MATERIAL SAFETY DATA SHEET (MSDS)
24 HOUR EMERGENCY PHONE: CHEMTREC 1-800-424-9300
Effective Date: Jan. 1, 2001 / Supersedes: Jan. 1, 2000 / PAGE 1 OF 2
JBS INDUSTRIES, INC.
1184 PETIGRU DRIVE, PAWLEYS ISLAND SC 29585
TELEPHONE: 1-800-925-8958
SECTION 1 PRODUCT & COMPANY IDENTIFICATION
PRODUCT NAME: MIGHTY WHITE PRODUCT NUMBER: TR-150
LIQUID ALKALINE DETERGENT
PRODUCT DESCRIPTION:
JBS Industries, Inc.
MANUFACTURER: PHONE: 800-925-8958
1184 Petigru Drive FAX: 800-201-8546
Pawleys Island, SC 29585
SECTION 2 COMPOSITION / INFORMATION ON INGREDIENTS
HAZARDOUS INGREDIENTS: EFFECT CAS# PERCENT
POTASSIUM HYDROXIDE CORROSIVE TO SKIN & EYES 7732-18-5 0-5
SODIUM METASILICATE CORROSIVE TO EYES 6834-92-0 0-5
TETRASODIUM EDTA SKIN & EYE IRRITANT 64-02-8 0-5
NTA Nag MONOHYDRATE CORROSIVE TO EYES 5064-31-3 0-2
PROPRIETARY SURFACTANT BLEND EYE IRRITANT NOT APPLICABLE 0-20
HAZARDOUS INGREDIENTS: EXPOSURE LIMITS OF INGREDIENTS
OSHA PEL ACGIH TLV
POTASSIUM HYDROXIDE 2MG/M3 2MG/M3
SODIUM METASILICATE NOT ESTABLISHED NOT ESTABLISHED
TETRASODIUM EDTA NOT ESTABLISHED NOT ESTABLISHED
NTA Nag MONOHYDRATE NOT ESTABLISHED NOT ESTABLISHED
PROPRIETARY SURFACTANT BLEND NOT ESTABLISHED NOT ESTABLISHED
SECTION 3 HAZARDS IDENTIFICATION
>>>>>>>>>>>>>>>>>>>>EMERGENCY OVERVIEW<<<<<<<<<<<<<<<<<<<
VERY IRRITATING TO EYES. INHALATION OF MISTS MAY BE IRRITATING TO THROAT AND RESPIRATORY TRACT.
REPEATED CONTACT WITH SKIN CAN REMOVE NATURAL OILS AND CAUSE DRYNESS AND IRRITATION.
>>>>>>>>>>>>>>>>>>>>>>>>>>>><<<<<<<<<<<<<<<<<<<<<<<<<<<<<<
SECTION 4 FIRST AID MEASURES
FLUSH WITH LARGE QUANTITIES OF WATER, HOLDING EYELIDS OPEN. GET IMMEDIATE
EYES: MEDICAL ATTENTION.
REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. SEEK MEDICAL
SKIN: ATTENTION IF IRRITATION PERSISTS.
GIVE WATER IF CONSCIOUS. DO NOT INDUCE VOMITING, ALTHOUGH VOMITING MAY OCCUR
NATURALLY. GET IMMEDIATE MEDICAL ATTENTION.
INGESTION:
INHALATION: MOVE PERSON TO FRESH AIR. SEEK MEDICAL ATTENTION IF IRRITATION PERSITS.
SECTION 5 FIRE FIGHTING MEASURES
FLAMMABLE PROPERTIES: FLASH POINT: NONE
METHOD USED: NOT APPLICABLE
PRODUCT WILL NOT BURN. NO KNOWN HAZARDOUS DECOMPOSITION PRODUCTS.
UNUSUAL FIRE & EXPLOSION HAZARDS: UPON CONTACT WITH DUSTS OF AL, SN, OR ZN, MAY PRODUCE
HYDROGEN GAS, WHICH IS FLAMMABLE.
FIRE FIGHTING PROCEDURES: APPROPRIATE FOR SURROUNDING MATERIALS.
SECTION 6 ACCIDENTAL RELEASE MEASURES
SPILLS & LEAKS: SMALL SPILLS: RINSE TO DRAIN.
LARGE SPILLS: CONTAIN FOR RECLAMATION OR DISPOSAL.
