===================== Product Identification =====================
MSDS NAME:HW8Y2, WASH IDCS YELLOW TRAFFIC PAINT
NIIN:00N033325
MSDS Number: BPQFV
=== Responsible Party ===
Company:MORTON INTERNATIONAL NORRIS/TMT
Address:1675 COMMERCIAL ST NE
City:SALEM
State:OR
ZIP:97303
Country:US
Info Phone Num:503-364-2277
Emergency Phone Num:800-424-9300 (CHEMTREC)
Preparer's Name:WILLIAM HEIBER
CAGE:DO471
=== Contractor Identification ===
Company:MORTON INTERNATIONAL; SPECIALTY CHEM GRP
Address:333 WEST WACKER
City:CHICAGO
State:IL
ZIP:60606-1292
Phone:815-338-1800
CAGE:DO471
Company:MORTON INTL INC SPECIALTY CHEMICALS GROUP
Address:333 W WACKER DR
City:CHICAGO
State:IL
ZIP:60606-1218
Country:US
Phone:312-807-2000
CAGE:32063
============= Composition/Information on Ingredients =============
Name:VOLATILE ORGANIC COMPOUNDS: 4.25 LB/GL, (509 G/L)
RTECS #:9999999VO
Name:SUPP DATA:MAY BE CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING
USES IN HUMANS ACUTELY OR CHRONICALLY EXPOSED TO (ING 11)
RTECS #:9999999ZZ
Name:ING 10:CHLOROCARBONS . NOTE: TOLUENE 108-88-3 APPEARS ON
NAVY LISTING OF OCCUP REPRODUCTIVE HAZARDS. SEEK (ING 12)
RTECS #:9999999ZZ
Name:ING 11:CONSULTATION FROM APPROP HLTH PROFESSIONALS
CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS RECOM .
RTECS #:9999999ZZ
Name:OTHER PROT EQUIP:SHOULD BE WORN AS NEEDED. COVERALLS ARE
RECOMMENDED.
RTECS #:9999999ZZ
Name:EXPLAN OF CARCIN: PROPYLENE OXIDE: ANTIC TO BE A
CARCIN(NTP), GROUP 2A(IARC)
RTECS #:9999999ZZ
Name:PROPANE, 1,2-EPOXY; (PROPYLENE OXIDE) (SARA III). VP:442 @
0F
CAS:75-56-9
RTECS #:TZ2975000
Fraction by Wt: 0.12%
OSHA PEL:100 PPM
ACGIH TLV:20 PPM; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Name:VM&P NAPHTHA; (#200 THINNER). VP:360 @ 68F
CAS:64742-89-8
Fraction by Wt: 10%
ACGIH TLV:400 PPM (MFR)
Name:TOLUENE (SARA III). VP:24 @ 68F
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM; 9293
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:2-BUTANONE; (METHYL ETHYL KETONE). VP:72 @ 68F
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: <5%
OSHA PEL:200 PPM; 300 STEL
ACGIH TLV:200 PPM; 300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:HEPTANE. (BLEND) VP:86.4 @ 68F
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: <5%
OSHA PEL:500 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9293
Name:ACETONE; (2-PROPANONE/ACETONE) (SARA III). VP:184 @ 60F
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 5%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000STEL;9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:CHROMIC ACID, LEAD (2+) SALT (1:1); (LEAD CHROMATE)
CAS:7758-97-6
RTECS #:GB2975000
Fraction by Wt: 3.10%
OSHA PEL:0.05 MG/M3 (MFR)
ACGIH TLV:0.05 MG/M3 (MFR)
Name:METHANE, DICHLORO-; (METHYLENE CHLORIDE). VP:352 @ 68F
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 11.51%
OSHA PEL:500 PPM, 1000, C
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE EYE/SKIN/NOSE/THROAT
IRRIT. MAY CAUSE CNS DEPRESS. CHRONIC: RPTS HAVE ASSOC RPTD/PRLNGD
OVEREXP TO SOLV W/PERM BRAIN & NERV SYS DAM. RECURRENT OVEREXP MAY
RSLT IN LIVER/KIDNEY INJURY. RPTD/PRLNGD EXPOS TO LEAD CHROMATE
MAYCAUSE DELAYED EFTS INVOLVING GI, BLOOD, NERV & REPROD SYS. (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: ANTIC TO BE A CARCIN
(NTP), GROUP 2B(IARC). LEAD CHROMATE: GROUP 1(IARC), KNOWN
CARCIN(NTP),(ING 14)
Effects of Overexposure:HLTH HAZ:INHAL:MAY CAUSE NOSE/THROAT IRRIT. MAY
CAUSE NERV SYS DEPRESS CHARACT BY FOLLOWING PROGRESSIVE STEPS:HDCH,
DIZZ, NAUS, STAG GAIT, CONFUSN & UNCON. SKIN/EYE:MAY CAUSE
IRRIT/BURNING OF EYES. RP TD/PRLNGD LIQ CONT MAY CAUSE SKIN
IRRITW/DISCOMFORT & DERM. INGEST:GI DISTRESS. CHLOROCARBON MATLS
HAVE (SUPP DATA)
Medical Cond Aggravated by Exposure:MAY CAUSE RESPIRATORY & SKIN
ALLERGIC REACTIONS IN SOME INDIVIDUALS.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMED & HAVE NAMES OF INGREDIENTS AVAILABLE.
SKIN:WASH W/SOAP & WATER, IF IRRIT OCCURS, CONTACT MD. EYES:IMMED
FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. IF IRRIT OCCURS,
CONTACT MD. INHAL:IF AFFECTED BY INHAL OF VAPORS/SPRAY MIST,
REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTF RESP, PREFERABLEY
MOUTH TO MOUTH. IF BREATHING DFCLTY PERSISTS OR OCCURS LATER,
CONSULT MD.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:23F,-5C
Lower Limits:0.5%
Upper Limits:37%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL & WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESS DEMAND SCBA &
FULL PROT EQUIP . WATER FROM FOG NOZZLES MAY BE USED TO COOL CLOSED
CONTRS TO PREVENT PRESS BUILDUP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE FL PT, EMITS FLAMM
VAPORS WHICH, WHEN MIXED W/AIR, CAN BURN/BE EXPLOSIVE. FINE
MISTS/SPRAYS MAY BE FLAMM AT TEMPS BELOW FL PT. CAN (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. REMOVE MATERIAL W/INERT ABSORBENT & USE NON-SPARKING TOOLS.
KEEP OUT OF DRAINS, SEWERS & WATERWAYS. CONTACT FIRE, FEDERAL,
STATE OR LOCAL AGENCIES AS RE QUIRED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE >120F. STORE I/A/W OSHA
1910.106. KEEP AWAY FROM HEAT, SPARKS & FLAME. CLOSE CONTR AFTER
EACH USE. GROUND CONTRS WHEN POURING.
Other Precautions:OBSERVE LABEL PRECS. PVNT PRLNGD/RPTD BRTHG OF
VAPS/SPRAY MIST. NO SMOKING IN AREA OF USE. DO NOT USE IN GEN
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURF. HEAT &/OR UV
RADIA MAY CAUSE THE FORMATIO N OF HCL &/OR PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:VENT WORKING SPACES TO BELOW TLV. IF ABOVE TLV,
WEAR PROPERLY FITTED NIOSH/MSHA APPROVED VAPOR/PARTICULATE RESP FOR
USE W/PAINTS DURING APPLICATN & UNTIL ALL VAPORS & SPRAY MISTS ARE
EXHAUSTED. FOLLOW RESP MFRS DIRECTIONS FOR RESP USE.
