LENMAR, INC -- P-524 RED FLAT LACQUER TT-L-20 31116
=======================================================
Material Safety Data Sheet
=======================================================
NIIN: 00-166-3151
MSDS Num: BWSDG
MSDS NAME: P-524 RED FLAT LACQUER TT-L-20 31116
Responsible Party
Name: LENMAR, INC
Address: 150 SOUTH CALVERTON ROAD
City: BALTIMORE MD 21223
Info Phone: 401-947-2300
Emergency Phone Number: 401-358-5524 NIGHT/401-947-2300 DAY
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: LENMAR, INC.
Address: 150 SOUTH CALVERTON ROAD
City: BALTIMORE MD 21223
Phone: 410-947-2300/410-358-5524
Name: LENMAR, INC
Address: 150 SOUTH CALVERTON ROAD
City: BALTIMORE MD 21223
Phone: (301) 947-2300
=======================================================
Item Description Information
=======================================================
Item Manager: GSA
Item Name: LACQUER
Specification Number: TT-L-20A
Unit of Issue: GL
UI Container Qty: 4
Type of Container: METAL
=======================================================
Ingredients
=======================================================
Cas: 9004-70-0
RTECS #: QW0970000
Name: NITROCELLULOSE (VAPOR PRESSURE 33.0 MM HG @ 20C)
% Wt: 15
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 1000 PPM
------------------------------
Cas: 12656-85-8
RTECS #: QA4660000
Name: MOLYDATE ORANGE PIGMENT (VAPOR PRESSURE 760.0 MM HG @ 20C)
% Wt: 0.14
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: NOT ESTABLISHED
------------------------------
Cas: 78-93-3
RTECS #: EL6475000
Name: METHYL ETHYL KETONE (SARA 313) (CERCLA) (VAPOR PRESSURE 70.0 MM HG @ 20C)
% Wt: 10
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 200 PPM;STEL 300 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 108-10-1
RTECS #: SA9275000
Name: SHORT COCONUT ALKYD (SARA 313) (CERCLA) (VAPOR PRESSURE 6.0 MM HG @ 20C)
% Wt: 5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 100 PPM;STEL 150 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Name: SHORT OIL ALKYD RESIN SOUTION (VAPOR PRESSURE 13.5 MM HG @ 20C)
% Wt: 5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 100 PPM;STEL 150 PPM
-----------------------------
Cas: 108-88-3
RTECS #: XS5250000
Name: TOLUENE (SARA III) (CERCLA) (VAPOR PRESSURE 22.0 MM HG @ 20C)
% Wt: 30
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 50 PPM; STEL 150 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 67-64-1
RTECS #: AL3150000
Name: ACETONE (SARA 313) (CERCLA) (VAPOR PRESSURE 180.0 MM HG @ 20C)
% Wt: 5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 750 PPM;STEL 1000PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 67-63-0
RTECS #: NT8050000
Name: ISOPROPYL ALCOHOL (SARA III) (VAPOR PRESSURE 33.0 MM HG @ 20C)
% Wt: 10
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 400 PPM;STEL 500 PPM
------------------------------
Cas: 123-86-4
RTECS #: AF7350000
Name: BUTYL ACETATE (CERCLA) (VAPOR PRESSURE 8.0 MM HG @ 20C)
% Wt: 10
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 150 PPM;STEL 200 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 141-78-6
RTECS #: AH5425000
Name: ETHYL ACETATE 99% (CERCLA) (VAPOR PRESSURE 76.0 MM HG @ 20C)
% Wt: 5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 400 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 8030-30-6
RTECS #: DE3030000
Name: ALIPHATIC NAPHTHA (VAPOR PRESSURE 26.0 MM HG @ 20C)
% Wt: 10
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 300 PPM;STEL 400 PPM
------------------------------
Cas: 1330-20-7
RTECS #: ZE2100000
Name: XYLENE (SARA 313) (CERCLA) (VAPOR PRESSURE 10.0 MM HG @ 20C)
% Wt: 5
Other REC Limits: NONE RECOMMENDED
OSHA PEL: NOT ESTABLISHED
ACGIH TLV: 100 PPM;STEL 150 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Effects of Exposure: CHRONIC HEALTH EFFECTS POSSIBLE FROM LONG TERM EXPOSURE TO
MATERIAL, INCLUDING DRYING, CRACKING & IRRITATION OF SKIN. REACTS WITH
SKIN PROTEIN & MOISTURE & CAN CAUSE RASH, SCALING OR BLISTERING. HIGH
CONCENTRATIONS MAY CAUSE HEADACHES, DIZZINESS, ANESTHETIC, & OTHER
CENTRAL NERVOUS SYSTEM EFFECTS, DEATH.
