MATERIAL SAFETY DATA SHEET
SECTION 1: CHEMICAL PRODUCT IDENTIFICATION
Manufacturer/Distributor : Kobo Products, Inc.
Address : 690 Montrose Avenue
So. Plainfield, NJ 07080
Emergency Telephone # : (908) 757-0033
Facsimile Number : (908) 757-0905
Trade Name : GMS-NS5
Chemical Name/ Synonyms : Mica (And) Silicone
SECTION 2: COMPOSTION / INFORMATION ON INGREDIENTS
Ingredients CAS # EINECS #
Mica 1200-26-2 310-127-6
Silicone ----- ------
SECTION 3: HAZARD IDENTIFICATION
No particular danger
SECTION 4: FIRST AID MEASURES
Effects and Symptoms:
Effects of Overexposure: May cause mechanical irritation to eyes.
Medical Conditions Aggravated by Exposure: Persons with respiratory conditions maybe at increased risk.
Primary Route(s) of Entry: Inhalation, Ingestion and eyes.
Emergency First Aid:
Eye Contact: Flush eyes with water for at least 15 min. See physician if irritation persists.
Skin Contact: Flush skin with soap and water for at least 15 min.
Inhalation: Remove to fresh air. If breathing is difficult give oxygen. See physician.
Ingestion: None needed for small amounts. For large amounts, if conscious, give water and call physician. Do not induce
vomiting.
SECTION 5: FIRE FIGHTING MEASURES
Flash Point (Closed Cup) : Non flammable, non-combustible.
Flammable Limits LEL/UEL % : N/A
Extinguishing Media : Water, Dry Chemical, Foam, CO2
Special Fire Fighting Procedures : Self-contained breathing apparatus fighting fires.
Unusual Fire And Explosion Hazards : Excessive concentrations of airborne dust may lead to an explosion hazard.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Personal Precautions : Eye contact and inhalation.
Environmental Precautions: : Prevent material from contaminating soil or entering sewerage and drainage systems.
Spill response : Use appropriate NIOHS/MSHA approved respirator. Wear chemical gloves, goggles, and lab coat.
Carefully contain spilled material. Deposit spilled material in appropriate waste container. Wash
spill area with soap and water.
SECTION 7: HANDLING AND STORAGE
Handling : Use with adequate ventilation. Avoid contact with eyes. Wash thoroughly after handling and before
mealtimes. Follow all MSDS and label precautions even after container is emptied since it may contain
residual material.
Storage : Store containers closed in ambient location.
SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION
Exposure Levels: OSHA ACGIH
Component TWA PEL TWA TLV
3 mg/m3 3 mg/m3
Mica
Personal Protection:
Page 1 of 2
KOBO Products, Inc.
GMS-NS5
Eye Protection : Safety glasses with sided shields or goggles
Skin Protection : Rubber gloves, wash at meals and end of shifts
Respiratory Protection : Use NIOSH/MSHA approved air-purifying respirator as needed to control exposure.
Ventilation : Provide adequate general mechanical exhaust.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (掳C) : N/A Percent Volatile By Vol. (%) : <1.0
Freezing Point (掳C) : N/A Vapor Density (Air=1) : N/A
Melting Point (掳C) : > 1000 Evaporation Rate (Buac=1) : 0
Vapor Pressure (mm hg) : N/A Solubility In Water : Insoluble
Bulk Density (g/cbi.) : 4 Appearance & Odor : Free flowing off-white powder with characteristic odor.
SECTION 10: STABILITY AND REACTIVITY
Stable: Yes
Hazardous Polymerization : Will not occur
Conditions To Avoid : Open flames and sparks, extreme heat, oxidizing materials
Incompatibility : Oxidizing materials and strong caustic materials can cause a reaction
Hazardous Decomposition Products : Incomplete combustion can form ,SiO2, CO, CO2, and dense smoke
SECTION 11: TOXICOLOGICAL INFORMATION
No data
SECTION 12: ECOLOGICAL INFORMATION
No data.
SECTION 13: DISPOSAL CONSIDERATIONS
Method of Disposal : Dispose of in accordance with all applicable federal, state, and local regulations. Material may be sent to an
approved landfill or licensed treatment, storage, and disposal facility.
SECTION 14: TRANSPORT INFORMATION
Classification: Non-hazardous
SECTION 15: REGULATORY INFORMATION
No information available
SECTION 16: OTHER INFORMATION
Date Prepared : April 12, 2002
Last Revised : January 10, 2003
Note: The statements made here are intended to describe the product with regard to necessary safety precautions. They do not
guarantee special characteristics. This information is furnished without warranty, expressed or implied, except that it is accurate to the
best of our current knowledge.
Page 2 of 2
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP