| MSDS | : | 47-076 SONOMERIC 1 | | CAS | : | 95-63-6
8052-42-4
8052-41-3
584-84-9
64742-95-6
1305-78-8
14808-60-7
14807-96-6 | | NAME | : | 1,2,4-trimethylbenzene
asphalt fumes, asphalt, cutback asphalt
stoddard solvent (petroleum distillate), mineral spirits
toluene-2,4-diisocyanate (tdi) (suspected animal carcinogen
solvent naphtha, petroleum, light aromatic, high flash
calcium oxide; lime
silica dioxide, crystalline quartz, sand (suspected human
talc (powder), (asbestos free), talcum; hydrous magnesium
|
| |
|
|
===================== Product Identification =====================
MSDS NAME:47-076 SONOMERIC 1
NIIN:00F034363
MSDS Number: BTNKY
=== Responsible Party ===
Company:CHEMREX INC
Address:889 VALLEY PARK DR
City:SHAKOPEE
State:MN
ZIP:55379
Country:US
Info Phone Num:612-496-6000/612-496-6027
Emergency Phone Num:612-496-6000
Preparer's Name:MARK HORTON
CAGE:CHEMR
=== Contractor Identification ===
Company:CHEMREX INC
Address:889 VALLEY PARK DR
City:SHAKOPEE
State:MN
ZIP:55379
Country:US
Phone:612-496-6000/612-496-6027
CAGE:CHEMR
Company:SONNEBORN BUILDING PRODUCTS REXNORD CHEM PROD
Address:7711 COMPUTER AVE
Box:City:MINNEAPOLIS
State:MN
ZIP:55435
Country:US
Phone:612-835-3434;800-424-9300(CHEMTREC)
CAGE:63472
============= Composition/Information on Ingredients =============
Name:1,2,4-TRIMETHYLBENZENE
CAS:95-63-6
RTECS #:DC3325000
Fraction by Wt: 1-3%
ACGIH TLV:25 PPM
Name:ASPHALT FUMES, ASPHALT, CUTBACK ASPHALT
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: 5-15%
Other REC Limits:5 MG/CUM
ACGIH TLV:5 MG/CUM
Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 1-5%
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Name:TOLUENE-2,4-DIISOCYANATE (TDI) (SUSPECTED ANIMAL CARCINOGEN
BY IARC) GROUP 2B *94-2
CAS:584-84-9
RTECS #:CZ6300000
Fraction by Wt: <0.1%
Other REC Limits:0.005 PPM
OSHA PEL:0.02 PPM, CEILING
ACGIH TLV:0.005 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
AROMATIC NAPHTHA
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 3-5%
Name:CALCIUM OXIDE; LIME
CAS:1305-78-8
RTECS #:EW3100000
Fraction by Wt: 4-8%
OSHA PEL:5 MG/CUM
ACGIH TLV:2 MG/CUM
Name:SILICA DIOXIDE, CRYSTALLINE QUARTZ, SAND (SUSPECTED HUMAN
CARCINOGEN BY IARC, NTP). GROUP 2A - *93-4*
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <0.1%
Other REC Limits:0.05 MG/CUM NIOSH
ACGIH TLV:0.1 MG/CUM RESP DUST
Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 5-10%
ACGIH TLV:2 MG/CUM (RESP DUST)
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): >5000 MG/KG (SEE SUPP)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATE IRRITANT/MAY CAUSE
REVERSIBLE CORNEAL INJURY. SKIN: SEVERE IRRITATION, MAY CAUSE
DERMATITIS & ALLERGIC RESPONSES. INHALATION: SEVERE IRRITANT. THIS
PRODUCT MAY CONTAIN ISOCYANATE WHICH MAY PRODUCE RESPIRATORY TRACT
IRRITATION, BRONCHITIS, BRONCHIAL SPASMS & PULMONARY EDEMA.
