DOW CORNING CORP -- O-RING LUBRICANT
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CHXJV
MSDS NAME: O-RING LUBRICANT
Responsible Party
Name: DOW CORNING CORP
Address: SOUTH SAGINAW RD
City: MIDLAND MI 48686
Info Phone: 517-496-5900
Emergency Phone Number: 800-424-9300 (CHEMTREC)
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: DOW CORNING CORP
Address: 3901 S SAGINAW RD
Box: 997
City: MIDLAND MI 48686-0997
Phone: 517-496-6000/517-496-6315
Name: DOW CORNING CORP
Address: 2200 W SALZBURG RD
City: AUBURN MI 48611
Phone: 517-496-4388
=======================================================
Ingredients
=======================================================
Cas: 112945-52-5
RTECS #: VV7310000
Name: SILICA GEL; (SILICA, AMORPHOUS)
% Wt: 9
OSHA PEL: 6 MG/M3
ACGIH TLV: 10 MG/M3
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: INHAL: NO IRRIT TO EYES/RESP PASSAGES. NO INJURY IS
LIKELY FROM RELATIVELY SHORT EXPOS OF LESS THAN 8 HRS. SKIN: SINGLE PRLNG
EXPOS (24-48 HRS) CAUSE NO KNOWN ADVERSE EFT. EYES: DIRECT CONT MAY CAUSE
TEMPORARY DISCOMFORT, W/MILD REDNESS & DRYNESS, SIMILAR TO WINDBURN.
(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: INGEST: SML AMTS TRANSFERRED TO
MOUTH BY FINGERS DURING USE, ETC, SHOULD NOT CAUSE INJURY. SWALLOWING LGE
AMTS MAY CAUSE DIGESTIVE DISCOMFORT. CHRONIC: NO HARMFUL LONG-TERM EFTS
KNOWN. TERAT OGENICITY, MUTAGENICITY, OTHER REPRO EFTS: NONE KNOWN.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL: NO FIRST AID SHOULD BE NEEDED. IF ANY BRTHG DFCLTYS OCCUR
DURING WORK, REMOVE FROM EXPOS & GET MED ATTN. SKIN: NO FIRST AID SHOULD
BE NEEDED. WASH SKIN W/MILD SOAP & WATER TO REMOVE PROD. LAUND ER SOILED
CLTHG BEFORE WEARING AGAIN. EYES: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST
15 MINS. GET MED ATTN IF PAIN/IRRIT OCCURS. INGEST: NO FIRST AID SHOULD BE
NEEDED. IF LARGE AMOUNTS SWALLOWED, GE T MEDICAL ATTENTION. GENERAL COMMENTS:
TREAT ANY EXPOSURE SYMPTOMATICALLY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OBSERVE ALL PERS PROT EQUIP RECS DESCRIBED. WIPE
UP/SCRAPE UP, & PLACE IN CONTRS FOR SALVAGE/DISP. CLEAN AREA AS APPROP,
SINCE SOME SILICONE MATLS MAY PRESENT SLIP HAZ (EVEN IN SML QTYS). GIVE AREA
OF SPILL FINAL CLEANING W/STEAM, SOLVS/DETERGENTS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: LOCAL, STATE, AND FEDERAL LAWS AND REGULATIONS MAY
APPLY TO RELEASES AND DISPOSAL OF THESE MATERIALS, AS WELL AS MATERIALS AND
ITEMS USED IN THE CLEANUP. YOU MUST DETERMINE WHICH FEDERAL, STATE AND LO CAL
LAWS AND REGULATIONS ARE APPLICABLE.
Handling And Storage Precautions: USE WITH ADEQUATE VENTILATION. AVOID EYE
CONTACT. NO SPECIAL STORAGE AND HANDLING PRECAUTIONS. USE REASONABLE CARE.
Other Precautions: AVOID EYE CONTACT. USE REASONABLE CARE IN HANDLING. THESE
PRECAUTIONS ARE FOR ROOM TEMPERATURE HANDLING. USE AT ELEVATED TEMPERATURE,
OR IN AEROSOL/SPRAY APPLICATIONS, MAY REQUIRE ADDITIONAL PRECAUTIO NS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 212F,100C
Extinguishing Media: LGE FIRES: USE DRY CHEM, FOAM/WATER SPRAY. SML FIRES: USE
CARBON DIOXIDE (CO*2), DRY CHEM/WATER SPRAY. WATER CAN BE USED TO COOL
FIRE-EXPOSED CONTRS.
Fire Fighting Procedures: WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
DETERMINE NEED TO EVACUATE/ISOLATE AREA, ACCORDING TO YOUR LOC EMER PLAN. USE
WATER SPRAY TO KEEP FIRE-EXPOSED CONTRS COOL.
Unusual Fire/Explosion Hazard: PROD CAN BURN, BUT IS NOT COMBUST AT NORM TEMPS.
NOT SUSCEPTIBLE TO MECH IMPACT/STATIC DISCHARGE. THERMAL BREAKDOWN OF THIS
PROD DURING FIRE/EXPOS TO VERY HIGH HEAT MAY EVOLVE THE FOLLOWING HAZ COMBUS
T/DECOMP PRODS: CARBON MONOXIDE, CO*2, TRACES OF INCOMPLETELY BURNED CARBON
CMPDS, SILICON DIOXIDE & FORMALDEHYDE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NO RESPIRATORY PROTECTION SHOULD BE NEEDED. USE NIOSH
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN (FP N).
Ventilation: GOOD GENERAL VENTILATION IS RECOMMENDED. LOCAL EXHAUST SHOULD NOT
BE REQUIRED.
Protective Gloves: IMPERVIOUS GLOVES (FP N).
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGLES (FP N).
Other Protective Equipment: NONE NORMALLY REQUIRED. EMERGENCY EYEWASH AND
DELUGE SHOWER MEETING ANSI DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASHING AT MEALTIME AND END OF SHIFT IS NORMALLY
ADEQUATE.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: >1
Appearance and Odor: TRANSLUCENT WHITE GREASE, WITH SLIGHT ODOR.
Percent Volatiles by Volume: 0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: PRODUCT MAY DECOMPOSE OR IGNITE IF EXPOSED TO
EXTREMELY HIGH TEMPERATURES.
Materials To Avoid: AVOID CONTACT WITH OXIDIZING MATERIALS.
Hazardous Decomposition Products: SEE FIRE AND EXPLOSION HAZARDS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: O-RING LUBRICANT
Company: DOW CORNING CORP
Street: 3901 S SAGINAW RD
PO Box: 997
City: MIDLAND MI
Zipcode: 48686-0997
Health Emergency Phone: 800-424-9300 (CHEMTREC)
Label Required IND: Y
Date Of Label Review: 09/28/1998
Status Code: C
Label Date: 09/28/1998
Origination
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYES: DIRECT CONTACT MAY CAUSE TEMPORARY
DISCOMFORT, WITH MILD REDNESS AND DRYNESS, SIMILAR TO WINDBURN. INGESTION:
SWALLOWING LARGE AMOUNTS MAY CAUSE DIGESTIVE DISCOMFORT. CHRONIC: NONE SPECIF
IED BY MANUFACTURER.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|