Search    ENTER KEYWORD
MSDS Material Safety Data Sheet
CAS

07-01-0
13463-67-7
471-34-1
7732-18-5

File Name: amesresearch_com---ic_msds.asp
 Iron CoatTM
Product Name (as used on Label and List)

Material Safety Data Sheets (MSDS)

HMIS-NPCA-MFPA Health 1
Flammability 0
Reactivity 0
Personal Protection B


SECTION 1 鈥? CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
TM
PRODUCT NAME Iron Coat
IDENTIFICATION IC
DATE PRINTED
PRODUCT USE/CLASS Latex Paints & Coatings, water born dispersion
MANUFACTURER Ames Research Laboratories, Inc. Corporate Office:
Jefferson, Oregon 97352 PO Box 1350
Jefferson, Oregon 97352-1350
EMERGENCY TELEPHONE 1-888-345-0809
PREPARER (optional)
PHONE (503) 588-3330
PREPARE DATE 07-01-08

SECTION 2 鈥? COMPOSITION/INFORMATION ON INGREDIENTS
ITEM CHEMICAL NAME CAS NUMBER WT/WT % LESS THAN
01 Titanium dioxide 13463-67-7 5.0%
02 Calcium carbonate 471-34-1 15.0%
03
04 Acrylic-Styrene Polymer Not Regulated
05 Water 7732-18-5 > 37
Material is not known to contain Toxic Chemicals under section 313 of Title III of the Superfund Amendments and
Reauthorization Act of 1986 and 40 CFR 372. Product alkaline to PH-10. May causes stomach distress if injested. Do not
ingest.
--EXPOSURE LIMITS --
ITEM ACGIH TLV-STEL OSHA PEL-CEILING COMPANY SKIN
TLV-TWA PEL-TWA TLV-TWA
3 3
01 10 mg / m N.E. 15 mg / m N.E. N.E. NO
3 3
02 10 mg / m N.E. 15 mg / m N.E. N.E. NO



(See Section 16 for abbreviation legend)

SECTION 3 鈥? HAZARDOUS IDENTIFICATION
EFFECTS OF OVEREXPOSURE
EYE CONTACT May cause slight irritation
SKIN CONTACT May cause irritation
INHALATION May cause respiratory tract irritation
INGESTION Irritating to mouth, throat and stomach.
CHRONIC HAZARDS No anticipated effects. This product does not contain regulated levels of
NTP,IARC or OSHA listed carcinogens.
PRIMARY ROUTE(S) OF ENTRY Skin contact, Inhalation, Ingestion, Eye Contact

SECTION 4 鈥? FIRST AID MEASURES
FIRST AID
EYE CONTACT Flush eye with water for at least 15 minutes. Call a physician. PH is roughly 8.5-9.0. Alkaline.
SKIN CONTACT Remove contaminated clothing and shoes. Wash affected area(s) thoroughly with soap and water.
Flush skin after contact. May cause mild skin irritation. Protect with gloves.
INHALATION Slight ammonia odor. Remove to fresh air. If not breathing, give artificial respiration. If breathing is
difficult, give oxygen. Get immediate medical attention.
INGESTION
No data shown on latex. Not probable route of exposure.


SECTION 5 - FIRE FIGHTING MEASURES


1
All rights reserved Copyright 漏 November 2006. Patent pending.
Msds-ic
Iron CoatTM
Product Name (as used on Label and List)

Material Safety Data Sheets (MSDS)

FLASH POINT These Formulations tested in accordance with ASTM E 108-80a
Class A with a Zero ignitions with a flame spread test. With
Weyerhaeuser Company, Fire Technology Unit. Product was
also tested in accordance with ASTM E-84-81a. 鈥淪moke
attained was Zero. Product contains dispersed Latex and water
solvent. The flames spread index determined meets the criteria
for Class A material over A/C/ Substrate.
LOWER EXPLOSIVE LIMIT N.A.
UPPER EXPLOSIVE LIMIT N.A.
AUTOIGNITION TEMPERATURE Zero ignition.
EXTINGUISHING MEDIA FOAM CO2, DRY CHEMICAL, WATER, FOG foam.
UNUSUAL FIRE AND EXPLOSIVE HAZARDS None Known. Some Gases, Hydrogen Chloride, carbon
monoxide,
SPECIAL FIREFIGHTING PROCEDURES Containers exposed to fire should be kept cool with water spray.
Containers can build up pressure if exposed to heat (fire). As in
any fire, wear self-contained breathing apparatus pressure-
demand (MSHA/NIOSH approved or equivalent) and full
protective gear.