INGESTION: IRRITATION.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:IRRITATION, TEARING, REDDENING, SWELLING,
BLISTERS, COUGHING, CHEST DISCOMFORT, SHORTNESS OF BREATH.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY/SKIN
CONDITIONS
======================= First Aid Measures =======================
Eyes: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH
THOROUGHLY W/SOAP/WATER. WIPE/FLUSH W/ISOPROPYL ALCOHOL. WASH AGAIN
W/SOAP & WATER. INHALATION: MOVE TO FRESH AIR. GIVE OXYGEN/APPLY
CPR IF NECESS ARY. INGESTION: DON'T INDUCE VOMITING. IF VOMITING
OCCURS, KEEP VICTIM'S HEAD BELOW HIPS TO AVOID ASPIRATION OF
VOMITUS INTO THE LUNGS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:105F
Lower Limits:0.9
Upper Limits:7
Extinguishing Media:WATER SPRAY(FOG), FOAM, DRY CHEMICAL/CO2
Fire Fighting Procedures:WEAR SCBA/AIR MASKS. CONTAINERS EXPOSED TO
FIRE SHOULD BE KEPT COOL W/WATER SPRAY. WATER STREAM INTO FIRE, MAY
CAUSE FROTHING W/SUBSEQUENT SPREAD OF FIRE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO HEAT. VAPOR IS >AIR & TRAVEL ALONG GROUND/FLOOR & BE
IGNITED AT LOCATIONS DISTANT FROM THE SOURCE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE & REMOVE ALL IGNITION SOURCES.
EVACUATE AREA. SMALL: WIPE UP W/RAGS/TOWELS & PUT IN LOOSELY
COVERED CONTAINERS IN A WELL-VENTILATED AREA. LARGE: USE
RESPIRATORY PROTECTION. DIKE/IMPOUND LIQU ID. COVER W/ABSORBENT
COMPOUND.(SEE SUPP)
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
USE ONLY W/ADEQUATE VENTILATION. WEAR PROTECTIVE CLOTHING AT ALL
TIMES. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:DON'T BREATHE VAPORS. AVOID CONTACT W/EYES, SKIN &
CLOTHING. DON'T TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATORY PROTECTION
WHEN THE PRODUCT IS MIXED/APPLIED IN A POORLY VENTILATED AREA/IF
WORKPLACE LEVELS OF INGREDIENTS EXCEED TLV.
Ventilation:LOCAL EXHAUST AS NEEDED TO KEEP VAPOR/DUST LEVELS BELOW
RECOMMENDED LIMITS.
Protective Gloves:NATURAL/BUTYL RUBBER
Eye Protection:SAFETY GOGGLES
Other Protective Equipment:POLYVINYL ALCOHOL/NITRILE GLOVES, PROTECTIVE
CLOTHING TO COVER ARMS & LEGS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER USING.
Supplemental Safety and Health
SPILL PROC CONT'D: USE NON-SPARKING TOOLS TO SWEEP/SHOVEL INTO
CONTAINERS. COVER LOOSELY/REMOVE TO A WELL-VENTILATED AREA. REPEAT
SORBENT/SWEEP CYCLE UNTIL DRY. RINSE AREA W/WATER & FLUSH TO SEWER.
LD 50 INFORMATION IS FOR MINERAL SPIRITS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:240F-450F
Vapor Pres:8
Vapor Density:>1
Spec Gravity:1.08
Evaporation Rate & Reference:SLOWER THAN N-BU AC
Solubility in Water:< 0.1%
Appearance and Odor:THICK BLACK LIQUID W/TYPICAL PAINT THINNER ODOR
Percent Volatiles by Volume:5-15
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, ALCOHOLS, AMINES, STRONG OXIDANTS, STRONG BASES/ACIDS.
Stability Condition to Avoid:WATER VAPOR, SOURCES OF IGNITION &
LONGTERM EXPOSURE TO ELEVATED TEMPERATURES.
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN, HYDROGEN
CYANIDE GAS, OTHER ACRID & TOXIC FUMES.
Conditions to Avoid Polymerization:MOISTURE/OTHER MATERIALS THAT REACT
W/ISOCYANATES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T INCINERATE CLOSED CONTAINERS. DON'T
DISCHARGE UNDILUTED/CLEAN UP WASTE TO SANITARY SEWERS, LAKES,
STREAMS/PONDS. DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGUALTIONS. FLAMMABLE LIQUID U N1993.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|