Pressure-Lube, Inc. Approval Date 1/29/2007
Material Safety Data Sheet Supersedes Date 1/6/2006
Section I. Chemical Product and Company Identification
JAX GEAR-GUARD SYNTHETIC (AEROSOL) Product JAX105
Product Name/
ID No.
Trade Name
Emergency Telephone
PRESSURE-LUBE, INC.
Supplier
W134 N5373 CAMPBELL DRIVE For Chemical Emergency, Spill, Leak, Fire,
Exposure or Accident, Call CHEMTREC:
MENOMONEE FALLS, WI 53051 USA
NORTH AMERICA 800-424-9300
INTERNATIONAL +01-703-527-3887 Collect
Synonym(s) None
Non-Emergency Contact
Chemical Name Not applicable
JAX: 262-781-7660
Chemical Family Mixture JAX/FAX: 262-781-3906
Chemical Formula Not applicable
Material Uses Lubricant
Section II. Composition and Information on Ingredients
Name PEL/TLV, Source CAS # % by Weight
PROPRIETARY FORMULA.
n-Pentane 600 ppm, OSHA 109-66-0 20-40
Isopentane 1000 ppm, OSHA 78-78-4 5-10
Zinc oxide 5 mg/m3, OSHA 1314-13-2 <5
Zinc sulfide 15 mg/m3, OSHA 1314-98-3 <5
Butane 800 ppm, OSHA 106-97-8 10-20
Propane 1000 ppm, OSHA 74-98-6 10-20
LC50, LD50 of Ingredients Not available
Section III. Hazards Identification
Emergency Overview Contents under pressure. Flammable. Do not store near heat, sparks or open flame. Store containers below 120掳F (49掳C).
Potential Health Effects:
Eye Contact Slightly irritating to the eye.
Skin Contact Unlikely that this product would absorb into the skin and cause damage. Prolonged exposure may cause defatting of the skin
which could lead to dryness and cracking. Redness and pain could occur. People prome to skin sensitiveness may be more
sensitive to this product.
Ingestion ACUTE ASPIRATION HAZARD. Slightly toxic by ingestion. There is a danger of this product being aspirated into the lungs during
vomiting. Aspiration can result in severe lung damage or death. May cause nausea, vomiting, pulmonary irritation, and bronchial
pneumonia when aspirated. Central nervous system depression may occur. May be fatal if swallowed.
Inhalation Tests on similar products indicate the possibility of the following symptoms: headache, nasal and respiratory irritation, nausea,
drowsiness, fatigue, dizziness, convulsions, and loss of consciousness. Can cause central nervous system depression.
Continued on Next Page
PAGE 2 OF 4
JAX GEAR-GUARD SYNTHETIC (AEROSOL)
Section III. Hazards Identification (cont'd)
1 4 0
HMIS Code Health: Fire: Reactivity:
1 4 0
NFPA Code Health: Fire: Reactivity:
Section IV. First Aid Measures
Flush with large amounts of water, occasionally lifting upper and lower eyelids. Be sure to remove contact lenses. Get medical
Eye Contact
attention.
Skin Contact Thoroughly wash exposed area with soap and water. Remove contaminated clothing and launder it before reuse. Should any
irritation persist, get medical attention.
Ingestion is not considered a potential route of exposure as an aerosol but, if swallowed, DO NOT induce vomiting. If
Ingestion
spontaneous vomiting is about to occur, place the victim's head below his knees to prevent aspiration. Never give anything by
mouth to an unconscious person. Call a physician immediately.
Inhalation If affected, remove individual to fresh air. If breathing is difficult, administer oxygen. If breathing has stopped, give artificial
respiration. Keep person warm and quiet. Contact physician immediately.
Section V. Fire and Explosion Data
Not available
Autoignition Temperature
Flash Point Not available
Flammable Limits (Approx.) LOWER Flammable Limit: 0.9% UPPER Flammable Limit: 9.5%
See Lower and Upper Flammable Limits
Explosion Hazards
Products of Combustion Fumes, smoke, carbon monoxide, carbon dioxide, sulfur oxides, and other oxides of incomplete combustion.