SECTION 6 鈥? ACCIDENTAL RELEASE MEASURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Flush small spills with water. Soak up large spills with sand or earth and remove. Repeat sorbent/sweep cycle until the
spill has dried up. Collect and dispose according to local regulations. Avoid runoff into storm sewers and ditches that
lead to waterways. This product does not meet the definition of hazardous waste under the U.S. EPA Hazardous Waste
Regulations 40 CFR 261. Consult your state or local authorities for proper disposal in the event more restrictive
requirements apply.

SECTION 7 鈥? HANDLING AND STORAGE
HANDLING: Use in a well ventilated area. Keep out of reach of children. If user operations generate dust, fume, or
mist, use ventilation to keep exposure to airborne contaminants below the exposure limit. Uses
goggles and gloves. Similar to most latex paints.
STORAGE: Keep container closed when not in use. Dries Rapidly.

SECTION 8 鈥? EXPOSURE CONTROLS/PERSONAL PROTECTION
ENGINEERING CONTROLS: Local exhaust ventilation may be necessary to control any air contaminants to
within their TLVs during the use or this product. Contains low levels of
Ammonia for PH control Less than 9 ph.
RESPIRATORY PROTECTION: Wear NIOSH/MSHA approved respiratory protection when the product is mixed
or applied in a poorly ventilated area or if workplace levels of ingredients if they
exceed the TLV. Follow applicable federal, state, and local regulations.
OTHER PROTECTIVE EQUIPMENT: Where contact is likely, wear chemical resistant gloves, chemical safety
goggles with a face shield, and clean protective clothing to cover arms and legs
to keep exposure to a minimum.
HYGIENC PRACTICES: Do not take internally. Wash thoroughly after handling. Remove contaminated
clothing and wash before reuse. Avoid breathing vapors from heated material.




2
All rights reserved Copyright 漏 November 2006. Patent pending.
Msds-ic
Iron CoatTM
Product Name (as used on Label and List)

Material Safety Data Sheets (MSDS)

SECTION 9 鈥? PHYSICAL AND CHEMICAL PROPERTIES
o
BOILING RANGE: 212 F VAPOR DENSITY: Is heavier than air
ODOR: Slight Ammonia Ph ODOR THRESHOLD: N.D.
8.0 鈥?9.5 Mild
APPEARANCE: Thick, white, liquid. EVAPORATON RATE: Similar to Latex paint, water
based Latex polymers.
SOLUBILITY IN H20 Dilutable, Miscible. SPECIFIC GRAVITY: 1.05 to 1.15
% VOLATILES Volatile is water. Level is 39-55%
pH @ 0.0% 8.0- 9.5 Ph FREEZE POINT: 32 degrees F Near Water at 25 deg C. Do
not freeze. Freezing will solidify
and destroy the product.
VISCOSITY: 130-160 Krebs VAPOR PRESSURE: 1.75 mm Hg
PHYSICAL STATE: White Thick Latex COEFFICIENT OF WATER/OIL Water VOC solvents
Liquid, Contains DISTRIBUTION: negligible.
acrylic latex
(See Section 16 for abbreviation legend)

SECTION 10 鈥揝TABILITY AND REACTIVITY
CONDITIONS TO AVOID: Long term exposure to elevated temperatures
INCOMPATIBILITY: NA
HAZARDOUS DECOMPOSITION PRODUCTS: NA
HAZARDOUS POLYMERIZATION: Will not occur.
STABILITY: This product is stable under normal storage conditions.

SECTION 11 鈥? TOXICOLOGICAL PROPERTIES
PRODUCT DERMAL LS50: No Information
PRODUCT LC50: No Information
PRODUCT ORAL LD50: No Information

COMPONENT TOXICOLOGICAL INFORMATION:

--CHEMICAL NAME-- DERMAL LD50 ORAL LD50 LC50
This product does not contain regulated levels of NTP, IARC or OSHA
Existing Health Conditions Affected by Exposure 鈥? No known effects on other illnesses



SECTION 12 鈥? ECOLOGICAL INFORMATION
ECOLOGICAL INFORMATION: Contains water based acrylic. Relatively non-toxic to environment.




