===================== Product Identification =====================
MSDS NAME:NICROBRAZ CEMENT 600
NIIN:01-057-2756
MSDS Number: BGJND
=== Responsible Party ===
Company:WALL COLMONOY CORPORATION
Address:30261 STEPHENSON HIGHWAY
City:MADISON HEIGHTS
State:MI
ZIP:48071
Country:US
Info Phone Num:(313)585-6400
Emergency Phone Num:(313)585-6400
CAGE:OALF5
=== Contractor Identification ===
Company:WALL COLMONOY CORPORATION
Address:30261 STEPHENSON HWY.
City:MADISON HEIGHTS
State:MI
ZIP:48071
Phone:(313) 585-6400
CAGE:OALF5
Company:WALL COMPANY CORP
Address:30261 STEPHENSON HWY
Box:City:MADISON HEIGHTS
State:MI
ZIP:48071
Country:US
CAGE:63585
============= Composition/Information on Ingredients =============
Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 93%
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Name:NON-HAZARDOUS RESIN(WHICH IS A 'TRADE SECRET' )
Fraction by Wt: 7%
Name:VOL. ORGANIC CMPD: PER CALIFIRNIA RULE 1107, PARAG. 3 & 15,
VOC AS AIR-DRIED IS ZERO (0) GM/L.
RTECS #:9999999VO
Fraction by Wt: 3%
OSHA PEL:50PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50(ORAL RAT 10300 MG/KG; LC50 1000PPM
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: 'CNS' DEPRESSANT, RESPIRATORY
SYSTEM IRRITANT, AS WELL AS EYE/SKIN IRRITANT. CHRONIC: LIVER &
KIDNEY TOXIN UPON PROLONGED EXPOSURE ABOVE EXPOSURE LIMITS.
EXPOSURE TO HIGH-CONCENTRATIONS IN A CO NFINED OR POORLY VENTED
AREA MAY CAUSE DEATH.
Explanation of Carcinogenicity:MANUFACTURER STATES NO INGREDIENTS
LISTED AS A CARCINOGEN
Effects of Overexposure:INHAL: HEADACHE, DIZZINESS,STUPOR,
NAUSEA(VOMITING), FATIGUE, RESPIRATORY SYSTM IRRITATION,
LIGHT-HEADEDNESS, COORDINATION & EQUILIBRIUM LOSS; EYE: IRRITATION,
REDNESS; SKIN: IRRITATION, DERMATITIS, R EDNESS; INGEST: NAUSEA,
VOMITING.
Medical Cond Aggravated by Exposure:LIVER DISEASE & RYTHM DISORDER OF
THE HEART. NOTE: HEART MAY BE SENSITIZED BY OVER-EXPOSURE &
VENTRICULAR ARRHYTHMIA MAY BE INDUCED BY EPINEOPHRINE
ADMINISTRATION.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE PERSON TO FRESH AIR. IF UNCONSCIOUS, GIVE
ARTIFICIAL RESPIRATION OR O2 AS SITUATION DICTATES; EYES: FLUSH
W/WATER AT LEAST 15 MIN. SEEK MED. ATTN; SKIN: WASH W/PLENTY OF
SOAP & WATER; INGE ST: DO NOT INDUCE VOMITING. SEEK IMMEDIATE
MEDICAL ATTEN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Lower Limits:8.0
Upper Limits:10.5
Extinguishing Media:FIRE UNLIKELY, BUT IF IT OCCURS CAN BE CONTRILLED
BY CARBON DIOXIDE, DRY CHEMICALS OR WATER FOG.
Fire Fighting Procedures:SELF CONTAINED RESPIRATORY PROTECTION.
CONTAINERS EXPOSED TO FIRE SHOULD BE KEPT COOL W/WATER SPRAY.
Unusual Fire/Explosion Hazard:VAPORS CAN BE DECOMPOSED BY INTENSE HEAT
OR OPEN FLAMES TO RELEASE HCL OR PHOSGENE.
================== Accidental Release Measures ==================
Spill Release Procedures:SOAK UP WITH ABSORBENT MATERIAL. PLACE IN
CLOSED CONTAINER. LABEL & STORE IN SAFE PLACE UNTIL DISPOSAL.
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED IN A COOL WELL
VENTILATED AREA. DO NOT STORE IN PITS OR BASEMENTS.KEEP IN LABELED
CONTAINERS.
Other Precautions:AVOID WELDING OPEN FLAMES & INTRA-RED HEATERS. DO NOT
STORE IN ALUMINUM CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT REQUIRED IF USED W/GOOD VENTILATION. IF
ENGINEERING CONTROLS DO NOT KEEP INHALATION EXPOSURE BELOW PEL/TLV,
USE NIOSH/MSHA APPROVED RESPIRATORS PER CURRENT
29CFR1910.134,INSTRUCTIONS/WARNING & NIO SH-RESPIRATOR DECISION
LOGIC.
Ventilation:PROVIDE SUFFICIENT GENERAL/LOCAL EXHAUST VENTILATION IN
PATTERN/VOLUME TO CONTROL INHALATION EXPOSURES BELOW PEL/TLV.
Protective Gloves:POLYVINYL ALCOHOL TYPE/ NEOPRENE
Eye Protection:AS REQUIRED FOR TASK AT HAND(CHM GOGGLES
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND TO MINIMIZE
EXPOSURE.
Work Hygienic Practices:AVOID REPEATED CONTACT W/SKIN OR PROLONGED
BREATHING OF VAPORS. DO NOT GET NEAR ANY STRONG OXIDANTS.
Supplemental Safety and Health
WASH SKIN AFTER HANDLING & BEFORE EATING. DO NOT EAT IN VICINITY OF
USE. WASH CONTAMINATED CLOTHING BEFORE REUSE.
================== Physical/Chemical Properties ==================
HCC:T4
Boiling Pt:B.P. Text:165F/73.9C
Vapor Pres:125 @ 77F
Vapor Density:4.55
Spec Gravity:1.32
Evaporation Rate & Reference:(BUTYL ACETATE = 1), 0.37
Solubility in Water:0.07 %
Appearance and Odor:CLEAR,COLORLESS LIQUID WITH A CHLOROFORM-LIKE ODOR.
Percent Volatiles by Volume:96.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES SUCH AS SODIUM HYDROXIDE. SHOULD NOT BE USED IN CONTACT
WITH ALUMINUM OR ZINC OR THEIR ALLOYS.
Stability Condition to Avoid:WELDING,OPEN FLAME & INFRA-RED HEATERS.
Hazardous Decomposition Products:HCL DURING THERMAL DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:NORMALLY RECOVERED FROM RESIDUE BY DISTILLATION.
SMALL QUANTITIES MAY BE DISPOSED VIA AN INCINERATION-SCRUBBER OR A
LICENSED WASTE HAULER. CHECK LOCAL REGULATIONS. DO NOT CONTAMINATE
WATER.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|