LORD CORP -- CHEMLOK 610
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CBXMH
MSDS NAME: CHEMLOK 610
Responsible Party
Name: LORD CORP
Address: 2000 WEST GRANDVIEW BLVD
City: ERIE PA 16514
Info Phone: 814-868-3611
Emergency Phone Number: 814-763-2345
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: LORD CORP
Address: 2000 W GRANDVIEW BLVD
Box: 10038
City: ERIE PA 16514
Phone: 814-868-3611
Name: LORD CORPORATION, CHEMICAL PRODUCTS DIVISION
Address: 2000 WEST GRANDVIEW BLVD
City: ERIE PA 16514-0038
Phone: 814-868-3611
=======================================================
Ingredients
=======================================================
Cas: 64-17-5
RTECS #: KQ6300000
Name: ETHYL ALCOHOL; (ETHANOL)
% Wt: 2
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM
------------------------------
Name: RESP PROT:USE A NIOSH APPROVED AIR-SUPPLIED RESPIRATOR. OBSERVE OSHA
REGULATIONS (29 CFR 1910.134) FOR RESP USE.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:EYE CONTACT:MAY CAUSE IRRITATION. SKIN CONTACT:MAY
CAUSE IRRITATION. MAY CAUSE DERMATITIS. INHALATION:MAY CAUSE RESPIRATORY
TRACT IRRITATION. INGESTION:HARMFUL IF SWALLOWED. INGESTION IS NOT AN
EXPECTED ROUTE OF ENTRY IN INDUSTRIAL OR COMMERCIAL USES. CHRONIC:MAY CAUSE
LIVER OR KIDNEY DAMAGE. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:CHRONIC SKIN CONTACT MAY CAUSE
DERMATITIS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES:FLUSH IMMED W/LG AMT OF WATER FOR AT LST 15 MINS HOLDING
EYELIDS OPEN WHILE FLUSHING. GET PROMPT MED ATTN. SKIN:FLUSH CONTAM SKIN W/LG
AMTS OF WATER WHILE REMOVING CONTAM CLTHG. WASH AFFECTED ARE AS W/SOAP &
WATER. GET MED ATTN IF SYMPS OCCUR. INHAL:MOVE PERS TO FRESH AIR. RESTORE
& SUPPORT CONTINUED BRTHG. IF BRTHG IS DFCLT, GIVE OXYG. GET IMMED MED
ATTN. INGEST:DO NOT INDUCE VOMIT. (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: AVOID BRTHG VAPS. NOTIFY APPROP AUTHS IF NEC. CONTAIN
& REMOVE W/INERT ABSORB MATL. AVOID CONT. USE APPROP NIOSH/MSHA APPRVD
RESP PROT FOR LG SPILLS/SPILLS IN CONFINED AREA. KEEP NON-ESSNTL PERS AWAY
FROM SPILL AREA. BEFORE ATTEMPTING (SUPP DATA)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL SHOULD BE DONE I/A/W FEDERAL (40 CFR PART
261), STATE & LOCAL ENVIRONMENTAL CONTROL REGULATIONS. IF WASTE IS
DETERMINED TO BE HAZARDOUS, USE LICENSED HAZARDOUS WASTE TRANSPORTER &
DISPOSAL FA CILITY.
Handling And Storage Precautions: KEEP CLOSURE TIGHT & CNTNR UPRIGHT TO
PVNT LEAKAGE. AVOID SKIN & EYE CONT. DO NOT HANDLE UNTIL ALL SAFETY PRECS
HAVE BEEN READ & UNDERSTOOD.
