: Kobo Products, Inc.
Manufacturer/Distributor
: 690 Montrose Avenue
Address
So. Plainfield, NJ 07080
: (908) 757-0033
Emergency Telephone #
: (908) 757-0905
Facsimile Number
: DSPCS/20N-I2
Trade Name
Chemical Name/ Synonyms : Silica (And) Ethylene/Methacrylate Copolymer (And) Isopropyl Titanium
Triisostearate
SECTION 2: COMPOSTION / INFORMATION ON INGREDIENTS
Chemical Name CAS # EINECS #
Silica 7631-86-9 231-545-4
Ethylene/Methacrylate Copolymer --- ---
Isopropyl Titanium Triisostearate 61417-49-0 262-774-8
SECTION 3: HAZARD IDENTIFICATION
Effects and Symptoms:
Effects of Overexposure : May cause mechanical irritation to eyes.
Medical Conditions Aggravated by Exposure : Persons with respiratory conditions may be at increased risk.
Primary Route(s) of Entry : Inhalation and eye contact.
Chronic (Cancer Info.) : Not listed as a carcinogen by IARC, NTP, Z List or OSHA.
Target Organs : Lung.
Medical Conditions Aggravated : Individuals with pre-existing respiratory conditions such as
asthma or skin conditions such as dermatitis may be at greater
risk from exposure to material.
SECTION 4: FIRST AID MEASURES
Emergency First Aid:
Eye Contact : Flush eyes with water for at least 15 min. See physician if irritation persists.
Skin Contact : Flush skin with water.
Inhalation : Remove to fresh air. If breathing is difficult give oxygen. See physician.
Ingestion : None needed for small amounts. For large amounts, if conscious, give water and
call physician. Do not induce vomiting.
SECTION 5: FIRE FIGHTING MEASURES
Flash Point (Closed Cup) : N/A
Flammable Limits LEL/UEL % : N/A
Extinguishing Media : Water, Dry Chemical, Foam, and CO2
Special Fire Fighting Procedures : Self-contained breathing apparatus and protective clothing.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Personal Precautions : Avoid inhalation and eye contact.
Environmental Precautions: : Prevent material from contaminating soil or entering sewerage and drainage
systems.
Spill response : Use appropriate NIOHS/MSHA approved respirator. Wear gloves, goggles, and
lab coat. Carefully contain spilled material. Deposit spilled material in
appropriate waste container. Wash spill area with soap and water.
Page 1 of 3
KOBO Products, Inc.
DSPCS/20N-I2
SECTION 7: HANDLING AND STORAGE
Handling: Use with adequate ventilation. Avoid contact with eyes. Wash thoroughly after handling and
before mealtimes. Follow all MSDS and label precautions even after container is empty since it
may contain residual material.
Storage: Store containers closed in ambient location.
SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION
Exposure Levels: OSHA ACGIH
Component TWA PEL TWA TLV
6 mg/m3 10 mg/m3
Amorphous Silica
Personal Protection:
Eye Protection : Safety glasses with side shields or goggles
Skin Protection : Rubber gloves, wash at meals and end of shifts
Respiratory Protection : Use NIOSH/MSHA approved air purifying respirator as needed to control
exposure.
Ventilation : Provide adequate general mechanical exhaust.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (掳C) : N/A Percent Volatile By Vol. (%) : N/A
Freezing Point (掳C) : N/A Vapor Density (Air=1) : N/A
Melting Point (掳C) : N/A Evaporation Rate (Buac=1) : N/A
Vapor Pressure (mm hg) : N/A Solubility In Water : None
Bulk Density (g/cbi.) : 0.5 鈥?1.0 Appearance & Odor : Fine off-white powder
Charateristic odor
SECTION 10: STABILITY AND REACTIVITY
Stable : Yes
Hazardous Polymerization : Will not occur
Conditions To Avoid : Open flames and sparks, extreme heat.
Incompatibility : None
Hazardous Decomposition Products : Incomplete combustion can form CO, CO2
SECTION 11: TOXICOLOGICAL INFORMATION
Silica Copolymer
Skin Irritation : None No Data
Eye Irritation : Minimal irritation No Data
Oral Toxicity (rat) : LD50 > 10 g/kg (rat) LD50 > 19,000 mg/kg
Sensitization : No data No Data
SECTION 12: ECOLOGICAL INFORMATION
Copolymer - Acute toxicity LC50 for goldfish >5000 ppm. at 96 hours exposure. (Nontoxic)
SECTION 13: DISPOSAL CONSIDERATIONS
Method of Disposal : Dispose of in accordance with all applicable federal, state, and local regulations. Material
may be sent to an approved landfill or licensed treatment, storage, and disposal facility.
SECTION 14: TRANSPORT INFORMATION
DOT Regulation : Not regulated
Page 2 of 3
KOBO Products, Inc.
DSPCS/20N-I2
SECTION 15: REGULATORY INFORMATION
Silica:
United States : TSCA (Toxic Substance Control Act inventory): All components are listed on or exempt under
TSCA.
EPA RCRA : No information was found.
FDA : Silica and Silicon dioxide are cleared under 21 CFR for food-related uses.
Europe(EU) : EINECS (European Inventory of Existing Commercial Chemical Substances): All components
are listed on or exempt under EINECS or have been notified to ELINCS.
SECTION 16: OTHER INFORMATION
Hazardous Material Information System [Ratings Key: 4= Highest hazard, 0= Lowest hazard]
(U.S.A.)
Health 1
Fire Hazard 1
Reactivity 0
Personal Protection E
EU S phrases : S22鈥? Do not breathe dust.
S25鈥? Avoid contact with eyes.
S36鈥? Wear suitable protective clothing.
Date Prepared : June 20, 2000
Date Revised : June 13, 2002
Last Revision : December 19, 2003
By
Eric Smith
Note:
The statements made here are intended to describe the product with regard to necessary safety precautions. They do
not guarantee special characteristics. This information is furnished without warranty, expressed or implied, except
that it is accurate to the best of our current knowledge.
Page 3 of 3
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP