MATERIAL SAFETY DATA SHEET
SECTION 1: CHEMICAL PRODUCT IDENTIFICATION
: Kobo Products, Inc.
Manufacturer/Distributor
: 690 Montrose Avenue
Address
South Plainfield, NJ 07080
: (908) 757-0033
Emergency Telephone #
: (908) 757-0905
Facsimile Number
: ZnO-USP1-I2, ZnO-USP1-I2P
Trade Name
Chemical Name/ Synonyms : Zinc Oxide (And) Isopropyl Titanium Triisostearate
INCI Name : Zinc Oxide (And) Isopropyl Titanium Triisostearate
SECTION 2: COMPOSTION / INFORMATION ON INGREDIENTS
Chemical Name CAS # EINECS #
Zinc Oxide 1314-13-2 215-222-5
Isopropyl Titanium Triisostearate 61417-49-0 262-774-8
SECTION 3: HAZARD IDENTIFICATION
No particular danger
SECTION 4: FIRST AID MEASURES
Effects and Symptoms:
Effects of Overexposure : May cause mechanical irritation to eyes.
Medical Conditions Aggravated by Exposure : Persons with respiratory conditions may be at increased risk.
Primary Route(s) of Entry : Inhalation.
Emergency First Aid:
Eye Contact : Flush eyes with water for at least 15 min. get medical attention.
Skin Contact : Wash exposed areas with soap and water.
Inhalation : Remove to fresh air
Ingestion : Do not induce vomiting. Get medical attention.
SECTION 5: FIRE FIGHTING MEASURES
Flash Point (Closed Cup) : NA
Flammable Limits LEL/UEL % : N/A
Extinguishing Media : Water, fog, and foam, dry chemical or CO2
Special Fire Fighting Procedures : None.
Unusual Fire and Explosion Hazards : None
SECTION 6: ACCIDENTAL RELEASE MEASURES
Personal Precautions : Eye contact and excessive skin contact.
Environmental Precautions: : N/A
Spill response : Sweep material into a closeable container for disposal.
SECTION 7: HANDLING AND STORAGE
Handling : Keep container closed when not in use. Avoid inhalation of dust and contact with eyes.
Storage : Store in a dry cool area.
SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION
Exposure Levels:
Component OSHA鈥檚 PEL ACGIH鈥檚 TLV
15 mg/m3 10mg/m3
ZnO Nuisance Dust
5 mg/m3 5 mg/m3
Respirable Dust
Personal Protection:
Page 1 of 2
KOBO Products, Inc.
ZnO-USP1-I2, ZnO-USP1-I2P
Eye Protection : Safety glasses with side shields or goggles
Skin Protection : Rubber or plastic film gloves. Wash hands after handling
Protective clothing : Rubber apron
Ventilation : Provide adequate local mechanical exhaust.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (掳C) : N/A Percent Volatile By Vol. (%) : N/A
Freezing Point (掳C) : N/A Vapor Density (Air=1) : N/A
Melting Point (掳C) : N/A Evaporation Rate (Buac=1) : N/A
Vapor Pressure (mm hg) : N/A Solubility In Water : Not soluble
Bulk Density (g/cbi.) : N/A
Appearance & Odor : White powder, Odorless
Specific Gravity (H2O=1) : N/A
SECTION 10: STABILITY AND REACTIVITY
Stable : Yes
Hazardous Polymerization : May not occur
Conditions to Avoid : None.
Incompatibility : None.
Hazardous Decomposition Products : None.
SECTION 11: TOXICOLOGICAL INFORMATION
ZnO Isopropyl Titanium Triisostearate
Skin Irritation : None when 0.5 mL/patch of 50 % water dispersion Mild irritation
Primary Eye Irritation : Slight stimilus, Draize Score= 6.67 Minimal irritation
Acute Oral Toxicity : Non-toxic, LD50 > 2 g/kg (rat) Single dose LD 50 >2 g/kg (rat)
Acute Skin Toxicity : Non-toxic, LD 50 > 2 g/kg (rat) No data
Mutagenicity : Negative (Ames test) No data
Sensitization : No data None
SECTION 12: ECOLOGICAL INFORMATION
No Data
SECTION 13: DISPOSAL CONSIDERATIONS
Method of Disposal : Dispose of in accordance to federal, state and local regulations. Do not discharge into waterways or
sewer system.
SECTION 14: TRANSPORT INFORMATION
DOT Classification : Not Regulated
SECTION 15: REGULATORY INFORMATION
No information is available.
SECTION 16: OTHER INFORMATION
Date Prepared : January 30, 2004
Note:
The statements made here are intended to describe the product with regard to necessary safety precautions. They do not
guarantee special characteristics. This information is furnished without warranty, expressed or implied, except that it is accurate
to the best of our current knowledge.
Page 2 of 2
|