Other Precautions: EMPTY CNTNRS SHOULD NOT BE RE-USED. USE W/ADEQ VENT. STORE
ONLY IN WELL-VENTILATED AREAS. KEEP FROM FREEZING. KEEP CNTNR CLSD WHEN NOT
IN USE. DO NOT SMOKE IN ANY CHEM HNDLG/STOR AREA. FOOD/BEVERAGES SHOULD NOT
BE CONSUMED ANYWHERE (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: >200F,>93C
Lower Limits: 4.3%
Upper Limits: 19%
Extinguishing Media: CO*2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures: USE NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
IF WATER IS USED, FOG NOZZ ARE PREF. DURING FIRE, IRRIT &/OR TOX GASES
& PARTICULATE MAY BE (SUPP DATA)
Unusual Fire/Explosion Hazard: COMBUSTIBLE LIQ - CLASS IIIB. KEEP CNTNRS
TIGHTLY CLSD. CLSD CNTNRS MAY RUPTURE WHEN EXPOS TO EXTREME HEAT. USE WATER
SPRAY TO KEEP FIRE EXPOS CNTNRS COOL.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE A NIOSH/MSHA APPRVD CHEM/MECH FILTER RESP DESIGNED
TO REMOVE COMBINATION OF PARTICULATES & ORGANIC VAP IF OCCUP LIMS ARE
EXCEEDED. FOR EMER SITUATIONS, CONFINED SPACE USE/OTHER CNDTNS WHERE EXPOS
LIMS MAY BE GREATLY EXCEEDED,
Ventilation: SUFFICIENT VENT IN PATTERN & VOLUME SHOULD BE PROVIDED IN
ORDER TO MAINTAIN AIR CONTAMINANT LEVELS BELOW REC EXPOS LIMS.
Protective Gloves: NEOPRENE, NITRILE OR RUBBER GLOVES.
Eye Protection: ANSI APPROVED CHEM WORKERS GOGGS (FP N).
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: REMOVE & WASH CONTAM CLTHG BEFORE REUSE. WASH HANDS
BEFORE EATING, SMOKING/USING WASHROOM. WASH THORO AFTER HANDLING.
Supplemental Safety and Health: FIRE FIGHT PROC:GENERATED BY THERMAL
DECOMP/COMBUST. FIRST AID PROC:GIVE VICTIM 1-2 GLASSES OF WATER/MILK. CALL
MD/POIS CTL CTR IMMED FOR FURTHER INSTRUCTIONS. NEVER GIVE ANYTHING BY MOUTH
TO UNCON PE RS. SPILL PROC:CLEANUP, REFER TO HAZ CAUT INFO IN OTHER SECTIONS
OF THIS MSDS. OTHER PREC:THIS PROD IS HNDLG/STORED.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >172F,>78C
M.P/F.P Text: 32.0F,0.0C
Vapor Density: HVR/AIR
Spec Gravity: 1
PH: 10.5
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: SOLUBLE
Appearance and Odor: ORANGE LIQUID; MILD ODOR.
Percent Volatiles by Volume: 96.4
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH TEMPERATURES.
Materials To Avoid: STRONG ACIDS, BASES & STRONG OXIDIZERS.
Hazardous Decomposition Products: MAY CONTAIN CO, CO*2, OXIDES OF NITROGEN,
OXIDES OF SULFUR, HALOGENATED BY-PRODUCTS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: CHEMLOK 610
Assigned IND: Y
Company: LORD CORP
Street: 2000 W GRANDVIEW BLVD
PO Box: 10038
City: ERIE PA
Zipcode: 16514
Health Emergency Phone: 814-763-2345
Label Required IND: Y
Date Of Label Review: 07/24/1996
Status Code: C
Label Date: 07/24/1996
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: Slight
Hazard And Precautions: DECOMPOSITION PRODUCTS MAY BE TOXIC. ACUTE:EYE
CONTACT:MAY CAUSE IRRITATION. SKIN CONTACT:MAY CAUSE IRRITATION. MAY CAUSE
DERMATITIS. INHALATION:MAY CAUSE RESPIRATORY TRACT IRRITATION.
INGESTION:HARMF UL IF SWALLOWED. INGESTION IS NOT AN EXPECTED ROUTE OF ENTRY
IN INDUSTRIAL OR COMMERCIAL USES. CHRONIC:MAY CAUSE LIVER OR KIDNEY DAMAGE.
CHRONIC SKIN CONTACT MAY CAUSE DERMATITIS.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.