mineral oil, petroleum distillate, solvent dewaxed (severe), heavy solvent dewaxed residual oil (petroleum) solvent deasphalted residual petroleum oil supdat:than 1/2 cup full of this matl is swallowed, give quantities of spill proc:ecologists. this matl will float on water. absorb matls & ing 5:spills may need to be rptd to natl response center (800/424-8802). ing 6:it has contacted may be haz to animal/aquatic life. waste disp meth:introduced into waste-water treatment sys, chem & ing 8:spill matl is biodegradable if gradually exposed to ing 9:include land farming, incineration, and land disposal, if hygiene pract:soap & water before eating, drinking, smoking/use of ing 11:solvents, kerosene, or harsh abrasive skin cleaners for washing ing 12:work if general cont occurs. remove oil-soaked clthg & launder ing 13:leather gloves & shoes.
LYONDELL PETROCHEMICAL CO -- ARCO CAR OIL 54
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CFSTQ
MSDS NAME: ARCO CAR OIL 54
Responsible Party
Name: LYONDELL PETROCHEMICAL CO
Address: 12000 LAWNDALE AVE
Box: 2451
City: HOUSTON TX 77252-2451
Info Phone: 800-525-4692
Emergency Phone Number: 800-245-4532;800-424-9300(CHEMTREC)
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: LYONDELL PETROCHEMICAL CO
Address: 1221 MCKINNEY AVE SUITE 1600
Box: 3646
City: HOUSTON TX 77253-3646
Phone: 713-652-7200
=======================================================
Ingredients
=======================================================
Cas: 64742-65-0
RTECS #: PY8038501
Name: MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED (SEVERE), HEAVY
PARAFFINIC
% Wt: >85
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 64742-62-7
Name: SOLVENT DEWAXED RESIDUAL OIL (PETROLEUM)
% Wt: <10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 64741-95-3
Name: SOLVENT DEASPHALTED RESIDUAL PETROLEUM OIL
% Wt: <5
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Name: SUPDAT:THAN 1/2 CUP FULL OF THIS MATL IS SWALLOWED, GIVE QUANTITIES OF
WATER. INDUCE VOMIT, & OBTAIN MED ATTN.
-----------------------------
Name: SPILL PROC:ECOLOGISTS. THIS MATL WILL FLOAT ON WATER. ABSORB MATLS &
PADS CAN BE USED. COMPLY W/ALL APPLIC LAWS.
-----------------------------
Name: ING 5:SPILLS MAY NEED TO BE RPTD TO NATL RESPONSE CENTER (800/424-8802).
SPILLED MATL & ANY SOIL/WATER WHICH
-----------------------------
Name: ING 6:IT HAS CONTACTED MAY BE HAZ TO ANIMAL/AQUATIC LIFE.
-----------------------------
Name: WASTE DISP METH:INTRODUCED INTO WASTE-WATER TREATMENT SYS, CHEM &
BIOLOGICAL OXYG DEMAND WILL LIKELY INCREASE.
-----------------------------
Name: ING 8:SPILL MATL IS BIODEGRADABLE IF GRADUALLY EXPOSED TO
MICRO-ORGANISMS. POTNTL TREATMENT & DISP METHODS
-----------------------------
Name: ING 9:INCLUDE LAND FARMING, INCINERATION, AND LAND DISPOSAL, IF
PERMITTED.
-----------------------------
Name: HYGIENE PRACT:SOAP & WATER BEFORE EATING, DRINKING, SMOKING/USE OF
TOILET FACILITIES. DO NOT USE GASOLINE,
-----------------------------
Name: ING 11:SOLVENTS, KEROSENE, OR HARSH ABRASIVE SKIN CLEANERS FOR WASHING
EXPOSED SKIN AREAS. TAKE SHOWER AFTER
-----------------------------
Name: ING 12:WORK IF GENERAL CONT OCCURS. REMOVE OIL-SOAKED CLTHG & LAUNDER
BEFORE REUSE. LAUNDER/DISCARD CONTAMD
-----------------------------
Name: ING 13:LEATHER GLOVES & SHOES.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: INHAL: NO SIGNIFICANT ADVERSE HLTH EFTS ARE
EXPECTED TO OCCUR UPON SHORT-TERM EXPOS. EYE CONT: TEST ON SIMILAR MATLS
SUGGEST THAT THIS PROD IS NOT IRRITATING UPON SHORT-TERM EXPOS. SKIN ABSORP:
TESTS ON SIMILAR MATLS SUGGEST THAT NOSIGNIFICANT ADVERSE HLTH EFTS ARE
EXPECTED TO OCCUR UPON SHORT-(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: EXPOS. SKIN: PRLNGD/RPTD SKIN
CONT W/SIMILAR MATLS HAS PRDCED MILD IRRIT & INFLAMM. INGEST: TESTS ON
SIMILAR MATLS SUGGEST THAT NO SIGNIFICANT ADVERSE HLTH EFTS ARE EXPECTED TO
OCCUR UPON SH ORT-TERM EXPOS.
Medical Cond Aggravated By Exposure: PERSONNEL WITH PRE-EXISTING SKIN DISORDERS
SHOULD AVOID CONTACT WITH THIS PRODUCT.
