MATERIAL SAFETY DATA SHEET
SECTION 1: CHEMICAL PRODUCT IDENTIFICATION
Manufacturer/Distributor : Kobo Products, Inc.
Address : 690 Montrose Avenue, So. Plainfield, NJ 07080
Emergency Telephone # : (908) 757-0033 Facsimile Number : (908) 757-0905
Trade Name : ZnO FSF-11S4
Chemical Name/ Synonyms : Zinc Oxide (And) Triethoxy Caprylylsilane
SECTION 2: COMPOSTION / INFORMATION ON INGREDIENTS
Chemical Name CAS # EINECS #
Zinc Oxide 1314-13-2 215-222-5
Triethoxy Carpylylsilane 2943-75-1 220-941-2
SECTION 3: HAZARD IDENTIFICATION
No particular danger
SECTION 4: FIRST AID MEASURES
Effects and Symptoms:
Medical Conditions Aggravated by Exposure : Persons with respiratory or skin conditions may be at increased
risk.
Primary Route(s) of Entry : Inhalation or skin and eye contact.
Emergency First Aid:
Eye Contact : Flush eyes with water for at least 15 min. See physician if irritation persists.
Skin Contact : Flush skin with soap and water for at least 15 min.
Inhalation : Remove to fresh air. If breathing is difficult give oxygen. See physician.
Ingestion : None needed for small amounts. For large amounts, if conscious, give milk to
drink, induce vomiting, and call physician.
SECTION 5: FIRE FIGHTING MEASURES
Flash Point (Closed Cup) : N/A
Flammable Limits LEL/UEL % : N/A
Extinguishing Media : Water, Dry Chemical, Foam, CO2
Special Fire Fighting Procedures : Self-contained breathing apparatus and protective clothing.
Unusual Fire And Explosion Hazards : May burn or explode upon ignition if suspended in air as a dust.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Personal Precautions : Avoid skin and eye contact
Environmental Precautions : Prevent material from contaminating soil or entering sewerage and drainage systems.
Spill response : Use appropriate NIOHS/MSHA approved respirator. Wear chemical gloves, goggles,
and lab coat. Carefully contain spilled material. Deposit spilled material in
appropriate waste container. Wash spill area with soap and water.
SECTION 7: HANDLING AND STORAGE
Handling : Use with adequate ventilation. Avoid contact with eyes. Wash thoroughly after handling and
before mealtimes. Follow all MSDS and label precautions even after container is emptied since it
may contain residual material.
Storage : Store containers closed in ambient location.
SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION
Exposure Levels: OSHA ACGIH
Component OSHA鈥檚 PEL ACGIH鈥檚 TLV
Page 1 of 2
KOBO Products, Inc.
ZnO FSF-11S4
15 mg/m3 10mg/m3
ZnO Nuisance Dust
5 mg/m3 5 mg/m3
Respirable Dust
Personal Protection:
Eye Protection : Safety glasses with side shields or goggles
Skin Protection : Rubber gloves, wash at meals and end of shifts
Respiratory Protection : Use NIOSH/MSHA approved air purifying respirator as needed to control exposure.
Ventilation : Provide adequate general mechanical exhaust.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (掳C) : N/A Percent Volatile By Vol. (%) : None
Freezing Point (掳C) : N/A Vapor Density (Air=1) : N/A
Melting Point (掳C) : > 1000掳C Evaporation Rate (Buac=1) : N/A
Vapor Pressure (mm hg) : N/A Solubility In Water : Insoluble
Appearance & Odor : White powder. Characteristic odor
SECTION 10: STABILITY AND REACTIVITY
Stable : Yes
Hazardous Polymerization : Will not occur
Conditions To Avoid : Fire or excess heat
Incompatibility : Acids, alkalis and strong oxidizers
Hazardous Decomposition Products : None.
SECTION 11: TOXICOLOGICAL INFORMATION
Zinc Oxide
Skin Irritation : None when 0.5 mL/patch of 50 % water dispersion
Primary Eye Irritation : Slight stimilus, Draize Score= 6.67
Acute Oral Toxicity : Non-toxic, LD 50 > 2 g/kg (rat)
Acute Skin Toxicity : Non-toxic, LD 50 > 2 g/kg (rat)
Mutagenicity : Negative (Ames test)
SECTION 12: ECOLOGICAL INFORMATION
No known effect on environment is expected under normal use.
SECTION 13: DISPOSAL CONSIDERATIONS
Method of Disposal : Dispose of in accordance with all applicable federal, state, and local regulations. Material
may be sent to an approved landfill or licensed treatment, storage, and disposal facility.
SECTION 14: TRANSPORT INFORMATION
Not regulated as hazardous material. No special precautions are required.
SECTION 15: REGULATORY INFORMATION
No information available
SECTION 16: OTHER INFORMATION
Date Prepared : May 1, 2002
Note:
The statements made here are intended to describe the product with regard to necessary safety precautions. They do
not guarantee special characteristics. This information is furnished without warranty, expressed or implied, except
that it is accurate to the best of our current knowledge.
Page 2 of 2
|