LEARONAL INC -- 37002 KADIZID BRIGHTENER KR
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BXMMN
MSDS NAME: 37002 KADIZID BRIGHTENER KR
Responsible Party
Name: LEARONAL INC
Address: 272 BUFFALO AVE
City: FREEPORT NY 11520-5000
Info Phone: 516-868-8800
Emergency Phone Number: 516-868-8800
Review Ind: Y
Published: Y
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Assigned Ind: Y
Name: LEARONAL INC
Address: 272 BUFFALO AVE
City: FREEPORT NY 11520
=======================================================
Contractor Summary
=======================================================
Name: LEA-RONAL INC/FREEPORT, NY 11520
Address: UNKNOWN
City: UNKNOWN NK 00000
Phone: UNKNOWN
Name: LEARONAL INC
Address: 272 BUFFALO AVE
City: FREEPORT NY 11520
Phone: (516) 868-8800
=======================================================
Ingredients
=======================================================
Cas: 67-64-1
RTECS #: AL3150000
Name: ACETONE; DIMETHYL KETONE; 2-PROPANONE
% Wt: 65-70
OSHA PEL: 2400 MG/CUM
ACGIH TLV: 750 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Name: ORGANIC COMPOUNDS(TYPE NOT SPECIFIED)
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: IRRITATION. SKIN: IRRITATION. ACETONE MAY BE
ABSORBED THROUGH SKIN. INHALATION: HIGH CONCENTRATIONS MAY CAUSE NARCOTIC
EFFECTS. INGESTION: INDUSTRIAL CHEMICALS ARE NEVER TO BE TAKEN INTERNALLY.
MAY BE HARMFUL, IRRITATION OF MOUTH & THROAT.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: IRRITATION, DIZZINESS, LIGHTHEADEDNESS,
HEADACHE, BURNING SENSATION, BITTERNESS, GI DISTURBANCES, NAUSEA, VOMITING,
DEFATTING.
First Aid: EYES: IMMEDIATELY FLUSH W/COPIOUS WATER FOR 15 MINS. SKIN: WASH
W/RUNNING WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
INGESTION: GIVE PLENTY OF WATER/MILK TO DILUTE IN STOMACH & INDUCE
VOMITING BY STICKING FINGER DOWN THROAT. NEVER GIVE LIQUIDS TO AN UNCONSCIOUS
PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SHUT OFF IGNITION SOURCES & EVACUATE AREA. WEAR
SAFETY EQUIPMENT CONTAIN & ABSORB W/INERT MATERIAL. SWEEP/SHOVEL AS MUCH
AS POSSIBLE INTO POLYTHYLENE CONTAINER & ISOLATE UNTIL DISPOSAL. RINSE
W/COPIOU S WATER TO WASTE TREATMENT SYSTEM.
Waste Disposal Methods: DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS
BY INCINERATION IN AN APPROVED SITE.
Handling And Storage Precautions: FLAMMABLE LIQUID. STORE IN COOL DRY AREA,
AWAY FROM HEAT/IGNITION SOURCES & INCOMPATIBLE MATERIALS. PROTECT FROM
PHYSICAL DAMAGE.
Other Precautions: AVOID BREATHING VAPORS/MIST & CONTACT W/EYES & SKIN.
FOR INDUSTRIAL USE ONLY. INDUSTRIAL CHEMICALS ARE NEVER TO BE TAKEN
INTERNALLY. ALWAYS WEAR SAFETY EQUIPMENT WHEN USING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: <100F
Lower Limits: 2.6 (SUPP)
Upper Limits: 12.8 (SUPP)
Extinguishing Media: ALCOHOL FOAM, CO2, DRY CHEMICAL. WATER SPRAY MAY BE
INEFFECTIVE.
Fire Fighting Procedures: WEAR SELF CONTAINED BREATHING APPARATUS & FULL
TURN-OUT GEAR.
Unusual Fire/Explosion Hazard: FLAMMABLE LIQUID. EXPOSURE TO HEAT MAY BUILD UP
PRESSURE IN CLOSED CONTAINERS. AUTOIGNITION TEMP ( PURE ACETONE): 869F.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE A NIOSH APPROVED CARTRIDGE FOR ORGANIC VAPORS IN
AREAS WHERE VAPORS EXCEED EXPOSURE LIMITS.
Ventilation: GOOD GENERAL VENTILATION. LOCAL EXHAUST/OTHER MEANS TO MAINTAIN
AIRBORN CONCENTRATIONS <EXPOSURE LIMITS.
Protective Gloves: RUBBER, NEOPRENE/POLYVINYL CHLORIDE
Eye Protection: CHEMICAL SPLASH GOGGLES/FULL FACE SHIELD
Other Protective Equipment: APRON/COVERALLS & RUBBER/NEOPRENE BOOTS, SAFETY
SHOWERS/EYE WASH/OXYGEN SUPPLY & FIRST AID KITS READILY ACCESSIBLE.
Work Hygienic Practices: REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health: AUTOIGNITION TEMP: 869F (PURE ACETONE).
LOWER/UPPER EXPLOSIVE LIMITS IS FOR PURE ACETONE.
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Density: >1
Spec Gravity: 0.865-0.91
PH: 5.5-9
Evaporation Rate & Reference: SLOWER THAN N-BU AC
Solubility in Water: MISCIBLE
Appearance and Odor: CLEAR LIGHT YELLOW LIQUID W/CHARACTERISTIC ODOR.
Percent Volatiles by Volume: 98/WT
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, SPARKS, OPEN FLAMES & OTHER IGNITION
SOURCES.
Materials To Avoid: OXIDIZING & REDUCING AGENTS, STRONG ACIDS & BASES.
Hazardous Decomposition Products: CO, CO2.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: 37002 KADIZID BRIGHTENER KR
Assigned IND: Y
Company: LEARONAL INC
Street: 272 BUFFALO AVE
City: FREEPORT NY
Zipcode: 11520
Health Emergency Phone: 516-868-8800
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: EYES: IRRITATION. SKIN: IRRITATION. ACETONE MAY BE
ABSORBED THROUGH SKIN. INHALATION: HIGH CONCENTRATIONS MAY CAUSE NARCOTIC
EFFECTS. INGESTION: INDUSTRIAL CHEMICALS ARE NEVER TO BE TAKEN INTERNALLY.
MAY BE HARMFUL, IRRITATION OF MOUTH & THROAT.
IRRITATION, DIZZINESS,
LIGHTHEADEDNESS, HEADACHE, BURNING SENSATION, BITTERNESS, GI DISTURBANCES,
NAUSEA, VOMITING, DEFATTING.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|