First Aid: INHAL:IMMED REMOVE PERS FROM CONTAMD AREA TO FRESH AIR. OBTAIN MED
ATTN IF THERE ARE SIGNS OF BRTHG DFCLTYS. EYE:FLUSH W/CLEAN, LOW-PRESS WATER
FOR @ LST 15 MINS, OCCASNLY LIFTING EYELIDS. IF PAIN/RED NESS PERSISTS AFTER
FLUSHING, OBTAIN MED ATTN. SKIN:REMOVE BY WIPING; THEN WASH SKIN THORO
W/PLENTY OF SOAP & WATER. REMOVE CONTAMD CLTHG & THORO CLEAN BEFORE
REUSE. DISCARD CONTAMD LEATHER (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: CONTAIN SPILL & PVNT IT FROM ENTERING ALL WATER
BODIES, IF POSS. SAFELY STOP FLOW OF SPILL. EVAC NON-ESSNTL PERS FROM IMMED
SPILL AREA DUE TO SLIPPING HAZARDS. IN URBAN AREA, CLEANUP AS SOON AS POSS:
IN NATRL ENVIR, CLEANUP ON ADVICE FROM
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: MAXIMIZE PROD RECOVERY FOR RESUSE/RECYCLING. CNDTNS OF
USE MAY CAUSE MATL TO BECOME "HAZ WASTE", AS DEFINED BY STATE OR FED LAWS.
USE APPRVD TREATMENT, TRANSPORTERS, & DISP SITES IN COMPLIANCE W/ALL A
PPLIC FED, STATE & LOCAL LAWS. IF SPILLIS
Handling And Storage Precautions: TO AVOID PROD DEGRADATION, WATER CONTAM
SHOULD BE AVOIDED & MIN FEASIBLE HNDLG TEMPS SHOULD BE MAINTAINED.
Other Precautions: PRIODS OF EXPOS TO HIGH TEMPS (>200F) SHOULD BE
MINIMIZED. PROD DEGRADATION MIGHT INCR HLTH HAZ RISKS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point Text: 400F,204C
Extinguishing Media: DRY CHEMICAL & CARBON DIOXIDE. FOAM AND WATER FOG ARE
EFFECTIVE BUT MAY CAUSE FROTHING.
Fire Fighting Procedures: NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N). IF
FIREFIGHTERS CANNOT WORK UPWIND TO FIRE, RESP EQUIP MUST BE WORN. COOL TANKS
& CNTNRS EXPOSED TO FIRE (SUPDAT)
Unusual Fire/Explosion Hazard: SLIGHTLY COMBUST! OSHA/NFPA CLASS-IIIB COMBUST
LIQ. WHEN HEATED ABOVE ITS FLASH POINT, THIS MATL WILL RELEASE FLAMM VAPS
WHICH CAN BURN IN OPEN/BE EXPLO(SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE IS NEEDED UNDER ANTIC USE CNDTNS W/ADEQ VENT. IF
EXPOS EXCEEDS OCCUP EXPOS LIMITS, FOLLOW OSHA STDS OR EQUIVALENT & WEAR
PROPER NIOSH APPROVED RESPIRATORY EQUIPMENT.
Ventilation: USE ADEQ VENT TO KEEP OIL MISTS OF THIS MATL BELOW APPLIC STD(S).
Protective Gloves: IMPERVIOUS GLOVES.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: HANDS/OTHER POTNTL SKIN CONT AREAS SHOULD BE WASHED
W/SOAP & WATER WHEN LEAVING WORK. WASH HANDS W/PLENTY OF
Supplemental Safety and Health: FIRE FIGHT PROC:W/WATER. BURNING LIQ WILL FLOAT
ON WATER. NOTIFY APPROP AUTH IF LIQ ENTER SEWER/WATERWAYS. EXPLO HAZ:IN
CONFINED SPACES IF EXPOSED TO IGNIT SOURCE. MISTS/SPRAYS MAY BE FLAMM @ TEMPS
BE LOW NORM FLASH POINT. KEEP AWAY FROM EXTREME HEAT & OPEN FLAME. FIRST
AID PROC:GLOVES & SHOES. INGEST:IF MORE
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >600F,>316C
Vapor Pres: <0.1
Vapor Density: >10
Spec Gravity: 0.88 (H*2O=1)
Evaporation Rate & Reference: NOT KNOWN
Solubility in Water: NEGLIGIBLE
Appearance and Odor: DARK GREEN-COLORED LIQUID; LUBE OIL ODOR.
Percent Volatiles by Volume: NEGLIG
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: EXTREME HEAT & OPEN FLAME.
Materials To Avoid: STRONG ACIDS, ALKALIES, AND OXIDIZERS SUCH AS LIQUID
CHLORINE & OXYGEN.
Hazardous Decomposition Products: BURNING OR EXCESSIVE HEATING MAY PRODUCE
CARBON MONOXIDE AND OTHER HARMFUL SUBSTANCES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: ARCO CAR OIL 54
Company: LYONDELL PETROCHEMICAL CO
Street: 1221 MCKINNEY AVE SUITE 1600
PO Box: 3646
City: HOUSTON TX
Zipcode: 77253-3646
Health Emergency Phone: 800-245-4532;800-424-9300(CHEMTREC)
Label Required IND: Y
Date Of Label Review: 11/18/1997
Status Code: C
Label Date: 11/18/1997
Origination Code: G
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE - CLASS IIIB. ACUTE: MAY CAUSE MILD SKIN
IRRITATION FOLLOWING EXTENDED CONTACT. CHRONIC: NONE LISTED BY MANUFACTURER.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.