MATERIAL SAFETY DATA SHEET
SECTION 1: CHEMICAL PRODUCT IDENTIFICATION
: Kobo Products, Inc.
Manufacturer/Distributor
: 690 Montrose Avenue
Address
South Plainfield, NJ 07080 USA
: (908) 757-0033
Emergency Telephone #
: (908) 757-0905
Facsimile Number
: GC40S4
Trade Name
INCI Name/ Synonyms : Caprylic/Capric Triglyceride (And) Titanium Dioxide (And) Aluminum Hydroxide (And)
Stearic Acid
SECTION 2: COMPOSITION / INFORMATION ON INGREDIENTS
Ingredient CAS # EINECS #
Titanium Dioxide 13463-67-7 236-675-5
Caprylic/Capric Triglyceride 65381-09-1 265-724-3
Stearic Acid 57-11-4 200-313-4
Aluminum Hydroxide 21645-51-2 244-492-7
SECTION 3: HAZARD IDENTIFICATION
No known hazards
SECTION 4: FIRST AID MEASURES
Effects and Symptoms:
Medical Conditions Aggravated by Exposure : Persons with respiratory conditions may be at increased risk.
Primary Route(s) of Entry : Skin and eye contact.
Emergency First Aid:
Eye Contact : Flush eyes with water for at least 15 min. See physician if irritation persists.
Skin Contact : Flush skin with soap and water for at least 15 min.
Inhalation : Remove to fresh air. If breathing is difficult give oxygen. See physician.
Ingestion : None needed for small amounts. For large amounts, call physician. Do not induce
vomiting.
SECTION 5: FIRE FIGHTING MEASURES
FlashPoint (Closed Cup) : 232 掳 C
Flammable Limits LEL/UEL % : N/A
Extinguishing Media : Water spray, Dry Chemical, Foam, CO2. Water may cause foaming.
Special Fire Fighting Procedures : Self-contained breathing apparatus and protective clothing.
Unusual Fire and Explosion Hazards : None known
SECTION 6: ACCIDENTAL RELEASE MEASURES
Personal Precautions : Eye contact and excessive skin contact.
Environmental Precautions: : Prevent material from contaminating soil or entering sewerage and drainage systems.
Spill response : Use appropriate NIOHS/MSHA approved respirator. Wear chemical gloves, goggles,
and lab coat. Carefully contain spilled material. Deposit spilled material in appropriate
waste container. Wash spill area with soap and water.
SECTION 7: HANDLING AND STORAGE
Handling : Use with adequate ventilation. Avoid contact with eyes. Wash thoroughly after handling and
before mealtimes. Follow all MSDS and label precautions even after container is emptied since
it may contain residual material.
Storage : Store containers closed in ambient location.
SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION
Page 1 of 3
KOBO Products, Inc.
GC40S4
Exposure Levels: OSHA ACGIH
Component TWA PEL TWA TLV
15 mg/m3 10 mg/m3
TiO2
Personal Protection:
Eye Protection : Safety glasses with side shields or goggles
Skin Protection : Rubber gloves, wash at meals and end of shifts
Respiratory Protection : Use NIOSH/MSHA approved air-purifying respirator as needed to control exposure.
Ventilation : Provide adequate general mechanical exhaust.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (掳C) : 500 Percent Volatile By Vol. (%): 54%
Freezing Point (掳C) : N/A Vapor Density (Air=1) : N/A
Melting Point (掳C) : N/A Evaporation Rate (Buac=1) : N/A
Vapor Pressure (mmHg) : N/A Solubility In Water : Insoluble
Bulk Density (g/cbi.) : N/A Appearance & Odor : Viscous White Fluid,
Specific Gravity (H2O=1) : 1.2 Slight Odor
SECTION 10: STABILITY AND REACTIVITY
Stable : Yes
Hazardous Polymerization : Will not occur
Conditions to Avoid : Open flames and sparks, extreme heat, oxidizing materials.
Incompatibility : Oxidizing materials, strong acids, strong alkalis can cause a reaction.
Hazardous Decomposition Products : CO and CO2.
SECTION 11: TOXICOLOGICAL INFORMATION
Titanium Dioxide*
Skin Irritation (rabbit) : Dermal LD50 > 10 g/kg (Rabbit)
Primary Eye Irritation : Non-irritant
(rabbit) Average Draize score = 0.00
Acute Oral Toxicity (rat) : Non-toxic, LD50 > 25 g/kg (rat)
Inhalation LC50 : >6.82 mg/L (4 hour)
*: Trochimowicz.. et. Al., J. Appl. Tox., 8, 383-385 (1998)
SECTION 12: ECOLOGICAL INFORMATION
No data available
SECTION 13: DISPOSAL CONSIDERATIONS
Method of Disposal : Dispose of in accordance with all applicable federal, state, and local regulations. Material may
be sent to an approved landfill or licensed treatment, storage, and disposal facility.
SECTION 14: TRANSPORT INFORMATION
DOT Classification Not regulated.
TDG Classification Not regulated.
IMO/IMDG Classification Not regulated.
ICAO/IATA Not regulated.
Classification
ADR/IDRClassification Not regulated.
SECTION 15: REGULATORY INFORMATION
Page 2 of 3
KOBO Products, Inc.
GC40S4
International Regulations
DSCL (EEC) S16/36- keep away from sources of ignition-No Smoking and wear suitable protective clothing.
International List
Australia (NICNAS): TITANIUM DIOXIDE
JAPAN (MITI): TITANIUM DIOXIDE
Korea (TCCL): TITANIUM DIOXIDE
Philippines (RA6969): TITANIUM DIOXIDE
SECTION 16: OTHER INFORMATION
Hazardous Material Information System [Ratings Key: 4= Highest hazard, 0= Lowest hazard]
(U.S.A.)
Health 0
Fire Hazard 1
Reactivity 0
Personal Protection C
EU S phrases : S16 : keep away from sources of ignition-No Smoking
S36 : wear suitable protective clothing.
Date Prepared : June 15, 2000
Date Revised : January 10, 2003
Last Revision : May 24, 2004
By Eric Smith
Note:
The statements made here are intended to describe the product with regard to necessary safety precautions. They do not
guarantee special characteristics. This information is furnished without warranty, expressed or implied, except that it is
accurate to the best of our current knowledge.
Page 3 of 3
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP