===================== Product Identification =====================
MSDS NAME:SEMI GLOSS AIR DRY ENAMEL, 24087
NIIN:00N040374
MSDS Number: BSQKT
=== Responsible Party ===
Company:RANDOLPH PRODUCTS CO
Address:PARK PLACE EAST
City:CARLSTADT
State:NJ
ZIP:07072
Country:US
Info Phone Num:201-438-3700
Emergency Phone Num:201-438-3700
CAGE:77672
=== Contractor Identification ===
Company:RANDOLPH PRODUCTS CO
Address:701 12TH ST
Box:830
City:CARLSTADT
State:NJ
ZIP:07072-0830
Country:US
Phone:201-438-3700
CAGE:77672
============= Composition/Information on Ingredients =============
Name:ING 16:SHOVEL INTO SUITABLE DISP CONTRS. ON WATER, MATL IS
SOLUBLE & WILL FLOAT. ATTEMPT TO CONTAIN & RECOVER (ING 18)
RTECS #:9999999ZZ
Name:ING 17:RAPIDLY TO PREVENT DISPERSION. MAY BE TOXIC TO
AQUATIC LIFE.
RTECS #:9999999ZZ
Name:WASTE DISP METH:SUBSTANTIALLY CONTAMD BY PROD, & INTENTED
FOR DISP, BE HNDLD AS HAZ WASTE DUE TO RISK OR FIRE & (ING 20)
RTECS #:9999999ZZ
Name:ING 19:EXPLOSION UNDER ADVERSE CIRCUMSTANCES. DISPOSAL MUST
BE I/A/W FEDERAL, STATE & LOCAL REGULATIONS .
RTECS #:9999999ZZ
Name:OTHER PREC:CONTRS MUST BE PROPERLY GROUNDED BEFORE
BEGINNING TRANSFER. ALL ELECTRICAL EQUIPMENT SHOULD (ING 22)
RTECS #:9999999ZZ
Name:ING 21:CONFORM TO NEC. EMPTY DISP CONTRS MUST BE HNDLD
W/CARE BECAUSE OF COMBUST VAP REMAINING AFTER EMPTYING & (ING 23)
RTECS #:9999999ZZ
Name:ING 22:SHOULD BE PROPERLY DECONTAMINATED BEFORE REUSE OR
DISPOSAL.
RTECS #:9999999ZZ
Name:VENT:ANY HARMFUL LEVEL BASED ON MEDICAL SURVEILLANCE.
RTECS #:9999999ZZ
Name:PIGMENTS
Fraction by Wt: 10-20%
ACGIH TLV:10 MG/M3 (MFR)
Name:TOLUENE (SARA III). VP:38 @ 20C. LEL:1.2
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 2-10%
OSHA PEL:100 PPM; 150 STEL
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:LIGROINE; (VM&P NAPHTHA). VP:10 @ 20C. LEL:0.9
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 15-25%
Other REC Limits:200 PPM (MFR)
OSHA PEL:300 PPM;400 PPM STEL
ACGIH TLV:300 PPM
Name:XYLENE (SARA III). VP:25 @ 20C. LEL:1.2
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1-5%
OSHA PEL:100 PPM; 150 STEL
ACGIH TLV:100 PPM; 150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:BUTYL ALCOHOL (SARA III). VP:4 @ 20C. LEL:1.4
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 5-15%
OSHA PEL:50 PPM, S, C
ACGIH TLV:50 PPM, S, C
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:MAGNESIUM SILICATE HYDRATE
CAS:1343-90-4
RTECS #:OM4360000
Fraction by Wt: 10-20%
ACGIH TLV:10 MG/M3 (MFR)
Name:ALKYD RESIN (ALKYD RESIN SOLUTION)
Fraction by Wt: 20-30%
Name:DRIERS
Fraction by Wt: <1%
Name:SUPP DATA:LONG DISTANCES ALONG GROUND BEFORE REACHING IGNIT
SOURCE & FLACK BACK TO VAP SOURCE. FINE SPRAY/MISTS (ING 10)
RTECS #:9999999ZZ
Name:ING 9:MAY BE COMBUSTIBLE AT TEMPERATURES BELOW THE NORMAL
FLASH POINT.
