EYES:............................................................ Undiluted product will cause burns or eye irritation, or
MATERIAL SAFETY DATA SHEET possibly blindness.
SKIN (DERMAL):....................................... This product may cause burns or irritation if not removed
REVISION DATE: ................ 01/07/03
Simoniz USA Inc. from the skin. Chronic overexposure may cause injury to blood, liver & kidneys.
DATE PRINTED: ................. 12/15/06
201 Boston Turnpike
SECTION VII FIRST AID
Bolton, CT 06043 PRODUCT NUMBER: ......... P3015XXX
CONTROL NUMBER: ......... P3015XXX BREATHING (INHALATION):................ If victim shows signs of discomfort or irritation, remove
(860) 646-0172 to fresh air. If symptoms persist, get immediate medical attention.
SWALLOWING (INGESTION): .............. DO NOT INDUCE VOMITING! Drink a large quantity
For chemical emergency information regarding this product, call Chem-Tel at 1-800-255- of water or milk. Do not attempt to give liquids to an unconscious person. Get immediate medical
3924 anytime. attention!
EYES:............................................................ Flush eyes with a large quantity of fresh water for at least
15 minutes. If irritation persists, consult a physician.
SECTION I - IDENTIFICATION
SKIN (DERMAL):....................................... Flush from skin and clothing with large amounts of fresh
Prime Pak Tire White water. If irritation persists, consult physician. Wash contaminated clothing before wearing.
PRODUCT NAME:
SECTION VIII EMPLOYEE PROTECTION
PRODUCT TYPE: ...................................... Alkaline liquid cleaning compound
RESPIRATORY PROTECTION:............. Not usually needed in well ventilated areas. If needed, use
an OSHA approved respirator.
SECTION II - INGREDIENTS
PROTECTIVE CLOTHING: .................... Nitrile or PVC gloves, and chemical splash goggles.
INGREDIENT CAS NUMBER PEL PERCENT
ADDITIONAL MEASURES: .................... Do not place this product in an unmarked container!
Keep away from children! Spilled material is slippery.
7732-18-5 No limits established
Water Not
SECTION IX - SPILL AND DISPOSAL DATA
Listed.
SPILL: .......................................................... Dike to prevent spillage into streams or sewer systems.
111-76-2 20 ppm TLV, 25 ppm
2-Butoxy Ethanol
Consult local, state and federal authorities.
PEL
1310-58-3 2 mg/m3 ceiling WASTE DISPOSAL: .................................. As recommended by local, state and federal authorities.
Potassium Hydroxide
68439-57-6 No limits established HANDLING & STORAGE PRECAUTIONS...................................... Store in a cool, well ventilated
Sodium Alpha Olefin Sulfonate
1300-72-7 No limits established area. Avoid overheating or freezing.
Sodium Xylene Sulfonate
SECTION X 鈥揙THER REGULATORY INFORMATION
SECTION III - PHYSICAL DATA PROPER SHIPPING NAME: Compounds, Cleaning, NFPA HEALTH: 3
Liquid
APPEARANCE: Green-orange transparent liquid. Slight solvent odor.
CONSTITUENT: Potassium Hydroxide NFPA FLAMMABILITY: 1
BOILING POINT: 210 degrees F. VAPOR PRESSURE: N/A
HAZARD CLASS AND LABEL: 8 NFPA REACTIVITY: 0
VAPOR DENSITY: Greater than 1. SPECIFIC GRAVITY: 1.04
ID NUMBER: NA 1760 NFPA OTHER: Alkali
PH: 14.0 SOLUBILITY IN WATER: Completely soluble.
PACKING GROUP: III
SECTION IV - FIRE AND EXPLOSION DATA
SECTION XI - PRECAUTIONARY STATEMENTS
FLASHPOINT:............................................ Greater than 200 degrees F.
WARNING:.................................................. The information contained in this MSDS is based on the
EXTINGUISHING MEDIA:...................... Water fog or fine spray. Carbon dioxide, Dry chemical, or
data available to us from sources we believe to be reliable. No warranty or guaranty expressed or
Alcohol resistant foam.
implied is made regarding the accuracy of this data or the results obtained from the reliance on this
SPECIAL FIRE FIGHTING PROCEDURES:.................................... Firefighters working in areas
data. The manufacturer assumes no responsibility for injury from the use of this product. Be safe-
where this product is present should be equipped with an approved, fully enclosed SCBA .
read this product safety information and pass it on to all persons who may be exposed to this
UNUSUAL FIRE AND EXPLOSION HAZARDS:............................. None known.
product. Federal law requires it.
SECTION V - REACTIVITY DATA
STABILITY: ................................................ Stable under normal conditions.
HAZARDOUS POLYMERIZATION: ..... This product not known to polymerize.
INCOMPATIBILITY:................................ Do not mix with acids or other detergents.
HAZARDOUS BYPRODUCTS:................ Carbon monoxide, carbon dioxide.
SECTION VI - HEALTH DATA
ROUTE(S) OF ENTRY: ............................. Inhalation, skin absorption, or ingestion.
LISTED CARCINOGEN: .......................... Not listed by IARC, NTP or OSHA.
MEDICAL CONDITION AGGRAVATED:........................................ May aggravate pre-existing
dermatitis.
INHALATION:............................................ Not likely to be inhaled in hazardous amounts. Avoid
exposure to mists or vapors. Maintain adequate ventilation in the work area.
INGESTION: ............................................... This material can cause burns and serious damage to any
exposed body parts.
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP