HYVAC PRODUCTS INC -- 93055 HYVAC HEAVY PUMP OIL
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CCFMK
MSDS NAME: 93055 HYVAC HEAVY PUMP OIL
Responsible Party
Name: HYVAC PRODUCTS INC
Address: 660 HOLLOW RD
City: PHOENIXVILLE PA 19460-1145
Info Phone: 800-628-0850/610-983-0300
Emergency Phone Number: 800-628-0850/610-983-0300
Review Ind: Y
Published: Y
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Name: HYVAC PRODUCTS INC
Box: 389
City: PHOENIXVILLE PA 19401-0389
=======================================================
Contractor Summary
=======================================================
Name: HYVAC PRODUCTS INC
Box: 389
City: PHOENIXVILLE PA 19401-0389
Phone: 610-792-0500;610-983-0300
=======================================================
Ingredients
=======================================================
Cas: 64741-88-4
RTECS #: PY8040500
Name: MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-REFINED HEAVY PARAFFINIC,
LUBRICATING OIL BASE STOCK
% Wt: 100
OSHA PEL: 5 MG/CUM
ACGIH TLV: 5 MG/CUM
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: ORAL LD50(RAT): >15 G/KG
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: SLIGHTLY TOXIC, 1 PT TO 1 QT IS LETHAL DOSE FOR 150 LB
HUMAN ADULT. INHALATION: MISTS ABOVE TLV MAY CAUSE CHEMICAL PNEUMONITIS.
SKIN/EYES: IRRITATION. INGESTION: SMALL DOSES MAY PRODUCE IRRITATION. PR
OLONGED EXPOSURE MAY CAUSE DERMATITIS &IRRITATION/CHRONIC BRONCHITIS.
Explanation Of Carcinogenicity: NONE
Signs And Symptions Of Overexposure: DROWSINESS, DIZZINESS, HEADACHE, NAUSEA,
IRRITATION, GENERALIZED DEPRESSION, VOMITING, DIARRHEA, DRYING, CRACKING,
FOLICULITIS.
First Aid: INHALATION: REMOVE TO FRESH AIR. CPR IF NEEDED. SKIN: WASH W/SOAP
& WATER. EYES: FLUSH W/WATER. INGESTION: DON'T INDUCE VOMITING. OBTAIN
MEDICAL ATTENTION IN ALL CASES. NOTE TO PHYSICIAN: FOLLOW INGES TION, AT
VISCOSITY ABOUT 350 SUS, THE RISK OF ASPIRATION INTO LUNGS IS REMOTE, BUT
CUFFED TUBE LAVAGE IS RECOMMENDED FOR LARGE QUANTITIES. (SEE SUPP)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE IGNITION SOURCES & HEAT, PROVIDE ADEQUATE
VENTILATION. CONTAIN LEAK. ABSORB W/SUITABLE MATERIAL SUCH AS RAGS,
STRAW/SAND.
Waste Disposal Methods: DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
Handling And Storage Precautions: STORE <150F. DON'T APPLY HIGH HEAT/FLAME
TO CONTAINER. KEEP SEPARATE FROM STRONG OXIDIZING AGENTS.
Other Precautions: EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUES WHICH COULD
INCLUDE FLAMMABLE/EXPLOSIVE VAPORS. AVOID CONTACT W/USED OIL, WASH THOROUGHLY
W/SOAP & WATER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 247-478F
Extinguishing Media: CO2, DRY CHEMICAL, FOAM/WATER FOG.
Fire Fighting Procedures: WEAR SCBA IN ENCLOSED AREAS.
Unusual Fire/Explosion Hazard: WATER MAY CAUSE FROTHING.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF HIGH VAPOR/MIST CONCENTRATIONS, USE RESPIRATOR
APPROVED FOR ORGANIC VAPORS/MISTS.
Ventilation: REQUIRED WHEN WORK PLACE EXPOSURES EXCEED TLVS.
Protective Gloves: OIL IMPERVIOUS
Eye Protection: SAFETY GOGGLES/CHEMICAL SPLASH GOGGLES
Other Protective Equipment: BODY-COVERING WORK CLOTHES.
Work Hygienic Practices: REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: EVAPORATION RATE: (ETHYL ETHER =1): 1000 TIMES
SLOWER. % VOLATILE BY VOLUME: NEGLIGIBLE. FIRST AID CONT'D: ASPIRATED
MATERIAL MAY CAUSE CHEMICAL PNEUMONITIS/LIPOID PNEUMONIA.
SUBCUTANEOUS/INTRAMUSCULA R INJECTION REQUIRES PROMPT SURGICAL DEBRIDEMENT.
IF UNFAMILIAR, SEEK SKILLED ADVICE.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 750F
Vapor Pres: <0.0001
Vapor Density: >20
Spec Gravity: 0.88
Evaporation Rate & Reference: (SEE SUPP)
Solubility in Water: NEGLIGIBLE
Appearance and Odor: AMBER VISCOUS LIQUID W/LITTLE ODOR.
Percent Volatiles by Volume: (SUPP)
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH HEAT/FLAME.
Materials To Avoid: STRONG OXIDANTS.
Hazardous Decomposition Products: THERMAL: CO, CO2
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NONE
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: 93055 HYVAC HEAVY PUMP OIL
Company: HYVAC PRODUCTS INC
PO Box: 389
City: PHOENIXVILLE PA
Zipcode: 19401-0389
Health Emergency Phone: 800-628-0850/610-983-0300
Label Required IND: Y
Date Of Label Review: 10/12/1999
Status Code: A
Origination Code: G
Hazard And Precautions: SLIGHTLY TOXIC, 1 PT TO 1 QT IS LETHAL DOSE FOR 150 LB
HUMAN ADULT. INHALATION: MISTS ABOVE TLV MAY CAUSE CHEMICAL PNEUMONITIS.
SKIN/EYES: IRRITATION. INGESTION: SMALL DOSES MAY PRODUCE IRRITATION. PR
OLONGED EXPOSURE MAY CAUSE DERMATITIS &IRRITATION/CHRONIC BRONCHITIS.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|