Medical Cond Aggravated By Exposure: NONE
First Aid: INHAL: REMOVE TO FRESH AIR, RESTORE BREATHING, CONSULT DR. SKIN:
FLUSH W/WATER. EYE: FLUSH IMMED W/LARGE AMOUNTS OF WATER. SEE DR. DO NOT
INDUCE VOMITING. KEEP WARM, QUIET, GET MED AID. SMALL AMOUNTS OF LIQ
ASPIRATED INTO RESPIRATORY SYSTEM DURING INGESTION, OR FROM VOMITING MAY
CAUSE CHEMICAL PNEUMONIA OR PULMONARY EDEMA. CONTAINS XYLENE WHICH HAS SHOWN
REPRODUCTIVE EFFECT IN MICE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: AVOID BREATHING SOLVENT VAPOR.ENSURE VENT.AVOID
SPARKS,FLAMES,ANYTHING WHICH COULD CAUSE FIRE.ELIMINATE SOURCE OF SPILL,IF
YOU CAN DO SO W/OUT RISK BY CLOSING VALVE,PLUGGING HOLE,ETC.APPLY ABSORBENT I
NERT MATERIAL(SAND,DUST,VERMIC)TO SPILL.CLEAN **
Neutralizing Agent: N/K** SPILL W/BRISTLE BROOM,NON-SPARKING TOOLS,CLEAN DRY
RAGS,WEAR PROTECT CLOTH
Waste Disposal Methods: SOAK LIQ W/SAWDUST OR RAGS & REMOVE.FLUSH W/WATER
IF POSSIBLE.DISPOSAL SHOULD BE IN ACCORD W/LOCAL,STATE, & FED
REGS.CONTAINS LEAD-DISPOSE OF IN ACCORD W/LOCAL,STATE & FED REGS.DON'T
INCINERATE,CUT/WE LD EMPTY CNTNR.HAZARDOUS WASTE.F003,IGNITABILITY.
Handling And Storage Precautions: DRUMS SHOULD BE GROUNDED WHEN BEING EMPTIED.
Other Precautions: AVOID SKIN CONTACT. PROVIDE RESPIRATORY PROTECTION AGAINST
FUMES GENERATED DURING BURNING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: -4F,-20C
Lower Limits: 0.9
Upper Limits: 12.8
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures: WATER STREAM WILL SPREAD FIRE. DO NOT USE WATER HOSE
STREAM. FULL BUNKER GEAR IN FIRE AREA (HELMET WITH FACE SHIELD, BUNKER COAT,
GLOVES, RUBBER BOOTS).
Unusual Fire/Explosion Hazard: KEEP CNTNR CLSD.KEEP FROM HEAT,SPARK,FLAME.CLSD
CNTNR MAY EXPLODE W/HEAT.USE H2O TO COOL CNTNR.REMOVE NON-ESSENTIAL
PERSONS.VAPOR HEAVIER THAN AIR,TRAVEL DISTNC
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH RESPIRATOR TYPE SUITABLE FOR MAT'LS IN INGREDIENT
SECTION RECOMMENDED. CHEMICAL/MECHANICAL FILTER RECOMMENDED WHEN VENT
RESTRICTED. PRECAUTIONS MUST BE TAKEN SO THAT PERSONS DON'T BREATH VAPOR.
PROTECT AGAINST BOTH VAPOR & SPRAY MIST.
Ventilation: KEEP AIR CONTAMINATION BELOW PEL/TLV.REMOVE SOLVENT VAPOR FROM
LOWER LEVEL OF WORK AREA & ELIMINATE IGNITION SOURCES.
Protective Gloves: REQUIRED FOR PROLONGED/REPEATED CONTACT
Eye Protection: CHEMICAL GOGGLES,SIDESHLDS,FACESHIELDS
Other Protective Equipment: USE PROTECTIVE CREAMS WHERE SKIN CONTACT IS LIKELY.
