Low Foam Concentrate 38-10010
MSDS 鈥? Material Data Safety Sheet
Review and update this document annual as outlined by OSHA regulations and your safety plan.
Incompatibility (materials to avoid):. Do not mix with acids or Work/Hygienic Practices: Do not contaminate food or beverage
PRODUCT & COMPANY
acidic compounds. with this or other cleaning chemicals.
IDENTIFICATION
Hazardous Decomposition or By-products: CO, CO2, NOX, in
small amounts when residue is incinerated SECTION IX - PHYSICAL/CHEMICAL
Identity (As Used on Label and List): Low Foam Concentrate
Hazardous Polymerization: May occur: Will not CHARACTERISTICS
Product Class:
occur: X Conditions to Avoid: NA.
Emergency Telephone Number: 651-227-8331 Boiling Point: Approx. 212 DEG. F pH:
___________________________________
Telephone Number for Information: 651-227-8331 Specific Gravity (H20) = 1: Approx. 1
Manufacturer's Name and Address:
SECTION VI 鈥? HEALTH HAZARD DATA &
Needels Supply Inc. %
444 Wacouta Street Volatile:
FIRST AID MEASURES
Saint Paul, MN 55101 Vapor Density (Air = 1): Essentially same as water
Primary Hazards: Harmful if swallowed. Concentrate causes
Date Prepared 01-10-2008 Evaporation Rate (Butyl Acetate = 1):. Essentially same as water
burns to eye. Prolonged skin contact removes skin oils and can
___________________________________ cause chafing.
Solubility in Water: Complete
Potential Health Hazards
.
SECTION II - COMPOSITION/ Route(s) of Entry: Skin Absorption: X Ingestion: NO
Vapor Pressure (MM HG):. Essentially same as water
Inhalation: NO
INFORMATION ON INGREDIENTS
Melting Point:. Liquid except when frozen
Eye:. Flush eyes with running water for at least 15 minutes. If
irritation persists, call a physician.
Hazardous Components (Specific Chemical Identity):
Skin:. Flush area with cool water. Remove and wash contaminated
Chemical Common OSHA AGGIH Other
clothing before reuse.
Name(s) PEL Comm
___________________________________
Ingestion:. If swallowed, do not induce vomiting, drink one to two
ents
glasses of water. Call a physician immediately.
A Water NE NE
HMIS
CAS#
Carcinogenicity: NTP? NO IARC Monographs? NO
7732-18-5
OSHA Regulated? NO
B Potassium NE 2mg/m3
Hazardous Material Identification System
Hydroxide
Signs & Symptoms of Exposure:. See health hazards
Health (Salud) 1 = Slight Hazard
CAS#
1310-58-3 (Riesgo Ligero)
C Sodium NA NA
___________________________________
Tripolyphos
Flammable 0 = Minimal Hazard
phate
SECTION VII 鈥? Precautions for Safe Handling (Inflamabilidad) (Riesgo Minimo)
CAS#
and Use
7758-29-4
Steps to be Taken in Case Material is Released or Spilled: All Ractivity 0 = Minimal Hazard
D *Dowanol 25ppm 25ppm 4%
spills should be treated as quickly as possible. Turn off all sources
Glyco (Reactividad) (Riesgo Minimo)
of ignition (pilot lights, cigarettes, etc.) in all areas close to spill.
Ether E B
Provide good ventilation in spill area. CAUTION: Spills cause floors
CAS# 111- Personal B = Gloves & Goggles
to become very slippery. It is recommended that an absorbent (oil
76-2
Protection
dry, sawdust, etc.) be available in case a large spill (say more than
E Ninol 11- NE NE
陆 gallon) occurs. Dyking and applying such material limits spread
CM
MSDS Abbreviations
and improves ease of removal. Apply amounts recommended by
*SARA 313
the manufacturer 鈥? this action generally makes the spill material into
list of 40 NE Not Established
a semi-dry slush which can be removed from a floor using a
CFR 372
ND Not Determined
squeegee (or floor brush) and a shovel (non sparking). Place this
material in a waterproof container and hold for later disposal. After NA Not Available
___________________________________
spill slush is removed, mop-rinse spill area with clear water. Mop-
NK Not Known
rinse again with clear and pick up rinse water with a wet/dry
SECTION III 鈥? NR Not Required
vacuum, put defoamer in vacuum tank to prevent vacuum flooding.
PHYSICAL CHARACTERISTICS Put rinse water in slush container. For small spills (less than 陆
gallon of product) clean up by thoroughly mopping and rinsing.
Solubility in Water: Complete Note: It is recommended that on operator wear impervious footwear
Appearance and Odor: Orange color, Ether like odor. (neoprene, etc.), protective eye glasses and protective gloves.
SECTION IV - FIRE FIGHTING MEASURES
.
Flammability: Autoignition
Temperature: ND
Precautions to be Taken in Handling and Storing: Normal care
Flash Point (method used): Greater than 210 DEG. F
in handling and storage. Store at temperatures from 40 DEG. F to
Flammable Limits: NA LEL: ND UEL: ND
110 DEG. F.
Extinguishing Media See Below
Water Foam? Water Alcohol
Other Precautions: Keep out of reach of children. Do not
?X X Fog? Foam?
Freeze.
Dry Vaporizing Other?
CO2?
Chemic Liquid?
X
Waste Disposal Method: Dispose of in accordance with existing
al?
laws and regulations.
Special Fire Fighting Procedures: NR .
___________________________________
Unusual Fire and Explosion Hazards: NK
TDG Flammability Classification:
Sensitivity to Mechanical Impact: No SECTION VIII - EXPOSURE
Sensitivity to Static Discharge: No
CONTROLS/PERSONAL PROTECTION
Respiratory Protection (Specify Types): NR
___________________________________
Ventilation: Local Exhaust: NA
Special: NA
SECTION V - STABILITY AND
Mechanical (General): Normal ventilation
REACTIVITY sufficient Other: NR
Protective Gloves: Protective gloves when used by hand
Stability: Unstable: Stable: X Eye Protection: Safety goggles or glasses
Conditions to Avoid:. Store above freezing, maximum storage Footwear:
temperature is 110 DEG. F. Other Protective Clothing or Equipment: NR
Needels Supply 鈥? 444 Wacouta Street 鈥? Saint Paul 鈥? Minnesota 鈥? 55101-2327 鈥? Office: 651-227-8331 鈥? Fax: 651-227-2453 鈥? http://www.Needels.com 鈥? Email@Needels.com
|