===================== Product Identification =====================
MSDS NAME:SCOTCHCAST ELECTRICAL INSULATING RESIN (PREPOLYMER)
NIIN:00D003180
Kit Part:Y
MSDS Number: BSQJC
=== Responsible Party ===
Company:MINNESOTA MINING & MFG CO ELECTRICAL PRODUCTS DIV
Address:3M AUSTIN CTR
Box:2963
City:AUSTIN
State:TX
ZIP:78769-2963
Country:US
Info Phone Num:612-733-5454
Emergency Phone Num:612-733-5454
CAGE:75037
=== Contractor Identification ===
Company:MINNESOTA MINING AND MFG CO ELECTRICAL PRODUCTS DIV
Address:3M AUSTIN CTR
Box:City:AUSTIN
State:TX
ZIP:78769-2963
Country:US
Phone:512-984-1800
CAGE:75037
============= Composition/Information on Ingredients =============
Name:METHYLENE BISPHENYL ISOCYANATE (MDI) (SARA III)
CAS:101-68-8
RTECS #:NQ9350000
Fraction by Wt: 35-45%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:C 0.02 PPM
ACGIH TLV:0.005 PPM; 9394
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Name:DIUNDECYL PHTHALATE
CAS:3648-20-2
RTECS #:TI1980000
Fraction by Wt: 35-40%
Other REC Limits:NONE RECOMMENDED
Name:HYDROXY TERMINATED 1,3BUTADIENE HOMOPOLYMER
CAS:69102-90-5
Fraction by Wt: 15-20%
Other REC Limits:NONE RECOMMENDED
Name:POLYOXYPROPYLENE GLYCOL
CAS:25322-69-4
RTECS #:TR5250000
Fraction by Wt: 5-10%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION MAY CAUSE IRRITATION
OF UPPER RESPIRATORY TRACT. CONTACT MAY CAUSE SKIN OR EYE
IRRITATION. SWALLOWING IS AN UNLIKELY ROUTE OF EXPOSURE. CHRONIC:
PROLONGED OR REPEATED EXPOSURE MAY CA USE AN ALLERGIC RESPIRATORY
REACTION.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED: SORE THROAT & NOSE, COUGHING,
SNEEZING. EYES: REDNESS, SWELLING, PAIN, TEARING. SKIN: REDNESS,
SWELLING, ITCHING. ALLERGIC RESPIRATORY REACTION: DIFFICULTY
BREATHING, WHEEZING, TIGHTNESS IN C HEST, RESPIRATORY FAILURE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALED: REMOVE TO FRESH AIR. IF SYMPTOMS/SIGNS CONTINUE,
CALL A DOCTOR. SWALLOWED: DO NOT INDUCE VOMITING! IF CONSCIOUS,
DRINK 1-2 GLASSES OF WATER. GET IMMEDIATE MEDICAL ATTENTION. EYES:
FLUSH WITH LOTS OF WATER FOR 15 MINUTES, HOLD LIDSOPEN. GET
MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHES. WASH WITH
SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>320F,>160C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:COMBUSTION MAY FORM TOXIC GASES/FUMES
SUCH AS OXIDES OF CARBON, OXIDES OF NITROGEN, HYDROGEN CYANIDE,
ISOCYANATES, OTHER TOXIC VAPORS/PARTICULATES, GASES, ETC.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROPER PROTECTIVE EQUIPMENT.POUR
DECONTAMINANT SOLUTION ON SPILL,ALLOW TO REACT FOR 10
MINUTES.ALTERNATIVLEY POUR WATER ON SPILL,LET REACT 30
MINUTES.COVER W/ABSORBENT,PLACE IN APPROVED DRUM. DO NOT SEAL DRUM
FOR 48 HOURS. NEUTRALIZE SPILL SITE.
Neutralizing Agent:DECONTAMINANT SOLUTION- 80% WATER, 8% CONCENTRATED
AMMONIA, 2% DETERGENT.
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER IN A WELL-VENTIALTED
AREA AWAY FROM INCOMPATIBLE MATERIALS. KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:KEEP CONTAINER TIGHTLY CLOSED. DO NOT HEAT UNDER
CONFINEMENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR EMERGENCY OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR WITH
ORGANIC VAPOR CARTRIDGE, OR SUPPLIED AIR RESPIRATOR OR SCBA, AS
REQUIRED. USE IAW 29 CFR 19 10.134.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION TO MAINTAIN EXPOSURE
BELOW REGULATORY LIMITS.
Protective Gloves:NEOPRENE
Eye Protection:SAFETY GLASSES
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
THIS ITEM IS PART A OF A 3 PART KIT. OTHER PARTS ARE UNDER
5970-00-D00-3180 PART B (POLYOL) AND 5975-00-D003179, CC-2 PREP
KIT/CABLE CLEANER. ALL PARTS ARE PART OF 3M KIT NUMBER-5903,
CATALOGUE NUMBER 80-7110-7800-8, PORCELAIN TERMINATION KIT.
KEY1=N1.
================== Physical/Chemical Properties ==================
HCC:V4
Spec Gravity:1.05 (WATER=1)
Viscosity:10 P
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK VISCOUS LIQUID
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AMINES, ALCOHOLS, WATER
Stability Condition to Avoid:CONTACT WITH AMINES, ALOCOHOLS, AND WATER.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE,
OXIDES OF NITROGEN, HYDROGEN CYANIDE, ISOCYANATES, OTHER TOXIC
VAPORS, GASES, ETC
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN AN INDUSTRIAL OR COMMERCIAL
FACILITY. DISPOSE OF COMPLETELY CURED (OR POLYMERIZED) MATERIAL IN
A SANITARY LANDFILL. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|