MATERIAL SAFETY DATA SHEET
SECTION 1: CHEMICAL PRODUCT IDENTIFICATION
: Kobo Products, Inc.
Manufacturer/Distributor
: 690 Montrose Avenue
Address
South Plainfield, NJ 07080
: (908) 757-0033
Emergency Telephone #
: (908) 757-0905
Facsimile Number
: KES35TSM
Trade Name
INCI Name : Titanium Dioxide (And) Ethyl Trisiloxane (And) Cyclopentasiloxane (And)
Caprylyl Methicone (And) Methicone (And) Silica (And) Lauryl PEG-9
Polydimethylsiloxyethyl Dimethicone
SECTION 2: COMPOSITION / INFORMATION ON INGREDIENTS
Ingredient: CAS #: EINECS #:
Titanium Dioxide 13463-67-7 236-675-5
Ethyl Trisiloxane 17861-60-8
Cyclopentasiloxane 541-02-6 208-764-9
Caprylyl Methicone 17955-88-3 241-881-3
Methicone 9004-73-3, 63148-57-2 ---
Silica 7631-86-9 231-545-4
Lauryl PEG-9 Polydimethylsiloxyethyl Dimethicone
SECTION 3: HAZARD IDENTIFICATION
EMERGENCY OVERVIEW:
Caution! Combustible Liquid and Vapor.
Keep away from heat, sparks, and flame.
Refer to other MSDS sections for detailed information.
SECTION 4: FIRST AID MEASURES
Emergency First Aid:
Eye Contact : Flush eyes with water for at least 15 min. See physician if irritation persists.
Skin Contact : Flush skin with soap and water for at least 15 min.
Ingestion : None needed for small amounts. For large amounts, call physician. Do not
induce vomiting.
SECTION 5: FIRE FIGHTING MEASURES
Flash Point (Closed Cup) : N/A
Flammable Limits LEL/UEL % : N/A
Extinguishing Media : CO2, Water spray, Dry Chemical, Foam
Special Fire Fighting Procedures : Self-contained breathing apparatus and protective clothing.
Unusual Fire And Explosion Hazards : Vapors are heavier than air and can travel along ground to remote
ignition sources.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Personal Precautions : Avoid skin and eye contact
Environmental Precautions: : Prevent material from contaminating soil or entering sewerage and drainage
systems.
Spill response : Use appropriate NIOHS/MSHA approved respirator. Wear chemical gloves,
goggles, and lab coat. Carefully contain spilled material . Deposit spilled
material in appropriate waste container. Wash spill area with soap and water.
Page 1 of 3
KOBO Products, Inc.
KES35TSM
SECTION 7: HANDLING AND STORAGE
Handling :
Use with adequate ventilation. Avoid contact with eyes. Wash thoroughly after handling and before
mealtimes. Follow all MSDS and label precautions even after container is emptied since it may contain
residual material.
Storage :
Store containers closed in ambient location.
SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION
Exposure Levels: OSHA ACGIH
Component TWA PEL TWA TLV
15 mg/m3 10 mg/m3
TiO2
Personal Protection:
Eye Protection : Safety glasses with side shields or goggles
Skin Protection : Rubber gloves, wash at meals and end of shifts
Respiratory Protection : Use NIOSH/MSHA approved air purifying respirator as needed to control
exposure.
Ventilation : Provide adequate general mechanical exhaust.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (掳C) : N/A Percent Volatile By Vol. (%) : 50
Freezing Point (掳C) : N/A Vapor Density (Air=1) : N/A
Melting Point (掳C) : N/A Evaporation Rate (Buac=1) : N/A
Vapor Pressure (mm hg) : N/A Solubility In Water : Insoluble
Specific Gravity (H2O=1) : N/A Appearance & Odor : White slurry,
Characteristic Odor
SECTION 10: STABILITY AND REACTIVITY
Stable : Yes
Hazardous Polymerization : Will not occur
Conditions To Avoid : Open flames and sparks
Incompatibility : Oxidizing material can cause a reaction
Hazardous Decomposition Products : SiO2, CO, CO2. May form acetaldehyde when heated which can cause
irritation to nose, eyes, and throat.
SECTION 11: TOXICOLOGICAL INFORMATION
Titanium Dioxide Cyclopentasiloxane
Skin Irritation : Dermal LD50 > 10 g/kg (Rabbit) Non-irritant
Acute Oral Toxicity : Non-toxic, LD50 > 25 g/kg (rat) LD50 > 5,000 mg/kg
Inhalation LC50 : >6.82 mg/L (4 hour) Saturated vapor, 8 hour, no death
Sensitization : No data Non-sensitizing
SECTION 12: ECOLOGICAL INFORMATION
No data is available.
SECTION 13: DISPOSAL CONSIDERATIONS
Method of Disposal : Dispose of in accordance with all applicable federal, state, and local regulations. Material
may be sent to an approved landfill or licensed treatment, storage, and disposal facility.
SECTION 14: TRANSPORT INFORMATION
DOT SHIPPING NAME: FOR BULK CONTAINERS (>119 GAL) ONLY: COMBUSTIBLE
Page 2 of 3
KOBO Products, Inc.
KES35TSM
LIQUID N.O.S. (CYCLOPENTASILOXANE)
11 DOT HAZARD CLASS: BULK CONTAINERS ONLY: COMBUSTIBLE LIQUID
DOT LABEL(S): NONE
UN/NA NUMBER: FOR BULK CONTAINERS ONLY: NA1993
PLACARDS: FOR BULK CONTAINERS ONLY: COMBUSTIBLE
IATA:
NOT REGULATED BY IATA
IMO IMDG-code: NA
EMS No: NA
EUROPEAN CLASS:
RID (OCTI): NA
ADR (ECE) : NA
RAR (IATA): NA
SECTION 15: REGULATORY INFORMATION
No information available
SECTION 16: OTHER INFORMATION
Hazardous Material Information System [Ratings Key: 4= Highest hazard, 0= Lowest hazard]
(U.S.A.)
Health 1
Fire Hazard 1
Reactivity 0
Personal Protection C
Date Prepared : October 6, 2006
By Eric Smith
Note:
The statements made here are intended to describe the product with regard to necessary safety precautions. They do
not guarantee special characteristics. This information is furnished without warranty, expressed or implied, except
that it is accurate to the best of our current knowledge.
Page 3 of 3
|