===================== Product Identification =====================
MSDS NAME:KEN-REACT KR55
NIIN:00N092341
Status Code:A
MSDS Number: CJRRV
=== Responsible Party ===
Company:KENRICH PETROCHEMICAL INC
Address:140 EAST 22ND ST
Box:32
City:BAYONNE
State:NJ
ZIP:07002-0032
Country:US
Info Phone Num:201-823-9000
Emergency Phone Num:201-823-9000
CAGE:8J811
=== Contractor Identification ===
Company:KENRICH PETROCHEMICALS, INC.
Address:140 EAST 22ND ST
Box:32
City:BAYONNE
State:NJ
ZIP:07002-0032
Country:US
Phone:201-823-9000
CAGE:8J811
============= Composition/Information on Ingredients =============
Name:TITANIUM IV TATRAKIS (2,2-BIS(2-PROPENYLOXY)
METHYL-1-BUTANOLATO-0) AUDDUCT 2 MOLES (DITRIDECYL PHOSPHITO-0),
DIHYDROGEN
CAS:64157-14-8
= Wt:95.
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: BREATHING: THIS SUBSTANCE HAS
THE POTENTIAL OF BEING A RESPIRATORY TRACT IRRITANT. SKIN:
PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE SKIN IRRITATION. EYE:
CONTACT WITH EYES WILL CAUSE EYE IRRI TATION. INGESTION: MAY BE
HARMFUL IF SWALLOWED. INHALATION: THERE IS A POTENTIAL FOR
IRRITATION OF THE RESPIRATORY TRACT. CHRONIC: NOT KNOWN.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT KNOWN.
======================= First Aid Measures =======================
First Aid:SKIN: WASH WITH SOAP AND WATER. GET MEDICAL ATTENTION IF
IRRITATION DEVELOPS OR PERSISTS. EYES: IMMEDIATELY FLUSH EYES WITH
PLENTY OF WATER FOR AT LEAST 15 MINUTES, HOLDING EYELIDS APART. GET
IMMEDIAT E MEDICAL ATTENTION IF IRRITATION OR OTHER SYMPTOMS
DEVELOP. INGESTION: GET IMMEDIATE MEDICAL ATTENTION. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. INHALATION: IF EXPOSED
TO EXCESSIVE LEVE LS OF VAPORS OR MISTS, REMOVE TO FRESH AIR AND
GET IMMEDIATE MEDICAL ATTENTION IF COUGH OR OTHER SYMPTOMS DEVELOP.
INGESTION: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=82.2C, 180.F
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . EVACUATE AREA AND FIGHT FIRE FROM A SAFE DISTANCE. USE
CAUTION WHEN USING WATER AS FROTHING MAY OCCUR AND THEREBY
INCREASING FIRE INTENSITY.
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES UPON THERMAL
DECOMOSITION. SENSITIVITY TO EXPLOSION BY MECHANICAL IMPACT: NONE.
SENSITIVITY TO EXPLOSION BY STATIC DISCHARGE: POTENTIAL EXISTS.
CONDITIONS OF FLAMMABILITY: MATERIA L WILL BURN-AVOID SOURCES OF
IGNITION AND ALSO AVOID TEMPERATURES THAT ARE WITHIN RANGE OF THE
FLASH POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:GENERAL: THIS MATL SHOULD BE PREVENTED FROM
CONTAMINATING SOIL FAR FROM SEWERAGE & DRAINAGE SYS & BODIES OF
H*2O. ISOLATE HAZ/SPILL AREA. KEEP UNNEC & UNPROTECTED PERS FROM
ENTERING AREA. SMALL SPILL: ABSORB SPILL W/INERT MATL, THEN PLACE
IN CHEM WASTE CNTNR. LARGE SPILL: SHUT OFF LEAK, IF SAFE TO DO SO.
CLEAN UP SPILLS IMMED, OBSERVING PREC IN PROT EQUIP SECTION.
(SUPDAT)
====================== Handling and Storage ======================
Handling and Storage Precautions:HANDLING: ALTHOUGH THIS MATL DOES NOT
PRESENT A SIGNIFICANT SKIN/EYE HAZ, SKIN & EYE CONTACT SHOULD BE
PREVENTED AS GOOD INDUSTRIAL HYGIENE PRACTICE. WEARING OF PROT
GLOVES & EYE PROT IS RECOMMENDED. ALWAYS ESTABLISH PRACTICE OF
WASHING ARMS & HANDS, AS W/ANY CHEM, AFTER HANDLING.
Other Precautions:STORAGE: STORE IN A COOL, DRY AND WELL VENTILATED
AREA. AVOID CONTACT OR EXPOSURE TO INCOMPATIBLE SUBSTANCES. ALSO
AVOID THOSE AREAS WHERE THERE ARE IGNITION SOURCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPRVD AIR PURIFYING RESP MAY BE
PERMISSIBLE UNDER CERTAIN CIRCUMSTANCES WHERE AIRBORNE CONCS ARE
EXPECTED TO EXCEED EXPOS LIM, IF ESTABLISED. CONSULT W/RESP MFR TO
DETERM APPROP TYPE OF EQUIP F OR GIVEN APPLICATION. PROT PROVIDED
BY AIR PURIFYING RESP IS LIMITED. USE POS PRESS ARE SUPPLIED RESP
IF THERE IS ANY POTENTIAL FOR AN UNCONTROLLED (SUPDAT)
Ventilation:SOURCE(S) OF FINE SPRAY, MIST OR VAPOR SHOULD BE CONTROLLED
WITH LOCAL EXHAUST VENTILATION.
Protective Gloves:IMPERVIOUS GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . WEAR CHEMICAL PROTECTIVE CLOTHING, INCLUDING
IMPERVIOUS SLEEVELETS, OVERALLS, APRONS, OR BOOTS AS NEEDED TO
PREVENT CONTACT WITH THE SKIN.
Supplemental Safety and Health
SPILL PROC: CONTAIN SPILLED LIQ W/SAND/EARTH. RETAIN ALL CONTAMD H*2O &
SOIL FOR REMOVAL & TREATMENT. RESP PROT: RELEASE, EXPOS LEVELS ARE
NOT KNOWN/ANY OTHER CIRCUMSTANCES WHERE AIR PURIFYING RESP MA Y NOT
PROVIDE ADEQUATE PROT. A RESP PROT PROGRAM THAT MEETS OSHA 1910.134
& ANSI Z88.2 (OTHER INFO)
================== Physical/Chemical Properties ==================
Boiling Pt:=48.9C, 120.F
Vapor Density:HVR/AIR
Spec Gravity:0.97 @ 60F (RELTO H*20)
pH:4.0 - 6.0
Viscosity:100 CPS @ 77F
Evaporation Rate & Reference:SLOWER THAN N-BU AC
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR YELLOW LIQUID; PHOSPHITIC ODOR.
Percent Volatiles by Volume:100 @ 77C
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS.
Stability Condition to Avoid:KEEP FROM CONTACT WITH OXIDIZERS, ACIDS.
AVOID SOURCES OF IGNITION.
=================== Toxicological Information ===================
Toxicological Information:ACUTE ORAL LD50 10.3 G/KG. PRIMARY DERMAL
IRRITATION - 3.1 (MODERATE IRRITANT). INHALATION LC50 (RAT) > 200
MG/LITER FOR 1 HOUR.
===================== Ecological Information =====================
Ecological:ECOTOXICOLOGICAL AND CHEMICAL FATE INFORMATION: NOT
DETERMINED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE
AND LOCAL REGULATIONS. CONTAINER DISPOSAL: DISPOSE OF IN ACCORDANCE
WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:DOT SHIPPING NAME: COMBUSTIBLE LIQUID, N.O.S.
HAZARD CLASS: COMBUSTIBLE LIQUID. PACKING GROUP: III. UN/NA NO: NA
1993. DOT LABELS: COMBUSTIBLE LIQUID. SUBSIDIARY LABEL: NONE. DOT
PLACARD: COMBUSTIBLE. IMO SHIPPING: COMBUSTIBLE LIQUID, N.O.S.
HAZARD CLASS: COMBUSTIBLE LIQUID. PACKING GROUP: III. UN NO: NA
1993. IMO LABELS: COMBUSTIBLE LIQUID. SUBSIDIARY LABEL: NONE. IATA
SHIPPING NAME: COMBUSTIBLE LIQUID, N.O.S. HAZARD CLASS:
COMBUSTIBLE LIQUID. PACKING GROUP: III. UN NO: NA 1993. IATA
LABELS: COMBUSTIBLE LIQUID. SUBSIDIARY LABEL: NONE.
===================== Regulatory Information =====================
SARA Title III Information:SARA 311/312 CHRONIC HEALTH HAZARD: NOT
DETERMINED. SARA 311/312 ACUTE HEALTH HAZARD: IRRITANT. SARA
311/312 FIRE HAZARD: YES. SARA 311/312 SUDDEN PRESSURE: NO. SARA
311/312 REACTIVITY HAZARD: NO. SEC TION 313 TOXIC CHEMICAL(S):
NONE.
Federal Regulatory Information:REPORTED IN TSCA INVENTORY: YES. TSCA
RULINGS: NONE TO MFR KNOWLEDGE. REPORTED IN EEC INVENTORY: YES.
REPORTED IN CANADA INVENTORY: YES. REPORTED IN AUSTRALIAN
INVENTORY: YES. REPORTED IN JAPAN'S MITI : YES. SECTION 302 -
EXTREMELY HAZARDOUS INGREDIENT(S): NONE. CERCLA HAZARDOUS
SUBSTANCE(S): NONE.
State Regulatory Information:NJ ENVIRONMENTAL HAZARDOUS SUBSTANCES
LIST: NOT LISTED. OTHER STATES LISTINGS: NOT LISTED TO MFR'S
KNOWLEDGE. CALIFORNIA PROPOSITION 65 INGREDIENTS: NONE.
======================= Other Information =======================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|