Ventilation:PROVIDE SUFFICIENT VENT IN VOL & PATTERN TO KEEP CONTAM
BELOW APPLIC OSHA REQUIREMENTS & OTHER SUGGESTED EXPOS LIMITS.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:IT IS SUGGESTED THAT A SOURCE OF CLEAN WATER
BE AVAIL IN WORK AREA FOR FLUSHING EYES/SKIN. IMPERVIOUS CLTHG (ING
13)
Work Hygienic Practices:WASH THORO AFTER HNDLG & BEFORE EATING OR
SMOKING. REMOVE & WASH CONTAMD CLTHG BEFORE REUSE. DISCARD SHOES IF
SATURATED.
Supplemental Safety and Health
EXPLO HAZ:CHEMICALLY REACT W/ALUMINUM IN SPRAY EQUIPMENT & OTHER
DEVICES & CAUSE AN EXPLOSION HAZARD. THERMAL DECOMPOSITION PRODUCTS
MAY INCLUDE HCL & PHOSGENE . EFTS OF OVEREXP:PRDCED SENSIT OF
MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE A SIMILAR EFT
IN HUMANS. ADRENOMIMETICS (E.G EPINEPHRINE) (ING10)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>93F,>33.9C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.5 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW LIQUID W/A CHARACTERISTIC HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES, OXYGEN, NITROGEN PEROXIDE, SODIUM, POTASSIUM & OTHER
OXIDIZERS & REACTIVE METALS.
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME.
Hazardous Decomposition Products:CO*2, CO, HCL, PHOSGENE, CHLORINE &
OXIDES OF LEAD, CHROMIUM & HEAVY METALS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. DO NOT INCINERATE IN A CLOSED CONTAINER.
COMPLY W/ALL APPLICABLE GOVERNMENTAL REGULATIONS ON SPILL
REPORTING.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|
| ALL PAGES On Chemical Property IN THIS GROUP
| | NAME | CAS |
|
PENTHOUSE RUG STEAM LIQUID
| 111-76-2
67-63-0
7758-29-4 |
|
428-2402, DURON GLOSS BLACK
| 1330-20-7
64742-89-8
67-64-1
74-98-6
106-97-8
108-88-3 |
|
8000229, U-1230 SERIES CLEANING KIT
| 71-55-6
2807-30-9
123-91-1 |
|
METHYLENE CHLORIDE
| 75-09-2 |
|
B2193, BATH WAX
| 68334-00-9 |
|
236B3501,BAR RUST 236 MULTI PURPOSE EPOXY (
| 71-36-3
13463-67-7
14808-60-7
25068-38-6
64742-95-6
14807-96-6
12001-26-2 |
|
1792, OVER-COAT
| 8032-32-4
71-55-6 |
|
DOS DLC
| 1344-95-2
122-62-3
14808-60-7
112945-52-5 |
|
8204, PROTURF FLUID INSECTICIDE (EPA REG (S
| 63-25-2 |
|
8341, PROTURF FERTILIZER WITH MINORS 26-4-1
| 7722-76-1
57-13-6
7778-80-5
7782-63-0
7733-02-0
1314-13-2
7439-96-5
1344-43-0
1317-39-1
7631-95-0
7487-88-9 |
|
83009, PROTURF FLUID FERTILIZER 29-2-3
| 7098-14-8
57-13-6
7320-34-5 |
|
8432, PROTURF FLUID FERTILIZER 29-2-3
| 7098-14-8
57-13-6
7320-34-5 |
|