SECTION 13 鈥? DISPOSAL CONSIDERATIONS
DISPOSAL METHOD: Review all local, state, and federal regulations concerning health and pollution for
appropriate disposal procedures.



SECTION 14 鈥? TRANSPORTATION INFORMATION
DOT PROPER SHIPPING NAME: Not regulated
DOT TECHNICAL NAME: N.A.
DOT HAZARD CLASS: N.A.
HAZARD SUBCLASS: N.A.
DOT UN/NA NUMBER: N.A.
PACKING GROUP: N.A.
RESP. GUIDE PAGE: N.A.
DOT PLACARD AT: N.A.
DOT CLASS NUMBER: N.A.
UN PROPER SHIPPING NAME: Not registered
N.A. AIR: N.A. MARINE: N.A.
UN CLASS NUMBER:
N.A. AIR: N.A. MARINE: N.A.
HAZARD SUBCLASS:
N.A. UN PACKING GROUP: N.A. AIR: N.A. MARINE: N.A.
UN UN/NA NUMBER
UN PLACARD AT: N.A.



SECTION 15 鈥? REGULARTORY INFORMATION
U.S. Federal Regulation: AS FOLLOWS 鈥?


3
All rights reserved Copyright 漏 November 2006. Patent pending.
Msds-ic
Iron CoatTM
Product Name (as used on Label and List)

Material Safety Data Sheets (MSDS)

OSHA: Hazardous by definition of Hazard Communication Standard (29 CRF1910.1200)

CERCLA 鈥? SARA Hazard Category: This product has been reviewed according to the EPA 鈥淗azard Categories鈥?
promulgated under Sections 311 and 312 of the Superfund Amendment and Reauthorization Act of 1986 (SARA Title III)
and is considered, under applicable definitions, to meet the following categories: None

SARA Section 313: This product does not contain toxic chemical(s) at or above the de minimus concentrations subject to
the reporting requirements of section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986
(SARA) and 40 CFR part 372

Toxic Substances Control Act: This product meets the compositional requirements of the Toxic Substances Control Act
and contains only chemical ingredients that are listed on the TOSCA inventory

California Prop. 65: This product contains no trace amount of a chemical(s) known to California to cause cancer and/or
birth defects or other reproductive harm.

Canadian EPA: This Product contains only chemical ingredients that are listed on the Domestic Substance List of the
Canadian Environmental Agency.


INTERNATIONAL REGULATIONS: AS FOLLOWS--
CANADIAN WHMIS: This MSDS has been prepared in compliance with
Controlled Product Regulations except for the use of the
sixteen headings.
CANADIAN WHMIS CLASS No Information available.



SECTION 16 鈥? OTHER INFORMATION
HMIS RATINGS: HEALTH FLAMMABILITY REACTIVITY PERSONAL
1 0 0 PROTECTION
B
PREVIOUS MSDS REVISION DATE: 06-12-07
REASON FOR REVISION:
VOLATILE ORGANIC COMPOUNDS 0.50 lbs/gal, 60 grams/ltr
(VOC鈥檚):
LEGEND: N.A. not applicable, N.E. Not established, N.D. Not determinded
ABBREVIATIONS USED: N/A (information or data not available); NTP (National Toxicology Program);
IARC (International Agency for Research on Cancer); NIOSH (National Institute
of occupational Safety and Health administration); PEL (Permissible Exposure
Limit) [8 hr. TWA][OSHA]; TLV (Threshold Limit Value)[8 hr. TWA][ACGIH];
STEL (Short term exposure limit)[15 min. TWA][OSHA]; C (ceiling value).
DISCLAIMER: Ames Research Laboratories, Inc. believes that the information provided is
accurate and reliable as of the date of this material safety data sheet and is
given in good faith. No warranty expressed or implied is made as to the
accuracy, reliability or completeness of the information. Any use of this data
and information must be determined by the user to be in accordance with
applicable Federal, State and Local laws and regulations. Ames Research
Laboratories, Inc. urges persons receiving this information to make their own
determination as to the information鈥檚 suitability and applicability for an intended
use.

Note: This information must be included in all MSDS that are copied and
distributed for this material.




