resp prot:condtns (see your safety equipment supplier). ing 5:to reduce exposure. prot:equivalent gloves should be worn to prevent skin acetone; (dimethyl ketone) (2-propanone) (sara iii) benzene (sara iii) supdat:process equip operating under elevated press if ing 3:fire and explosion hazard.
LD50 LC50 Mixture:LD50:(ORAL RAT) 5800MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF INHALED OR INGESTED. HIGH
CONCENTRATIONS OR PROLONGED EXPOSURE CAUSES HEADACHE, DIZZINESS,
NAUSEA, IRRITATION OF EYES AND RESPIRATORY TRACT, NARCOSIS AND
EVENTUALLY UNCONSCIOUSNESS. MAY CAU SE DAMAGE TO CNS, LIVER AND
KIDNEYS. PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE IRRITATION.
(EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EYE CONTACT CAUSES IRRIT. ANIMAL
STUDIES SHOW ADVERSE EFFECTS ON FERTILITY WHEN FEMALES WERE EXPOSED
CHRONICALLY DURING PREGNANCY. TESTS ON LAB ANIMALS INDICATE
MATERIAL MAY PRODUCE ADVERSE M UTAGENIC & REPRODUCTIVE EFTS.
CONTAINS A TRACE AMT OF BENZENE WHICH HAS BEEN FOUND TO BE
CARCONOGENIC TO HUMANS
Medical Cond Aggravated by Exposure:SKIN CONTACT AND PREGNANCY.
======================= First Aid Measures =======================
First Aid:GET MD ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:WASH
THOROUGHLY WITH SOAP AND WATER. EYES:IMMEDIATELY FLUSH THOROUGHLY
WITH WATER FOR AT LEAST 15 MINUTES. INHAL:REMOVE TO FRESH AIR, GIVE
ARTIFIC IAL RESPIRATION IF BREATHING HAS STOPPED. INGEST:IF
CONSCIOUS, DRINK WATER AND INDUCE VOMITING IMMEDIATELY AS DIRECTED
BY MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:0F,-18C
Lower Limits:2.6%
Upper Limits:12.8%
Extinguishing Media:DRY CHEMICAL, "ALCOHOL" FOAM, WATER SPRAY, CARBON
DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER SPRAY TO COOL EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:VAP CAN TRAVEL DISTANCES TO IGNIT SOURCE
& FLASH BACK. HOT ORG CHEM VAP/MISTS ARE SUSCEPTIBLE TO SUDDEN
SPONTANEOUS COMBUST WHEN MIXED W/AIR. IGNIT (SUPDAT)
Spill Release Procedures:DIKE SPILL; TAKE UP WITH ABSORBENT.
CONTAINERIZE FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTR CLSD. STORE IN COOL AREA
AWAY FROM IGNIT SOURCES & OXIDIZERS. DO NOT BRTH VAP. DO NOT GET IN
EYES. AVOID PRLNGD/RPTD SKIN CONTACT.
Other Precautions:ELECTRICALLY GROUND ALL EQUIPMENT WHEN HANDLING
PRODUCT. RETAINED RESIDUE MAY MAKE EMPTY CONTAINER HAZARDOUS; USE
CAUTION! DO NOT TAKE INTERNALLY. REMOVE CONTAMINATED CLOTHING AND
WASH BEFORE REUSE.
Respiratory Protection:IF WORKPLACE EXPOS LIM(S) OF PROD/ANY COMPONENT
IS EXCEEDED, A NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN
ABSENCE OF PROPER ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER
NIOSH/MSHA APPRVD RESP ( NEG PRESS TYPE) UNDER SPECIFIED (ING 5)
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR WITH ADEQUATE VENTILATION.
Protective Gloves:BUTYL RUBBER, CPE, POLYURETHANE/ (ING 7)
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH AND SAFETY EQUIPMENT SHOULD BE
READILY AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EXPLOS HAZ:MAY OCCUR AT TEMP BELOW PUB AUTOIGNIT/IGNIT TEMP. IGNIT TEMP
DECREASE W/INCREASED VAP VOL & VAP/AIR CONTACT TIME & ARE
INFLUENCED BY PRESS CHANGES. IGNIT MAY OCCUR AT TYPICAL ELEVATED
TEMP PROCESS CONDTNS, ESP IN PROCESS OPERATING UNDER VACUUM IF
SUBJECTED TO SUDDEN INGRESS OF AIR/OUTSIDE (ING 3)
Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE WITH ALL CURRENT
LOCAL, STATE AND FEDERAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.