8788, PROTURF TGR*R ENHANCER 50 WP (EPA (SU
| 76738-62-0 |
|
8693, PROTURF WEEDGRASS CONTROL 60 WP (SUPP
| 40487-42-1 |
|
ADHESIVE A.3026
| 78-93-3
108-88-3
67-64-1 |
|
F77 G 5 EQUIPMENT GREEN, QUICK DRY ENAMEL L
| 7758-97-6
12656-85-8
7439-92-1
18540-29-9
64742-48-9
108-88-3
1330-20-7
64742-95-6
13463-67-7
1344-37-2 |
|
F77 Y 10 REGAL YELLOW, QUICK DRY ENAMEL LEA
| 64742-48-9
108-88-3
1330-20-7
64742-95-6
13463-67-7
1344-37-2
7758-97-6
12656-85-8
7439-92-1
18540-29-9 |
|
E61 R25, STRUCTURAL STEEL SHOP COAT PRIMER
| 64742-48-9
64742-47-8
11103-86-9 |
|
PR-1431-G & GT PART A
| 13423-61-5
14307-33-6
8031-18-3
7732-18-5 |
|
RS-0011-600000-A, RTVS 11 BLACK
| |
|
E708 SEALANT
| 12001-29-5
8032-32-4 |
|
AMDRY 993 CODEP
| 12070-08-5
7429-90-5 |
|
STAINLESS STEEL
| 7440-03-1
7727-37-9
7440-31-5
7440-48-4
7439-89-6
7440-47-3
7440-02-0
7439-96-5
7439-98-7
7440-50-8
7440-32-6
7440-44-0
7723-14-0
7704-34-9
7440-21-3 |
|
RES00228FE8912, POLYESTER RESIN DION FR 669
| 100-42-5
106-89-8
75-09-2 |
|
LOW CARBON STEEL
| 7439-89-6
7732-14-0
7439-96-5
7704-34-9
7440-21-3
7440-66-6
7440-44-0 |
|
PR-1141 PC-61 SCARLET RED PART A
| 110-43-0 |
|
PR-1141 PC-53 EMERALD GREEN PART A
| 110-43-0 |
|
HW8Y2, WASH IDCS YELLOW TRAFFIC PAINT
| 75-56-9
64742-89-8
108-88-3
78-93-3
142-82-5
67-64-1
7758-97-6
75-09-2 |
|
ISO PREP, RI105
| 64742-48-9 |
|
DL2370, SOVEREIGN
| 6834-92-0
7320-34-5 |
|
06013, ELECTRONIC CLEANER AEROSOL
| 76-13-1
75-45-6 |
|
06014, ELECTRONIC CLEANER AEROSOL
| 76-13-1
75-45-6 |
|
FLAMAREST 1400S COMPONENT A
| 78-93-3 |
|
FLAMAREST 1400S COMPONENT B
| 108-88-3 |
|
FLAMAREST 1400S COMPONENT C
| 108-88-3
90-72-2 |
|
0115, NO. 115 DRAIN LAX DRAIN CL.
| 1310-58-3 |
|
CPS233837, METALWORKING FLUID GRADE 504
| 64742-54-7
64742-65-0
24937-78-8
63449-39-8 |
|
CPS255712, POLY FM GREASE 2
| 64742-21-8 |
|
RELEASE AGENT
| 71-55-6 |
|
NUCLEAR GRAD DURALLOY HARDENER
| |
|
CARPET SANITIZER FOR EXTRACTION & ROTARY EQ
| 8001-54-5
68424-17-5
6834-92-0
68412-54-4 |
|
WHAT SPOT?
| 67-63-0
111-76-2
74-98-6
106-97-8 |
|
OUAT FOAMING GERMICIDAL CLEANER
| 111-76-2
68475-59-2
9002-93-1
1336-21-6 |
|
COLDPOUR CP-0 OIL
| 8001-20-5 |
|
STA-LUBE FORMULA III HAND CLEANER
| 8002-05-9
68439-46-3 |
|
SP4824-3RA BLUE GREEN
| 1330-20-7
78-93-3
75-09-2
74-98-6 |
|
FIBERFIL FCH/NATURAL
| |
|
34806 HYDRANAL - COMPOSITE 2
| 111-77-3
288-32-4
7446-09-5
10034-85-2
7553-56-2 |
|
STAINLESS STEEL
| 64742-88-7
91-20-3
67-63-0 |
|
02321, MEROPA 220 INDUSTRIAL OILS
| 64742-65-0
72623-83-7
108-88-3 |
|
|