4
All rights reserved Copyright 漏 November 2006. Patent pending.
Msds-ic

Search    ENTER KEYWORD
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP
NAMECAS
alexlind_com_au---timbershadespds.asp N/A
alexlind_com_au---tungoilpds.asp N/A
alexlind_com_au---ultraclearlowsheenpds.asp N/A
alexlind_com_au---unithanectglossmsds.asp 108-67-8 64742-95-6 1330-20-7 95-63-6 54839-24-6 26471-62-5
alexlind_com_au---uvcpds.asp N/A
alexlind_com_au---wattylestapolgloss18065msds.asp N/A
alexlind_com_au---wetedgeextenderpds.asp N/A
alexlind_com_au---woodcraftpds.asp N/A
alexlind_com_au---woodguardmsds.asp 138-86-3 5989-27-5
alexlind_com_au---woodguardpds.asp N/A
alexlind_com_au---woodsheenmsds.asp 138-86-3 5989-27-5
alumin-r.asp 8052-42-4 64742-95-6 9003-55-8 7429-90-5 68855-54-9 63231-67-4 13983-17-0
ambionchem_com---insulstrp_liquid_msds.asp 75-09-2 64-18-6
amesresearch_com---bmxrg_msds.asp 04-07-0 7732-18-5
amesresearch_com---bwa_msds.asp 06-12-0 13463-67-7 471-34-1 7732-18-5
amesresearch_com---cs_msds.asp 07-01-0 7732-18-5
amesresearch_com---eb_msds.asp 07-01-0 13463-67-7 471-34-1 7732-18-5
amesresearch_com---ic_msds.asp 07-01-0 13463-67-7 471-34-1 7732-18-5
amesresearch_com---jp_msds.asp 07-01-0 13463-67-7 471-34-1 7732-18-5
amesresearch_com---msgy_msds.asp 07-01-0 13463-67-7 471-34-1 7732-18-5
amesresearch_com---pp25_msds.asp 07-01-0 13463-67-7 471-34-1 7732-18-5
amesresearch_com---rp_msds.asp 07-01-0 13463-67-7 471-34-1 7732-18-5
amesresearch_com---sd_msds.asp 07-01-0 13463-67-7 471-34-1 7732-18-5
amesresearch_com---seb_msds.asp 07-01-0 13463-67-7 471-34-1 7732-18-5
amesresearch_com---sp_msds.asp 07-01-0 7732-18-5
amesresearch_com---ss_msds.asp 07-01-0 13463-67-7 471-34-1 7732-18-5
amesresearch_com---vb_msds.asp 07-01-0 13463-67-7 471-34-1 7732-18-5
aquariumpharm_com---accuclear_2453.asp N/A
aquariumpharm_com---activatedfiltercarbon_2477.asp 7440-44-0
aquariumpharm_com---african_mineral_salts_cichlid_060408.asp N/A
aquariumpharm_com---algaedestroyerliquid_2455.asp 31512-74-0
aquariumpharm_com---algaefix_2456.asp 31512-74-0
aquariumpharm_com---amazon_extract_060408.asp N/A
aquariumpharm_com---ammocarb_2478.asp 1318-02-1 7440-44-0 7732-18-5
aquariumpharm_com---ammochips_2479.asp 1318-02-1
aquariumpharm_com---ammolock_2444.asp 10102-17-7
aquariumpharm_com---api_bettafix_111307.asp N/A
aquariumpharm_com---aquariumsalt_2445.asp 7647-14-5
aquariumpharm_com---bm_cutyourown_032808.asp N/A
aquariumpharm_com---buffer_max_cichlid_060408.asp N/A
aquariumpharm_com---buffer_max_marine_092107.asp N/A
aquariumpharm_com---carbonatehardnesstestkit_2473.asp N/A
aquariumpharm_com---copper_test_100405.asp 148-18-5 64-02-8 7732-18-5
aquariumpharm_com---eco_calcium_092007.asp N/A
aquariumpharm_com---eco_strontium_092507.asp N/A
aquariumpharm_com---firstlayerpurelaterite_635.asp 14808-60-7 1344-28-1 1309-37-1 13463-67-7
aquariumpharm_com---fungus_cure_liq_030308.asp N/A
aquariumpharm_com---fw_deluxe_ph_041708.asp N/A
aquariumpharm_com---fw_master_test_041808.asp 7647-01-0
aquariumpharm_com---high_range_ph_100305.asp 2303-01-7

Free MSDS Search ( Providing 250,000+ Material Properties )
Chemcas.com | Ads link:HBCCHEM.INC