RTECS #:9999999ZZ
Name:EFTS OF OVEREXP:CONCENTRATING/INHALING CONTENTS MAY BE
HARMFUL/FATAL. TOLUENE 108-88-3 APPEARS ON NAVY LISTING (ING 12)
RTECS #:9999999ZZ
Name:ING 11:OF OCCUP REPROD HAZARDS. SEEK CONSULTATION FROM
APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST (ING 13)
RTECS #:9999999ZZ
Name:ING 12:INFORMATION & SAFE HANDLING & EXPOSURE
RECOMMENDATIONS .
RTECS #:9999999ZZ
Name:FIRST AID PROC:CONTAMD SHOES. INGEST:IF LGE QTY IS
SWALLOWED, ADMIN WARM WATER (QT) & OBTAIN MED ATTN IMMED. DO (ING
15)
RTECS #:9999999ZZ
Name:ING 14:NOT INDUCE VOMITING BECAUSE BREATHING INTO LUNGS
WILL INCREASE RISK OF CHEMICAL PNEUMONIA.
RTECS #:9999999ZZ
Name:SPILL PROC:RESTRICT WATER USE IN CLEANUP. DIKE/IMPOUND LGE
LAND SPILL. ABSORB SMALL SPILL ONTO INERT SOLIDS & (ING 17)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL:EXPOS TO EXCESSIVE CONC
OF VAP/MIST, MAY RSLT IN TOX EFTS: NASAL IRRIT, DIZZ, WEAK,
FATIGUE, NAUS, HDCH, POSS UNCON & EVEN ASPHY. EYES:UPON DIRECT CONT
MAY CAUSE MOD IRRIT, REDNESS, TEARI NG &/OR BLURRED VISION. SKIN:IN
LIQ/SOLN FORM MAY BE ABSORBED THRU INTACT SKIN & PRDCE TOX EFTS IF
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HTLH HAZ:EXPOS IS PRLNGD/EXTENSIVE. FOLLOWING
RPTD/PRLNGD CONT, MAY CAUSE MINOR SKIN IRRIT, DEFATTING &/OR DERM.
INGEST:MAY BE TOX IF SWALLOWED IN LGE QTY & CAUSE GI IRRIT, NAUS,
VOM & DIARR. CHRONIC: RPTS HAVE ASSOC RPTD/PRLNGD OCCUP OVEREXPOS
TO SOLV W/PERM BRAIN & NERV SYS DAM. INTENTIONAL MISUSE BY DELIB
(ING 11)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:IMMED MOVE TO FRESH AIR. KEEP QUIET. ADMIN OXYGEN OR
ARTF RESP AS NEEDED. OBTAIN MED ATTN IMMED. PROMPT ACTION IS
ESSNTL. EYES:IMMED FLUSH W/CLEAN, LOW PRESS WATER FOR AT LEAST 15
MINS, OCCASNLY LIFTING EYELIDS. OBTAIN IMMED MED ATTN. SKIN:IMMED
REMOVE CONTAMD CLTHG. WASH AFFECTED AREAS W/SOAP & WATER. IF
STICKY, USE WATERLESS CLEANER FIRST. CLEAN CLTHG THORO BEFORE
REUSE. DISCARD (ING 14)
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:45.0F,7.2C
Lower Limits:0.9%
Extinguishing Media:SAND, FOAM, CARBON DIOXIDE OR CHEMICAL TYPES.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. COOL EXPOSED CONTRS W/WATER TO PVNT EXPLOS DUE TO PRESS.
FIRE-FIGHT FROM SAFE DISTANCE/PROTECTED (SUP DAT)
Unusual Fire/Explosion Hazard:HEAT STRESS MAY BUILD PRESS & RUPTURE
CLSD CONTRS, SPREADING FIRE & INCREASING RISK OF INJURY. WHEN
HEATED ABOVE FL PT, MATL RELS VAP. IF EXPOSED TO (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:RELS MAY CAUSE FIRE/EXPLOS. EVAC NONESSNTL
PERS. EXTING ALL IGNIT SOURCES & STOP RELS IF W/OUT UNDUE RISK.
NOTIFY FIRE/WATER SUPPLY/POLLUTION CONTROL AUTHS. EQUIP CLEANUP
CREW W/PROPER PROT. BLANKET S PILL W/FOAM TO LIMIT VAP EMISSION.