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices: USE NORMAL HYGIENE PRACTICES DURING AND AFTER HANDLING
THIS MATERIAL.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 131 TO 298F
Vapor Density: > AIR
Evaporation Rate & Reference: SLOWER THAN ETHER
Appearance and Odor: TYPICAL SOLVENTS, THIN RED LIQUID
Percent Volatiles by Volume: 76.4
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: OXIDIZING AGENTS, ACIDS AND ALKALIES
Hazardous Decomposition Products: CARBON DIOXIDE & CARBON MONOXIDE
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 52922
MSDS NAME: P-524 RED FLAT LACQUER TT-L-20 31116
MSDS Prepared Date: 10/22/1993
Review Date: 03/10/1995
Multiple KIT Number: 0
Review IND: Y
Unit Of Issue: GL
Container QTY: 4
Type Of Container: METAL
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: LFD
DOT Proper Shipping Name: PAINT
DOT PSN Modifier: INCLUDING PAINT, LACQUER, ENAMEL, STAIN, SHELLAC SOLUTIONS,
VARNISH, POLISH, LIQUID FILLER, AND LIQUID LACQUER BASE
Hazard Class: 3
UN ID Num: UN1263
DOT Packaging Group: II
Label: FLAMMABLE LIQUID
Special Provision: B52,T7,T30
Packaging Exception: 150
Non Bulk Pack: 173
Bulk Pack: 242
Max Qty Pass: 5 L
Max Qty Cargo: 60 L
Vessel Stow Req: B
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: LCP
IMO Proper Shipping Name: PAINT OR PAINT RELATED MATERIAL
IMO PSN Modifier: (INCLUDING PAINT, LACQUER, ENAMEL, STAIN, SHELLAC SOLUTIONS,
VARNISH, POLISH, LIQUID FILLER AND LIQUID LACQUER BASE) OR (INCLUDING PAINT
THINNING OR REDUCING COMPOUND) o
IMDG Page Number: 3268
UN Number: 1263
UN Hazard Class: 3.2
IMO Packaging Group: I/II *
Subsidiary Risk Label: -
EMS Number: 3-05
MED First Aid Guide NUM: 310
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: SXI
IATA UN ID Num: 1263
IATA Proper Shipping Name: PAINT
IATA PSN Modifier: (INCLUDING
PAINT,LACQUER,ENAMEL,STAIN,SHELLAC,VARNISH,POLISH,LIQUID FILLER AND LIQUID
LACQUER BASE)
IATA UN Class: 3
IATA Label: FLAMMABLE LIQUID
UN Packing Group: II
Packing Note Passenger: 305
Max Quant Pass: 5L
Max Quant Cargo: 60L
Packaging Note Cargo: 307
Exceptions: A7,A72
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: SXI
AFI Proper Shipping Name: PAINT OR PAINT RELATED MATERIAL
AFI PSN Modifier: (INCLUDING PAINT,LACQUER,ENAMEL,STAIN,SHELLAC
SOLUTIONS,VARNISH,POLISH,LIQUID FILLER AND LIQUID LACQUER BASE) OR (INCLUDING
PAINT THINNING OR REDUCING COMPOUNDS)
AFI Hazard Class: 3
AFI UN ID NUM: UN1263
AFI Packing Group: II
Special Provisions: P5
Back Pack Reference: A7.3
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: P-524 RED FLAT LACQUER TT-L-20 31116
Company: LENMAR, INC
Street: 150 SOUTH CALVERTON ROAD
City: BALTIMORE MD
Zipcode: 21223
Health Emergency Phone: 401-358-5524 NIGHT/401-947-2300 DAY
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: CHRONIC HEALTH EFFECTS POSSIBLE FROM LONG TERM EXPOSURE
TO MATERIAL, INCLUDING DRYING, CRACKING & IRRITATION OF SKIN. REACTS
WITH SKIN PROTEIN & MOISTURE & CAN CAUSE RASH, SCALING OR BLISTERING.
HIGH CONCENTRATIONS MAY CAUSE HEADACHES, DIZZINESS, ANESTHETIC, & OTHER
CENTRAL NERVOUS SYSTEM EFFECTS, DEATH. N/K
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|