HILTI INC -- FS 601 ELASTOMERIC FIRE STOP SEALANT
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CBCHK
MSDS NAME: FS 601 ELASTOMERIC FIRE STOP SEALANT
Responsible Party
Name: HILTI INC
Address: 5400 S 122ND E AVE
City: TULSA OK 74146
Info Phone: 918-252-6000
Emergency Phone Number: 800-879-4444
Preparer's Name: JEFF WARMOLTS
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: HILTI INC
Address: 5400 S 122ND E AVE
Box: 21148
City: TULSA OK 74121
Phone: 918-252-6000/800--879-6000
Name: HILTI INC
Address: 5400 S 122ND EAST AVE
Box: 21148
City: TULSA OK 74121
Phone: 918-252-6000/800-879-6000
=======================================================
Ingredients
=======================================================
Cas: 70131-67-8
Name: POLYDIMETHYLSILOXANE; (SILOXANES AND SILICONES, DIMETHYL (HYDROXY
TERMINATED))
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 471-34-1
RTECS #: FF9335000
Name: CARBONIC ACID, CALCIUM SALT (1:1); (CALCIUM CARBONATE)
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 63148-62-9
RTECS #: JJ6484500
Name: DOW CORNING 200 FLUID; (SILOXANES AND SILICONES, DIMETHYL)
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 21645-51-2
RTECS #: BD0940000
Name: ALUMINUM HYDROXIDE
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 2224-33-1
Name: ALKYL TRI(METHYLETHYLKETOXIME) SILANE
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 68611-44-9
Name: SILANE, DICHLORODIMETHYL-, REACTION PRODUCTS WITH SILICA; (FUMED SILICA)
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 1317-70-0
RTECS #: BV6550000
Name: ANATASE; (INORGANIC PIGMENT)
OSHA PEL: 10 MG/M3
ACGIH TLV: 10 MG/M3
------------------------------
Cas: 919-30-2
RTECS #: TX2100000
Name: 1-PROPANAMINE, 3-(TRIETHOXYSILYL)-; ((3-AMINOPROPYL)TRIETHOXYSILANE)
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
RTECS #: 9999999VO
Name: VOLATILE ORGANIC COMPOUND: NONE
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: KNOWN HAZARDS. EYE AND SKIN IRRITATION. SIGNS AND
SYMPTOMS:EYES:CAN CAUSE TEMPORARY DISCOMFORT (ITCHING, DRYNESS, REDNESS,
ETC). SKIN:NO EFFECTS EXPECTED DURING NORMAL USE. PROLONGED AND REPEATED CONT
ACT MAY IRRITATE THE SKIN. INHALATION:NO EFFECTS EXPECTED. INGESTION:NOT
CONSIDERED A ROUTE OF EXPOSURE.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: EYE AND SKIN CONDITIONS.
First Aid: EYES:IMMED FLUSH W/PLENTY OF WATER WHILE HOLDING LIDS APART FOR @
LST 15 MIN. CONT MD IF EFFECTS OCCUR. SKIN:WIPE OFF MATL W/SOAP & WATER.
LAUNDER CONTAM CLTHG BEFORE REUSE. INHAL:MOVE TO FRESH AIR IF DISCOMFORT
DEVELOPS. IF SYMPS PERSIST,CONSULT MD. INGEST:GIVE PLENTY OF WATER TO DRINK.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCON PERSON. DO NOT INDUCE VOMIT UNLESS
DIRECTED BY MD. CALL MD (SUP DAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ALLOW TO CURE. SCRAPE UP SPILLED MATERIAL AND PLACE
IN A CLOSED CONTAINER FOR DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: CONSULT WITH REGULATORY AGENCIES OR CORPORATE PERSONNEL
FOR DISPOSAL METHODS THAT COMPLY WITH LOCAL, STATE AND FEDERAL HEALTH AND
ENVIRONMENTAL REGULATIONS.
Handling And Storage Precautions: KEEP CONTAINER CLOSED WHEN NOT IN USE. STORE
IN A DRY PLACE BETWEEN 35 AND 100F. KEEP FROM FREEZING.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: >608F,>320C
Extinguishing Media: WATER FOG, CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NONE KNOWN.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NORMALLY REQUIRED. NEVER ENTER A CONFINED SPACE
WITHOUT AN APPROPRIATE NIOSH/MSHA APPROVED AIR-SUPPLIED RESPIRATOR (E.G. SCBA
OR AIRLINE WITH ESCAPE PACK).
Ventilation: GENERAL (NATURAL OR MECHANICALLY INDUCED FRESH AIR MOVEMENTS).
Protective Gloves: COTTON OR IMPERMEABLE GLOVES ARE REC.
Eye Protection: ANSI APPROVED CHEM WORKERS GOGGS (FP N).
Other Protective Equipment: ANSI APPROVED EMERGENCY EYE WASH AND DELUGE SHOWER
(FP N).
Work Hygienic Practices: OBSERVE GOOD HYGIENE PRACTICES. DO NOT EAT, DRINK OR
SMOKE WHILE USING. WASH HANDS AFTER USING AND BEFORE MEALS.
Supplemental Safety and Health: FIRST AID PROC:IMMEDIATELY. OTHER:REFERRAL TO A
PHYSICIAN IS RECOMMENDED IF THERE IS ANY QUESTION ABOUT THE SERIOUSNESS OF
THE INJURY/EXPOSURE.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.3
Evaporation Rate & Reference: NOT DETERMINED
Solubility in Water: INSOLUBLE
Appearance and Odor: RED PASTE. SLIGHT ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: PRODUCES METHYLETHYLKETOXIME ON CONTACT WITH
WATER/HUMIDITY. METHYLETHYLKETOXIME CAN CAUSE SLIGHT EYE/SKIN IRRITATION.
Materials To Avoid: WATER OR HUMIDITY. SEE "CONDITIONS TO AVOID".
Hazardous Decomposition Products: WHEN HEATED TO DECOMPOSITION, CAN YIELD CO*X
AND NO*X.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: FS 601 ELASTOMERIC FIRE STOP SEALANT
Assigned IND: Y
Company: HILTI INC
Street: 5400 S 122ND EAST AVE
PO Box: 21148
City: TULSA OK
Zipcode: 74121
Health Emergency Phone: 800-879-4444
Label Required IND: Y
Date Of Label Review: 04/22/1996
Status Code: C
Label Date: 04/22/1996
Origination Code: G
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:EYE AND SKIN IRRITATION. SIGNS AND
SYMPTOMS:EYES:CAN CAUSE TEMPORARY DISCOMFORT (ITCHING, DRYNESS, REDNESS,
ETC). SKIN:PROLONGED AND REPEATED CONTACT MAY IRRITATE THE SKIN. CHRONIC:
NONE SPECIFIED BY MANUFACTURER.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.