(ING16)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, OPEN FLAMES,
SPARKS OR STRONG OXIDIZING AGENTS. KEEP AWAY FROM CHILDREN. EMPTY
CONTRS ARE HAZ. DO NOT CUT OR WELD.
Other Precautions:AVOID BREATHING VAPORS/FUMES. STORE ONLY IN CONTRS
TIGHTLY CLOSED OR PROPERLY BLANKETED W/INERT GAS TO RETARD
POTENTIAL DEVELOPMENT OF DANGEROUS PEROXIDES. CONTACT LENSES SHOULD
NOT BE WORN. PRACTICE GOOD PERSONAL HYGIENE. (ING 21)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF MATL IS HANDLED AT ELEVATED TEMPS OR UNDER
MIST-FORMING CNDTNS, NIOSH/MSHA APPROVED SCBA OPERATED IN A
POSITIVE PRESS MODE SHOULD BE USED. WEAR NIOSH/MSHA APPROVED
RESPIRATOR WHERE VAPOR CONC ARE E NCOUNTERED.
Ventilation:EXPLOS PROOF EXHST VENT AT POINT OF CONTAM RELS. USE MATL
ONLY WHERE GEN ROOM VENT CONTROLS POTNTL EXPOS BELOW (ING 24)
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:ANSI APRV CHEM WORK GOGGS/ (OTR PROT EQT
Other Protective Equipment:COVERALLS, APRON & BOOTS. EQUIPMENT SHOULD
BE CLEANED THOROUGHLY AFTER EACH USE. EYE PROT: FULL LENGTH
FACESHIELD
Work Hygienic Practices:WASH HANDS BEFORE EATING/DRINKING/SMOKING/USE
OF TOILET FACILITIES. TAKE A SHOWER AFTER WORK USING PLENTY
SOAP/WATER.
Supplemental Safety and Health
FIRE FIGHT PROC:LOCATION. APPLY AQ EXTING MEDIA CAREFULLY TO AVOID
FROTHING & LIMIT EXPOS OF NEARBY EQUIP. MAY NEED SPEC FOAMS FOR
EFTIVE EXTING. NOTIFY AUTH IF LIQ ENTERS SEWERS/PUBLIC WATER. EXPLO
H AZ:IGNIT SOURCE IN AIR, VAP CAN BURN INOPEN OR EXPLODE IF
CONFINED. VAPS ARE OFTEN HVR THAN AIR & MAY TRAVEL (ING 9)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>230F,>110C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.14-1.26
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:80
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDANTS, ALUMINUM METAL DUE TO GENERATION OF
EXTREMELY FLAMMABLE HYDROGEN GAS & POSS CORROSION.
Stability Condition to Avoid:FLAME OR HIGH HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE MAY FORM WHEN BURNED.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTAMD SOLIDS SHOULD BE LANDFILLED ONLY AT
PROPERLY PERMITTED DISP SITES. CARE IS NEC TO AVOID OVERLOADING OR
BIOMASS POISONING. ASSURE BIOPLANT EFFLUENT COMPLIANT W/ALL APPLIC
WATER POLLUTION CONTRO L REGS. IT IS RECOM THAT ANY MATL (ING 19)
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|
| ALL PAGES On Chemical Property IN THIS GROUP
| | NAME | CAS |
|
LAUNDRI STARCH
| |
|
BLITZ OVEN CLEANER
| 1310-73-2 |
|
VAC UP STRIPPER, LIQUID
| 111-76-2
141-43-5
1310-73-2 |
|
CWT TITRETS, K-7040R
| 7664-93-9
13590-82-4
7732-18-5 |
|
