LILLY INDUSTIES INC -- 7-203 SUPERCRYL INTERMIX CLEAR
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BXMVK
MSDS NAME: 7-203 SUPERCRYL INTERMIX CLEAR
Responsible Party
Name: LILLY INDUSTIES INC
Address: 2601 EAST HENRY AVENUE
City: TAMPA FL 33610-5000
Info Phone: 813-236-5594
Emergency Phone Number: 813-236-5594
Preparer's Name: E F GODBEY
Published: Y
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Name: LILLY INDUSTIES INC
Address: 2601 EAST HENRY AVENUE
City: TAMPA FL 33610-5000
=======================================================
Contractor Summary
=======================================================
Name: LILLY INDUSTIES INC
Address: 2601 EAST HENRY AVENUE
City: TAMPA FL 33610-5000
Phone: 813-236-5594
=======================================================
Ingredients
=======================================================
Cas: 1330-20-7
RTECS #: ZE2100000
Name: XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *95-2*
% Wt: 26
Other REC Limits: 100 PPM
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM, SKIN
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 64741-41-9
Name: NAPHTHA (PETROLEUM), HEAVEY STRAIGHT RUN NAPHTHA (PETROLEUM) C6-C12
% Wt: 15
OSHA PEL: 500 PPM
ACGIH TLV: 100 PPM
------------------------------
Cas: 64742-94-5
RTECS #: WF3100000
Name: HEAVY AROMATIC SOLVENT NAPHTHA PETROLEUM * 95-2 *
% Wt: <5
OSHA PEL: 10 PPM
ACGIH TLV: 10 PPM
------------------------------
Cas: 64742-48-9
Name: ISOPARAFFINIC HYDROCARBONS (NAPHTHA PETROLEUM), HYDROTREATED HEAVY, NON
AROMATIC HEAVY NAPHTHA) ISOPAR G
% Wt: <5
ACGIH TLV: 300 PPM
------------------------------
Cas: 100-41-4
RTECS #: DA0700000
Name: ETHYL BENZENE *95-2*
% Wt: 9
Other REC Limits: 100 PPM
OSHA PEL: 435 MG/CUM
ACGIH TLV: 434 MG/CUM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHALATION: RESPIRATORY IRRITATION, CNS EFFECTS &
POSSIBLE ASPHYXIATION. EYES: IRRITANT. SKIN: IRRITANT, DERMATITIS. INGESTION:
GI IRRITANT. ASPIRATION OF MATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL PN
EUMONITIS WHICH CAN BE FATAL. OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN, CNS, LIVER & KIDNEY DAMAGE.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: NAUSEA, IRRITATION, DIZZINESS, WEAKNESS,
FATIGUE, HEADACHE, UNCONSCIOUSNESS, ASPHYXIATION, REDNESS, TEARING, BLURRED
VISION, DEFATTING, VOMITING, DIARRHEA
Medical Cond Aggravated By Exposure: PRE-EXISTING EYE, SKIN, LIVER, KIDNEY
& RESPIRATORY DISORDERS.
First Aid: EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. SKIN: WASH W/SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED, GIVE
CPR. INGESTION: ASPIRATION HAZARD. DON'T INDUCE VOMITING. K EEP WARM &
QUIET. OBTAIN MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: STAY UPWIND & WEAR PROTECTIVE EQUIPMENT.
STOP/CONTAIN LEAK SAFELY. KEEP ALL IGNITION SOURCES AWAY. VENTILATE AREA. USE
NONSPARKING TOOLS FOR CLEAN UP. DON'T FLUSH TO SEWER, WATERSHED/WATERWAY.
Waste Disposal Methods: DON'T INCINERATE CLOSED CONTAINERS. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS. FLAMMABLE LIQUID UN1263.
Handling And Storage Precautions: STORE LARGE QUANTITIES IN BUILDINGS DESIGNED
TO COMPLY W/OSHA. KEEP FROM IGNITION SOURCES. CONTAINERS SHOULD BE GROUNDED
WHEN POURING.DON'T STORE>120F
Other Precautions: KEEP CONTAINERS CLOSED WHEN NOT IN USE & IN AN UPRIGHT
POSITION. DON'T TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN. EMPTY
CONTAINERS RETAIN HAZARDOUS RESIDUES/EXPLOSIVE VAPORS. DON'T CUT/PUNCTURE/W
ELD ON/NEAR CONTAINERS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 54F
Lower Limits: 0.7
Upper Limits: 6.6
Extinguishing Media: FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures: WEAR FULL PROTECTIVE EQUIPMENT & SELF CONTAINED
BREATHING APPARATUS. WATER SPRAY W/FOG NOZZLES IS PREFERABLE TO COOL CLOSED
CONTAINERS WHEN EXPOSED TO HEAT.
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY EXPLODE IF EXPOSED TO
EXTREME HEAT. VAPORS ARE >AIR & MAY TRAVEL ALONG THE FLOOR BEFORE
IGNITION, FLASHING BACK TO VAPOR SOURCE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF EXPOSURE LIMIT IS EXCEEDED, USE A NIOSH/MSHA
APPROVED AIR SUPPLIED RESPIRATOR IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL.
Ventilation: SUFFICIENT MECHANICAL (GENERAL/LOCAL EXHAUST) TO MAINTAIN EXPOSURE
LIMITS BELOW TLVS.
Protective Gloves: NITRILE RUBBER
Eye Protection: CHEMICAL SPLASH GOGGLES/SAFETY GLASSES
Other Protective Equipment: IMPERVIOUS BOOTS & CLOTHING
Work Hygienic Practices: REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
ALWAYS WASH HANDS AFTER USING PRODUCTS & BEFORE EATING/SMOKING.
Supplemental Safety and Health: INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING THE CONTENTS MAY BE HARMFUL/FATAL. NEVER USE
WELDING/CUTTING TORCHES ON/NEAR CONTAINERS EVEN EMPTY. FOR INDUSTRIAL USE
ONLY.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 250-352F
Vapor Density: >1
VOC Pounds/Gallon: 4.39
VOC Grams/Liter: 526
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: INSOLUBLE
Appearance and Odor: VISCOUS LIQUID W/SOLVENT ODOR
Percent Volatiles by Volume: 61.01
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, OPEN FLAMES, STATIC ELECTRICITY, ELECTRICAL
EQUIPMENT, SPARKS & OTHER IGNITION SOURCES
Materials To Avoid: STRONG ACIDS, ALKALIES & OXIDIZERS
Hazardous Decomposition Products: FUMES CONTAINING ORGANIC ACIDS, CO, CO2,
SMOKE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOL ORGANIC CMPD: 4.39 LB/GAL (526 GM/L)
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: 7-203 SUPERCRYL INTERMIX CLEAR
Company: LILLY INDUSTIES INC
Street: 2601 EAST HENRY AVENUE
City: TAMPA FL
Zipcode: 33610-5000
Health Emergency Phone: 813-236-5594
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: INHALATION: RESPIRATORY IRRITATION, CNS EFFECTS &
POSSIBLE ASPHYXIATION. EYES: IRRITANT. SKIN: IRRITANT, DERMATITIS. INGESTION:
GI IRRITANT. ASPIRATION OF MATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL PN
EUMONITIS WHICH CAN BE FATAL. OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN, CNS, LIVER & KIDNEY DAMAGE. NAUSEA, IRRITATION,
DIZZINESS, WEAKNESS, FATIGUE, HEADACHE, UNCONSCIOUSNESS, ASP HYXIATION,
REDNESS, TEARING, BLURRED VISION, DEFATTING, VOMITING, DIARRHEA
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|