance
Acid Good resistance
Typical Properties and Application Data
Gloss Level 85-95% at 85 degrees Thinner Maxithane reducer
Gloss Level Ind Spread Rate 10.0sqm/L
Components 1.0
Volume Solids 45.0
Colour Clear Toxicity Lead free. Dry film is non-toxic and
conforms to AS1647, Part 3.
Number of Coats 1 or 2 Shelf life 12 months in unopened containers
Wet film per coat Recommended 91 碌m
0.5
Dry film per coat Recommended 41 碌m Touch Dry
Recoat 1 Hours Clean Up 12 months in unopened containers
Application Method
Data Sheet FEAST WATSON Quickstep
DuSpec Data Code AUDW0705 Page No 1 of 3
Issue No 4.0 Date Issued 23/01/2006
DATA SHEET
FEAST WATSON Quickstep
Data Sheet No. AUDW0705
Application Guide
Surface Preparation
NEW TIMBER
All timber surfaces should be thoroughly clean, dry and free from wax, oil, grease and other contaminants. Wash with mineral
turpentine if needed to remove wax and grease, and allow to dry.
Surface should be sanded in accordance with the Abrasive manufactures instructions.
Application Procedure and Equipment
Stir thoroughly before and during use with a broad flat stirrer to maintain a uniform solution.
Apply by brush, pad or roller, always laying off along the grain.
Brush, applicator or short-nap roller
Notes
Most have a final coat of Maxithane
Allow 3 hours, if sanding is deemed necessary
After 12 hours, it must be sanded
Health and Safety
MSDS 5299 Health Effects For detailed information refer to product label
Number and the current Material Safety Data Sheet
available through Sales and Customer Service
Offices. Health Effects: Splashes to eyes will
cause irritation. Prolonged contact with liquid is
harmful and inhalation of vapour and spray
mists may produce respiratory irritation and
headaches.
Protective Personal Protective Equipment: Wear eye
Flammability Flammability: This product is flammable
Equipment protection, protective clothing and gloves, and if
spraying wear a respirator with a combined
vapour/particulate cartridge.
Disposal Do not dispose down the drain. Refer to your
local council for correct disposal procedures
In the case of emergency please call 1800 033 111
Precautions and Limitations
Do not apply product if temperature is below 10掳C or above 30掳C or is likely to reach these temperatures during the drying period.
Equally, relative humidity should not exceed 85%.
Moisture content of timber should be close to equilibrium moisture cont
Transport and Storage
Pack A 703-94839
Sizes 20 Litre Flash point 43C
UN Number 1263
Weight 24 Kg
Dangerous 3 Package III
Goods Class Group
Shipment PAINTS,
Name
Data Sheet FEAST WATSON Quickstep
DuSpec Data Code AUDW0705 Page No 2 of 3
Issue No 4.0 Date Issued 23/01/2006
DATA SHEET
FEAST WATSON Quickstep
Data Sheet No. AUDW0705
Disclaimer
Dulux and Other marks followed by 庐 are registered trademarks. Marks followed by the symbol of 鈩? are trademarks.
The data provided within the Duspec system is correct at the time of publication, however it is the responsibility of those using this information to
check that it is current prior to specifying or using any of these coating systems.
DISCLAIMER: Any advice, recommendation, information, assistance or service provided by any of the divisions of Orica Consumer Products in
relation to goods manufactured by it or their use and application is given in good faith and is believed by Orica Consumer Products to be appropriate
and reliable. However, any advice, recommendation, information, assistance or service provided by Orica Consumer Products is provided without
liability or responsibility PROVIDED THAT the foregoing shall not exclude, limit, restrict or modify the right entitlements and remedies conferred
upon any person or the liabilities imposed upon Orica Consumer Products by any condition or warranty implied by Commonwealth, State or
Territory Act or ordinance void or prohibiting such exclusion limitation or modification. Coating systems can be expected to perform as indicated on
the Duspec Spec Sheet so long as applications and application procedures of the individual products are followed as recommended on the
appropriate Product data Sheet. "Orica" "Dulux" "Berger" "Berger
Gold Label" "Hadrian" "Walpamur" "Levene" "Acratex" and Other marks followed by 庐 are registered trademarks of Orica Australia Pty Ltd ABN 99
004 117 828. Marks followed by the symbol 鈩? are trademarks.
Please note that this document is only valid for 60 days from the date of issue.
Orica Consumer Products 1970 Princes Highway Clayton, Victoria 3168 AU ABN 99 004 117 828
Data Sheet FEAST WATSON Quickstep
DuSpec Data Code AUDW0705 Page No 3 of 3
Issue No 4.0 Date Issued 23/01/2006
|