CWT VALVE ASSEMBLY, K-7040R
| 7782-63-0
66-71-7
111-46-6 |
|
COLLOID 60, 80-0060-00
| 64742-52-5
300-92-5 |
|
CHOPPED STRAND
| 7732-18-5 |
|
PROMAR 200 FLAT B33W21101 PURE WHITE ALKYD VOC-(SUPDAT)
| 107-21-1
64742-47-8
64742-88-7
14808-60-7
471-34-1
13463-67-7 |
|
PA251 CIELO BLANCO INTERIOR/EXTERIOR LATEX SEMI-(SUPDAT)
| 7732-18-5
13463-67-7
107-21-1
25265-77-4 |
|
SEMI GLOSS AIR DRY ENAMEL, 24087
| 108-88-3
8032-32-4
1330-20-7
71-36-3
1343-90-4 |
|
SX CARTRIDGE REPLACEMENT TONER
| 1309-38-2
64808-48-6 |
|
DIURON 80W HERBICIDE
| 330-54-1 |
|
CLEAR SATIN LACQUER, X-5093
| 9004-70-0 |
|
BUFFAR PH 7.00
| |
|
STAINING BLACK DXX-553
| 123-86-4
71-36-3
9004-70-0
1333-86-4
64-17-5 |
|
479265 CALIBRATION CHECK GAS, 2.5% CARBON DIOXIDE IN(SUPDAT)
| 124-38-9 |
|
SPRAPO
| |
|
SPRAY BUFF
| |
|
SODIUM HYDROSULFITE
| 7775-14-6 |
|
SILVER-INDIUM-LEAD
| 7440-22-4
7440-74-6
7439-92-1 |
|
MILDEW STAIN REMOVER 16 OZ BOTTLE, 85616
| 10022-70-5 |
|
KWIK KOLD REGULAR 101, OHSOE518
| 6484-52-2
7732-18-5 |
|
DUPONT OIL YELLOW PDR
| 97-56-3 |
|
DUPONT OIL BROWN N
| 61867-96-7 |
|
DELVAC MOBIL DELVAC 1200 SUPER 15W-40
| |
|
OMNI-CLEANER PLUS
| 9038-95-3
7732-18-5
102-71-6
95-14-7
26172-55-4 |
|
SIL C-4401
| 9004-34-6
7782-42-5
9003-18-3
112945-52-5
13983-17-0
26125-61-1
1332-58-7 |
|
BENCHMARK INK
| 71-55-6
64741-66-7
13463-67-7
58353-09-6 |
|
INTERIOR-EXTERIOR ACRYLIC LATEX SEMI- (SUPP DATA)
| 57-55-6
25265-77-4
7664-41-7
64742-47-8 |
|
INTERIOR-EXTERIOR ACRYLIC LATEX SEMI- (SUPP DATA)
| 57-55-6
25265-77-4
7664-41-7
64742-47-8 |
|
CHLORIDE(CL) TEST PACKS, 701977901
| 7697-37-2
7782-61-8
57-13-6 |
|
LUBRIPLATE FMO-350(AEROSOL)
| 74-98-6 |
|
MIL-C-22750 14062 PTB, D1925G004B
| 25036-25-3
107-98-2
20344-49-4
13463-67-7
14808-60-7
123-86-4
141-78-6
108-88-3
78-93-3 |
|
SODIUM TRIFLUOROMETHANESULFONATE, 20837
| 2926-30-9 |
|
BELZONA 9221(BELZONA SUREFOOT AGGREGATE) (SUPP DATA)
| 1344-28-1 |
|
B&B TC-100
| |
|
INDALLOY 2 W/RMA FLUX
| 7440-31-5
7440-22-4
7440-36-0
7440-69-9
7440-74-6
112-34-5
7439-92-1 |
|
2-CYCLE TC-W3
| 64741-88-4
64742-47-8 |
|
TOP GRIT
| 64742-47-8
5989-27-5 |
|
SILOXANE 220
| 64741-65-7 |
|
HIGH ALKALINITY REAGENT, R5656, 7656
| |
|
PHOSPHATE ACTIVATOR SOLUTION, C849, 3268
| 10025-69-1 |
|
PHOSPHATE CHEMETS, C847, 3267
| 7664-93-9 |
|
L-12616
| 108-88-3
127-18-4 |
|
L-12618
| 107-06-2 |
|
PLAST 27 PHENOLIC MICROBALLOONS
| 9003-35-4 |
|
PLAST 70 STYRENE MONOMER, INHIBITED
| 100-42-5
98-29-3 |
|
LIQUID HARDENER, 30045
| 1338-23-4
7722-84-1
131-11-3 |
|
LIQUID HARDENER, 30046
| 1338-23-4
7722-84-1
131-11-3 |
|
LIQUID HARDENER, 30047
| 131-11-3
1338-23-4
7722-84-1 |
|
|