DEFT INC -- SOLVENT BLEND, W/R PRIMERS, IS-248
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BZKBT
MSDS NAME: SOLVENT BLEND, W/R PRIMERS, IS-248
Responsible Party
Name: DEFT INC
Address: 17451 VON KARMAN AVE
City: IRVINE CA 92714
Info Phone: 714-474-0400
Emergency Phone Number: 800-424-9300 (CHEMTREC)
Preparer's Name: MIKE SMITH
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: DEFT INC
Address: 17451 VON KARMAN AVE
City: IRVINE CA 92714-6205
Phone: 800 424-9300
Name: DEFT, INC.
Address: 17451 VON KARMAN AVE
City: IRVINE CA 92614
Phone: 949-474-0400
=======================================================
Ingredients
=======================================================
Cas: 64742-95-6
RTECS #: WF3400000
Name: SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (C8 & 10 AROMATIC
HYDROCARBON) VP: 3 @ 68F
% Wt: 50
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 71-36-3
RTECS #: EO1400000
Name: BUTYL ALCOHOL; (N-BUTYL ALCOHOL) (SARA 313) (CERCLA) VP: 4.4 @ 68F
% Wt: 50
OSHA PEL: 100 PPM
ACGIH TLV: 50 PPM, S, C
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
RTECS #: 9999999VO
Name: VOLATILE ORGANIC COMPOUND: 839 G/L
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Name: RESP PROT: BE MAINTAINED & DOCUMENTED BELOW OSHA/ACGIH LIMS, A
NIOSH/MSHA APPRVD AIR SUPPLIED RESP MAY NOT BE
-----------------------------
Name: ING 4: REQUIRED. HOWEVER, OTHER NIOSH/MSHA APPRVD RESPS MAY BE USED.
-----------------------------
Name: VENT: REMOVE ALL IGNITION SOURCES (HEAT, SPARKS, FLAME AND HOT SURFACES).
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL: IRRIT OF RESP TRACT & ACUTE NERVOUS SYS DEPRESS
CHARACT BY FOLLOWING PROGRESSIVE STEPS: HDCH, DIZZ, STAG GAIT, CONFUSN, UNCON
OR COMA. SKIN: CNTCT W/SKIN CAN CAUSE IRRIT. SYMPS MAY BE SWELL, RE DNESS
& RASH. EYES: LIQ, AEROSOLS OR VAPS ARE IRRIT & MAY CAUSE TEARING,
REDNESS, SWELL ACCOMPANIED (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: BY STINGING SENSATION. INGEST:
CAN RSLT IN IRRIT & POSS CORR ACTION IN MOUTH, STOM TISS & DIGEST
TRACT. VOMIT MAY CAUSE ASPIR OF SOLV, RSLTG IN CHEM PNEUM. CHRONIC: PRLNGD
CNTCT WILL CAUSE D RYING & CRACKING OF SKIN DUE TO DEFATTING ACTION. SKIN
SENSIT, ASTHMA OR OTHER ALLERGIC RESPONSES MAY DEVELOP.
Medical Cond Aggravated By Exposure: ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA AND DERMATITIS.
First Aid: INHAL: MOVE TO AREA FREE FROM RISK OF FURTHER EXPOS. RESTORE BRTHG.
ASTHMATIC TYPE SYMPS MAY DEVELOP & MAY BE IMMED OR DELAYED BY SEVERAL
HRS. OBTAIN MED ATTN. SKIN: REMOVE CONTAMD CLTHG. WASH AFFECTE D AREAS THORO
W/SOAP & WATER. WASH CONTAMD CLTHG THORO BEFORE REUSE. EYES: FLUSH
W/CLEAN LUKEWARM WATER (LOW PRESS) FOR AT LEAST 15 MIN OCCAS LIFTING EYELIDS.
OBTAIN MED ATTN. INGEST: DO NOT (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE ALL
SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES). VENTILATE AREA.
CONTAIN AND REMOVE WITH INERT ABSORBENT AND NON-SPARKING TOOLS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: WASTE MUST BE DISPOSED OF I/A/W FEDERAL, STATE &
LOCAL ENVIRONMENTAL CONTROL REGS. EMPTY CONTAINERS MUST BE HANDLED WITH CARE,
DUE TO PRODUCT RESIDUE & FLAMMABLE VAPOR. DO NOT INCINERATE CLOSED CONTAI
NERS. HAZ WASTE NUMBER/CODE: D001, F003, F005.
