DARWORTH CO -- POLYSEAMSEAL TUB & TILE ADHESIVE CAULK (PURE
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CJMJZ
MSDS NAME: POLYSEAMSEAL TUB & TILE ADHESIVE CAULK (PURE WHITE OR BONE/A
Responsible Party
Name: DARWORTH CO
Address: 7405 PRODUCTION DR
City: MENTOR OH 44060
Info Phone: 800-624-7767
Emergency Phone Number: 800-424-9300
Chemtrec IND/Phone: (800)424-9300
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: DARWORTH CO
Address: 7405 PRODUCTION DR
City: MENTOR OH 44060
Phone: 800-624-7767
=======================================================
Item Description Information
=======================================================
Item Name: POLYSEAMSEAL TUB & TILE ADHESIVE CAULK
=======================================================
Ingredients
=======================================================
Cas: 25265-77-4
RTECS #: UF6000000
Name: 2,2,4-TRIMETHYLPENTANEDIOL-1,3- MONOISOBUTYRATE (TRADE NAME TEXANOL)
% low Wt: 3.
% high Wt: 4.
------------------------------
Cas: 123-86-4
RTECS #: AF7350000
Name: N-BUTYL ACETATE
% low Wt: 4.
% high Wt: 5.
OSHA PEL: 710 MG/M3;150 PPM
ACGIH TLV: 713 MG/M3;150 PPM
ACGIH STEL: 950 MG/M3;200 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 57-55-6
RTECS #: TY2000000
Name: PROPYLENE GLYCOL
% low Wt: 2.
% high Wt: 3.
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: N-BUTYL ACETATE - EYE CONTACT CAUSES SEVERE
IRRITATION. VAPORS MAY BE IRRITATING AND CAUSE DIZZINESS, HEADACHE, NAUSEA,
VOMITING, AND NARCOSIS. EFTS OF CHRONIC OVEREXPOSURE: REFER TO SECTION TW O.
OVEREXPOSURE TO THIS MATERIAL (OR ITS COMPONENTS) HAS APPARENTLY BEEN FOUND
TO CAUSE FOLLOWING EFTS IN LABORATORY ANIMALS:, LIVER ABNORMALITIES, KIDNEY
DAMAGE, LUNG DAMAGE, BRAIN DAMAGE, BLOOD ABNO RMALITIES. REPORTS HAVE
ASSOCIATED REPEATED AND PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH
PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE (INHALATION).
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: SKIN - PEOPLE W/ PRE-EXISTING SKIN
DISORDERS MAY BE MORE SUSCEPTIBLE TO EFTS OF PROD. INHALATION - PEOPLE W/
PRE-EXISTING RESP DISORDERS SUCH AS ASTHMA, MAY BE AGGRAVATED BY EXPOSURE TO
MATERIAL.
First Aid: EYE CONT: IMMED FLUSH W/LARGE QTYS OF WATER FOR AT LST 15 MINUTES.
SEEK IMMEDIATE MED ATTENTION. SKIN CONT: IF THIS PROD COMES IN CONT W/SKIN,
WASH W/SOAP & LG QTYS OF WATER & SEEK MED ATTENTION IF IR RITATION
PERSISTS. INHAL: IF VICTIM EXHIBITS RESP DISTRESS, REMOVE VICTIM FROM CONTAMD
AREA. IF BREATHING STOPS, BEGIN ARTIFICIAL RESPIRATION AND SEEK IMMEDIATE MED
ATTENTION. INGEST: IF PRODUCT IS CO NSUMED, INDUCE VOMITING IF VICTIM IS
CONSCIOUS. SEEK IMMED MEDICAL ADVICE/ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: KEEP SOURCES OF IGNITION AND HOT METAL SURFACES
ISOLATED FROM SPILL. SPILLED MATERIAL MAY BE REMOVED WITH INERT ABSORBENT AND
SHOVEL. DISPOSE OF PRODUCT IN ACCORDANCE WITH APPLICABLE LOCAL, COUNTY, ST
ATE AND FEDERAL REGULATIONS.
Waste Disposal Methods: DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL REGULATIONS (FP N).
Handling And Storage Precautions: KEEP PRODUCT CONTAINERS COOL, DRY AND AWAY
FROM SOURCES OF IGNITION. KEEP FROM FREEZING. USE AND STORE PRODUCT WITH
ADEQUATE VENTILATION. KEEP PRODUCT CONTAINERS CLOSED WHEN NOT IN USE.
Other Precautions: AVOID INHALATION OF VAPORS. AVOID PERSONAL CONTACT WITH THE
PRODUCT. PRODUCT MAY BE TOXIC TO TROPICAL FISH. LABEL PRECAUTIONS: CAUTION:
KEEP OUT OF REACH OF CHILDREN. DO NOT TAKE INTERNALLY.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: WATER, FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N). USE WATER TO COOL EXPOSED MATERIAL.
Unusual Fire/Explosion Hazard: KEEP WORK AREAS FREE OF HOT METAL SURFACES AND
OTHER SOURCES OF IGNITION.
=======================================================
Control Measures
=======================================================
Respiratory Protection: (REFER TO HAZARDOUS COMPONENTS SECTION). THE USE OF
RESPIRATORY PROTECTION DEPENDS ON VAPOR CONCENTRATIONS. IF ABOVE TLV/PEL (SEE
HAZARDOUS COMPONENTS SECTION), USE NIOSH APPROVED ORGANIC VAPOR RESPIR ATOR.
Ventilation: LOC EXHST: REQD IF GEN VENT PROVES INADEQ TO MAINTAIN SAFE VAPOR
CONCS. INDOORS: DO NOT USE IN CONFINED SPACE (SUPDAT)
Protective Gloves: RUBBER GLOVES IF PROT IS NEEDED BY SENSITIVE SKIN
INDIVIDUALS.
Eye Protection: ANSI APPROVED CHEMICAL WORKERS GOGGLES (FPN).
Other Protective Equipment: EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N). IMPERMEABLE APRONS AREA ADVISED TO PREVENT SKIN CONTACT.
Supplemental Safety and Health: VOC: 148 G/L. VENT: WITHOUT ADEQUATE MECHANICAL
VENT. SPECIAL: N/A. MECHANICAL: USE MECHANICAL GEN ROOM/LOC VENT IF NEC TO
MAINTAIN EMPLOYEE EXPOSURE BELOW PEL'S & TLV'S (NOTED IN HAZ COMPONENTS
SECTI ON). OUTDOORS: MECHANICAL VENT OR RESPIRATORY PROTECTION NOT NORMALLY
REQUIRED.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: =100.C, 212.F
Vapor Pres: 15 MM HG @ 25C
Spec Gravity: 1.25
VOC Grams/Liter: 148
Evaporation Rate & Reference: LESS THAN ETHER
Solubility in Water: MISCIBLE
Appearance and Odor: WHITE OR COLORED PASTE WITH A SWEET BANANA ODOR.
Percent Volatiles by Volume: 45.5
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: THIS PRODUCT IS STABLE IN MOST CONDITIONS. USE
THIS PRODUCT ONLY AS RECOMMENDED BY MANUFACTURER.
Materials To Avoid: AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: THERMAL DECOMPOSITION IN THE PRESENCE OF AIR
MAY YIELD CARBON MONOXIDE AND/OR CARBON DIOXIDE. UNDER SEVERE THERMAL
DEGRADATION LOW MOLECULAR WEIGHT HYDROCARBONS MAY BE FORMED.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information:: HEALTH 1, FLAMMABILITY 1, REACTIVITY 0, PERSONAL PROTECTION
0.
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: POLYSEAMSEAL TUB & TILE ADHESIVE CAULK (PURE WHITE OR BONE/A
Company: DARWORTH CO
Street: 7405 PRODUCTION DR
City: MENTOR OH
Zipcode: 44060
Health Emergency Phone: 800-424-9300
Label Required IND: Y
Date Of Label Review: 06/24/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: N-BUTYL ACETATE - EYE CONTACT CAUSES SEVERE
IRRITATION. VAPORS MAY BE IRRITATING AND CAUSE DIZZINESS, HEADACHE, NAUSEA,
VOMITING, AND NARCOSIS. EFTS OF CHRONIC OVEREXPOSURE: REFER TO SECTION TW O.
OVEREXPOSURE TO THIS MATERIAL (OR ITS COMPONENTS) HAS APPARENTLY BEEN FOUND
TO CAUSE FOLLOWING EFTS IN LABORATORY ANIMALS: LIVER ABNORMALITIES, KIDNEY
DAMAGE, LUNG DAMAGE, BRAIN DAMAGE, BLOOD ABNOR MALITIES. REPORTS HAVE
ASSOCIATED REPEATED AND PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH
PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE (INHALATION).
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|