MATERIAL SAFETY DATA SHEET
IDENTITY (as Used on Label and List) CHEMICAL NAME
CuPLEX 100 Copper Lysine Copper lysine
Section I
Emergency Telephone Number
Manufacturer鈥檚 name
CHEMTREC 800-424-9300
Zinpro Corporation
Address (Number, Street, City, State and ZIP Code) Telephone Number for Information
952-944-2736
Date Prepared
10400 Viking Drive, Suite 240 January 2006
Eden Prairie, MN 55344-7265 Signature of Preparer (optional)
Section II鈥擧azardous Ingredients/Identity Information
Hazardous Components OSHA ACGIH wght % HAP (Y/N) SARA313
PEL TLV (Y/N)
(Specific chemical identity, common names, CAS #)
a a b
1 mg/m3 1 mg/m3 10%(Cu) N
copper 7440-50-8 Y
a
Permissible exposure level (PEL) and threshold limit value (TLV) for copper are set for 鈥渄usts and mists.鈥?
b
Copper compounds (7440-50-8) are subject to the reporting requirements of SARA Title III Section 313
(Emergency Planning and Community Right to Know) and of 40 CFR Part 372
Section III鈥擯hysical/Chemical Characteristics
Boiling Point Specific Gravity (H20 = 1)
NA 1.79
Vapor Pressure (mm Hg) Melting Point
decomposition >500oF
NA
Vapor Density (AIR = 1) Evaporation Rate (Butyl Acetate = 1)
NA NA
Solubility in Water
soluble
Appearance and Odor
dark blue powder, mild lysine odor
Section IV鈥擣ire and Explosion Hazard Data
Flash Point (Method Used) Flammable Limits LEL UEL
non-flammable NA NA NA
Extinguishing Media
as appropriate for surrounding materials
Special Fire Fighting Procedures
respiratory protection against potential of metal fumes;
prevent water from entering navigable or fish-bearing streams
Unusual Fire and Explosion Hazards
none
Section V鈥擱eactivity Data
Stability Unstable Conditions to Avoid
acids or caustics
Stable
X
Incompatibility (Materials to Avoid)
Metal compounds: do not mix with acids or caustics unless under controlled
conditions
Hazardous Decomposition or Byproducts
None
May Occur Conditions to Avoid
Hazardous
Polymerization
Page 1 of 2
Cuplex100.doc
Will Not Occur
X
Section VI鈥擧ealth Hazard Data
Route(s) of Entry Inhalation? Skin? Ingestion?
Yes Yes Yes
Health Hazards (Acute and Chronic)
May irritate skin, eyes, and mucous membranes.
Carcinogenicity NTP? IARC Monographs? OSHA Regulated?
No No No
Signs and Symptoms of Exposure
Prolonged contact may irritate (mild pain and redness) skin, eyes, and mucous membranes.
Prolonged inhalation may cause irritation of nose, mouth, & throat.
Medical Conditions Generally Aggravated by Exposure
Respiratory problems, existing dermatitis
Emergency and First Aid Procedures
Wash skin and eyes with copious amounts of water. Rinse mouth and throat with water
repeatedly without swallowing. Seek medical attention if necessary.
Section VII鈥擯recautions for Safe Handling and Use
Steps to Be Taken in Case Material Is Released or Spilled
Recover uncontaminated material for reuse. Vacuum or sweep remaining waste, keeping dust
to a minimum. Place in covered container for transport.
Waste Disposal Method
Dispose as nonhazardous solid waste at a facility licensed to receive municipal/industrial
waste. Cover or contain material during transport.
Precautions to Be Taken in Handling and Storing
Store in dry location. Wear dust mask, goggles and chemical resistant gloves to avoid
inhalation or contact.
Other Precautions
None
Section VII鈥擟ontrol Measures
Respiratory Protection (Specify Type)
Ventilation Local Exhaust Special
X dust mask if prolonged contact
Mechanical (General) Other
Protective Gloves Eye Protection
chemical-resistant gloves goggles
Other Protective Clothing or Equipment
none
Work/Hygienic Practices
Use of protective gear and good personal hygiene will reduce
the possibility of contact irritation. Wash with soap and
water after handling.
Page 2 of 2
|