Fire Fighting Media Foam, water fog, dry chemical, carbon dioxide, and vaporizing liquid type extinguishing agents may all be suitable for
and Instructions extinguishing fires involving this type of product, depending on the size or potential size of fire and circumstances related to the
situation. Plan fire protection and response strategy through consultation with local fire protection authorities or appropriate
specialists. The following procedures for this type of product are based on the recommendations in the National Fire Protection
Association's Fire Protection Guide on Hazardous Materials. Use water to keep fire-exposed containers cool. If a leak or spill
has not ignited, use water spray to disperse the vapors and to provide protection for men attempting to stop a leak. Water spray
may be used to flush spills away from explosives. Use supplied-air breathing equipment for enclosed or confined spaces or as
otherwise needed.
Special Remarks - Avoid possible bursting of aerosol can. Do not store near open flame. Do not store where temperature may exceed 120掳F (49掳
Fire and Explosion C). Do not puncture or incinerate. Special fire fighting procedures: Avoid possible accumulations of vapors at floor level, as
Hazards vapor is heavier than air. Water may be ineffective. Self-contained breathing apparatus and protective clothing should be worn in
fighting fires involving chemicals. Do not use direct stream of water because product will float and can be reignited on surface of
water.
Section VI. Accidental Release Measures
Release or Spill Ventilate area, especially low places where vapors may collect. Extinguish all ignition sources. Contain spill; cover with inorganic
absorbent material. Collect spilled material; place in a DOT-approved container for disposal. Clean up residue. Refer to other
sections of MSDS for information regarding hazards, ventilation, and personal protective equipment.
Environmental Impact Report spills as required to the appropriate authorities. U.S Coast Guard Regulations require immediate reporting of spills that
could reach any waterway including intermittent dry creeks. Report spill to the Coast Guard toll-free number 800-424-8802.
Section VII. Handling and Storage
Keep away from heat, sparks and open flame. Do not throw empty container into fire or trash compactor. Do not get in eyes, on
Handling
skin or on clothing. Wash thoroughly after handling. Do not breath vapor or mist. Do not transfer to nor store in an unmarked
container. Read label before using. Do not smoke when handling or using this product. Do not cut on empty containers as they
may contain vapors that are flammable. Use with adequate ventilation. Do not take internally. Keep out of reach of children.
Store in tightly sealed containers. Do not store in direct sunlight. Keep away from heat, sparks and open flame. Store containers
Storage
below 120掳F (49掳C). Do not throw empty container into fire or trash compactor.
Continued on Next Page
PAGE 3 OF 4
JAX GEAR-GUARD SYNTHETIC (AEROSOL)
Section VIII. Exposure Controls and Personal Protection
NIOSH/MSHA-approved air-supplied respirator is advised in absence of proper environmental control.
Respiratory Protection
Local mechanical exhaust ventilation capable of maintaining emissions at the point of use below the PEL/TLV.
Ventilation
Use any lined non-permeable rubber gloves, such as buna or nitrile, if needed to avoid prolonged or repeated skin contact.
Protective Gloves
Eye Protection Chemical splash goggles or face shield in compliance with OSHA regulations are advised when eye contact may occur.
Wash exposed areas with soap and water when finished using this product. Do not eat or drink or wear facial cream when using
Personal Hygiene
this product. Do not swallow. Wash hands before eating or using washroom.
Implement engineering controls so that workplace exposure limit(s) of product or any component is not exceeded. Use impervious
Engineering Controls
protective clothing (gloves, boots, apron or full body suit) depending on operation.
Exposure Limit See PEL/TLV of ingredients in Section II
Section IX. Physical and Chemical Properties
Appearance/Odor Blue color with a light petroleum odor Vapor Pressure 65 psig @ 70掳F
Vapor Density Greater than 1.0 (air = 1)
Percent Volatile 65%
Odor Threshold Not available
Evaporation Rate Not available
Specific Gravity 0.78-0.80 concentrate
Not available Solubility in Water Insoluble
Density
Coefficient of Water/Oil Not available
Not available
pH
Distribution
Boiling Point Complex mixture
Liquid, grease and compressed gas in aerosol
Physical State
Freezing/Melting Point Not available can
Section X. Stability and Reactivity Data
Stable under normal temperatures and pressures.
Stability
Conditions of Reactivity Not available
Conditions and Materials Strong acids, alkalies, and oxidizers.
to Avoid
Hazardous Polymerization Hazardous polymerization will not occur.
Hazardous Decomposition Fumes, smoke, carbon monoxide, carbon dioxide, sulfur oxides, and other oxides of incomplete combustion.
Products
Section XI. Toxicological Information
Dermal contact, eye contact, inhalation, ingestion.
Routes of Entry Ingestion Not available
Toxicity to Animals Not available Inhalation Not available
Effects of Acute Exposure Not available Toxically Synergistic Not available
Products
Acute Effects of Not available
Sensitization
Chronic Effects on Humans:
Carcinogenic Effects This product does not contain a carcinogen or potential carcinogen as listed by NTP, IARC, or OSHA [29 CFR 1910.1200(D)#4].
Mutagenic Effects No data available to indicate any components present at greater than 0.1% may present a mutagenic hazard.
Continued on Next Page
PAGE 4 OF 4
JAX GEAR-GUARD SYNTHETIC (AEROSOL)
Section XI. Toxicological Information (cont'd)
Teratogenic Effects No data available to indicate any components present at greater than 0.1% may present a teratogenic hazard.
Reproductive Effects No data available to indicate any components present at greater than 0.1% may present a reproductive hazard.
Section XII. Ecological Information
There is no data available on the adverse effects of this material on the environment.
Ecotoxicity
Section XIII. Disposal Considerations
Consult federal, state or local authorities for proper disposal and reporting procedures. All disposals must comply wtih federal,
Waste Disposal
state and local regulations.
Section XIV. Transportation Information
I.A.T.A. Air Transportation: U.S. D.O.T. Ground Transportation:
Shipping Name Aerosols, flammable, n.o.s. Consumer Commodity ORM-D
Shipping Name
Hazard Class 2.1
UN Number UN1950
Packing Group None The above U.S. D.O.T. information applies to
U.S. D.O.T. Remarks
I.A.T.A. Remarks None shipping BY GROUND ONLY.
Section XV. Regulatory Information
U.S. Federal Regulations:
Release of the following chemical(s) at quantities equal to or greater than the reportable quantities (RQ), is regulated by
CERCLA
40 CFR 302.4 :
None
SARA (Section 313) This product contains the following chemical(s) listed in Section 313 at or above the de minimis concentrations:
Zinc oxide CAS# 1314-13-2
Zinc sulfide CAS# 1314-98-3
This product contains greater than 1.0% of the following chemical(s) on the SARA Extremely Hazardous Substances List:
SARA Extremely
Hazardous List
None
TSCA Inventory All components of this material are on the U.S. TSCA Inventory.
This product contains the following chemical(s) known to the State of California to cause birth defects or other reproductive
California Prop. 65
harm:
None
International Regulations:
Canada All components are in compliance with the Canadian Environmental Protection Act. This product has been classified in
accordance with the hazard criteria of the CPR and this MSDS contains all the information required by CPR.
Japan MITI Not available
Australia Not available
Switzerland Not available
Section XVI. Other Information
1/29/2007
Approval Date
1/6/2006
Supersedes Date
Technical Services 262-781-7660
Prepared by
Section I
Sections Revised
Since Last Version
The information and recommendations contained herein are, to the best of Pressure-Lube, Inc.'s knowledge and belief, accurate and reliable as of the date
issued. Pressure-Lube, Inc. makes no warranty or guarantee, expressed or implied, of their accuracy or reliability, and Pressure-Lube, Inc. shall not be liable
for any loss or damage based upon the criteria supplied by the developers of these rating systems, together with Pressure-Lube, Inc.'s interpretation of the
available data.
|