CAUTION: SPILLS OF THIS MATERIAL MAY CAUSE FLOOR TO BECOME SLIPPERY.
SECTION 7 HANDLING & STORAGE
STORE IN ORIGINAL CONTAINER AT TEMPERATURES BELOW 120 DEGREES F.
PRODUCT IS BEST WHEN USED WITHIN 6 MONTHS OF DATE OF PURCHASE.
MSDS - JBS INDUSTRIES, INC. (CONT.) MIGHTY WHITE PAGE 2 OF 2
SECTION 8 EXPOSURE CONTROLS / PERSONAL PROTECTION
EYES: WEAR CHEMICAL GOGGLES.
SKIN: NEOPRENE GLOVES. RUBBER APRON IF GREATER EXPOSURE IS LIKELY.
RESPIRATORY: GOOD GENERAL VENTILATION. RESPIRATOR NOT NORMALLY REQUIRED.
SECTION 9 PHYSICAL & CHEMICAL PROPERTIES
APPEARANCE & ODOR: PURPLE, THIN LIQUID WITH CHARACTERISTIC ODOR.
SOLUBILITY IN WATER: COMPLETE
% VOLATILE (W/W): >65, MOSTLY WATER FREEZING POINT: NEAR WATER.
PH FULL STRENGTH: 13.5 SPECIFIC GRAVITY: 1.11
SECTION 10 STABILITY & REACTIVITY
STABILITY: THIS IS A STABLE MATERIAL.
CONDITIONS TO AVOID: NONE KNOWN.
MATERIALS TO AVOID: STRONG ACIDS, DUSTS OF ALUMINUM, TIN AND ZINC.
HAZARDOUS POLYMERIZATION WILL NOT OCCUR.
SECTION 11 TOXICOLOGICAL INFORMATION
NO DATA AVAILABLE ON THIS MIXTURE. FOR INFORMATION ON INGREDIENTS, WRITE TO THE ADDRESS LISTED IN
SECTION 1 OF THIS MSDS.
SECTION 12 ECOLOGICAL INFORMATION
NO DATA AVAILABLE ON THIS MIXTURE. ALL SURFACTANT COMPONENTS ARE BIODEGRADABLE. THIS PRODUCT
CONTAINS NO PHOSPHATES.
SECTION 13 DISPOSAL CONSIDERATIONS
FOLLOW ALL FEDERAL, STATE, AND LOCAL REGULATIONS APPROPRIATE FOR THIS MATERIAL. NEUTRALIZE PH WITH
DILUTED ACID BEFORE DISPOSAL.
SECTION 14 TRANSPORTATION INFORMATION
D.O.T. HAZARDOUS MATERIAL CLASS: POTASSIUM HYDROXIDE SOLUTION, CLASS 8, PG II
UN NUMBER: UN1814 NA NUMBER: NOT APPLICABLE
SECTION 15 REGULATORY INFORMATION
FACILITIES STORING MORE THAN 38,000 GALLONS OF THIS MATERIAL MUST FILE A SARA TITLE III FOR POTASSIUM HYDROXIDE.
SECTION 16 OTHER INFORMATION
***HAZARD RATINGS PROVIDED FOR USE BY TRAINED INDIVIDUALS ONLY.***
HMIS RATINGS (0=MINIMAL, 1=SLIGHT, 2=MODERATE, 3=SERIOUS, 4=SEVERE HAZARD)
FOR CONCENTRATE: HEALTH: 3 FLAMMABILITY: 0 REACTIVITY: 0
NFPA RATINGS (0=MINIMAL, 1=SLIGHT, 2=MODERATE, 3=SERIOUS, 4=SEVERE HAZARD)
FOR CONCENTRATE: HEALTH: 3 FLAMMABILITY: 0 REACTIVITY: 0
DILUTION OVER 30 TO 1: HEALTH: 2 FLAMMABILITY: 0 REACTIVITY: 0
The information relates to this specific material. It may not be valid for this material if used in combination with
any other materials or in any process. JBS Industries makes no warranty, express or implied as to the accuracy
or completeness or adequacy of information herein, except that such information is to the best of JBS Industries'
belief, accurate as of the date indicated. JBS Industries assumes no responsibility for injury from the use of the
product described herein.
JBS INDUSTRIES, INC. 1184 PETIGRU DRIVE PAWLEYS ISLAND, SC 29585, 800-925-8958
|