Handling And Storage Precautions: STORE IN BLDGS DESIGNED TO COMPLY W/OSHA
1910.106. AVOID STORING NEAR HIGH TEMPS, FIRE, OPEN FLAME & SPARK
SOURCES. STORE IN TIGHTLY CLSD (SUPDAT)
Other Precautions: KEEP CNTNRS TIGHT & UPRIGHT TO PVNT LEAK. PVNT PRLNGD
BRTHG OF VAPS/SPRAY MISTS. PRLNGD OVEREXP MAY CAUSE ALLERGIC RXN. AVOID CNTCT
W/SKIN & EYES. DO NOT TAKE INTERNALLY. DO NOT HANDLE UNTIL MFR'S SFT Y
PRECS HAVE BEEN READ & UNDERSTOOD.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 97.0F,36.1C
Lower Limits: 1.00%
Upper Limits: 11.20%
Extinguishing Media: FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER
FOG.
Fire Fighting Procedures: USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIPMENT
(FP N). WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE
BUILD-UP, AUTOIGNITION OR EXPLOSION.
Unusual Fire/Explosion Hazard: KEEP CNTNRS TIGHTLY CLSD. ISOALTE FROM HEAT,
SPKS, ELEC EQUIP & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN EXPOS TO
EXTREME HEAT. APPLICATN TO HOT SURFS (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPRVD RESP RECOM/APPRVD FOR USE IN ORG VAP
ENVIRON (ALL PURIFYING/FRESH AIR SUPPLIED) IS NEC. OBSERVE OSHA REGS FOR RESP
USE. VENT SHOULD BE PROVIDED TO KEEP EXPOS LEVELS BELOW OSHA PERMIS SIBLE
LIMS. IF TLV LIMS CAN
Ventilation: EXHST VENT SUFFICIENT TO KEEP AIRBORNE CONCS OF SOLV VAPS/MISTS
BELOW THEIR RESPECTIVE TLVS MUST BE UTILIZED.
Protective Gloves: COTTON, NEOPRENE, RUBBER POLYETHYLENE.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER(FPN). LONG
SLEEVE & LONG LEG CLTHG RECOM. REMOVE & WASH CONTAMD CLTHG BEFORE REUSE.
Work Hygienic Practices: WASH HANDS BEFORE EATING, SMOKING OR USING WASHROOM.
SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health: EXPLO HAZ: REQS SPEC PRECS. DURING EMER CNDTNS
OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT.
FIRST AID PROC: INDUCE VOMIT. DO NOT GIVE ANTYTHING TO UNCON PERSON. OBTAIN
MED ATTN. HNDLG/STOR PRECS: CNTNRS. STORE IN WELL VENT AREAS.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >244F,>118C
Vapor Pres: SEE INGS
Vapor Density: HVR/AIR
Spec Gravity: 0.84034
Evaporation Rate & Reference: 0.19 X N-BUTYL ACETATE
Solubility in Water: INSOLUBLE
Appearance and Odor: CLEAR LIQUID WITH SOLVENT ODOR.
Percent Volatiles by Volume: 100
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH TEMPERATURES, SPARKS OR OPEN FLAMES.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: BY HIGH HEAT/TEMPERATURE: CARBON MONOXIDE,
CARBON DIOXIDE AND OXIDES OF NITROGEN.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: SOLVENT BLEND, W/R PRIMERS, IS-248
Company: DEFT INC
Street: 17451 VON KARMAN AVE
City: IRVINE CA
Zipcode: 92714-6205
Health Emergency Phone: 800-424-9300 (CHEMTREC)
Label Required IND: Y
Date Of Label Review: 10/19/1995
Status Code: C
Label Date: 10/19/1995
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE: INHALATION: RESPIRATORY TRACT
IRRITATION AND ACUTE NERVOUS SYSTEM DEPRESSION WITH HEADACHE, DIZZINESS,
STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS OR COMA. SKIN: IRRITATION WITH
SWEL LING, REDNESS AND RASH. EYES: IRRITATION AND MAY CAUSE TEARING, REDNESS
AND SWELLING ACCOMPANIED BY STINGING SENSATION. INGESTION: IRRITATION AND
POSSIBLE CORROSIVE ACTION IN MOUTH, STOMACH TISSUE AND DIGESTIVE TRACT.
ASPIRATION MAY CAUSE CHEMICAL PNEUMONITIS. CHRONIC: DRYING AND CRACKING OF
SKIN; SENSITIZATION, ASTHMA OR OTHER ALLERGIC RESPONSES MAY DEVELOP.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|