IMAGE INK JET PRINTING CORP -- 5137 KETONE INK FT107
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CJCZC
MSDS NAME: 5137 KETONE INK FT107
Responsible Party
Name: IMAGE INK JET PRINTING CORP
Address: 1650 AIRPORT RD STE 103
City: KENNESAW GA 30144-5000
Emergency Phone Number: 770-421-7700
Chemtrec IND/Phone: (800)424-9300
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: IMAGE INK JET PRINTING CORP
Address: 1650 AIRPORT RD STE 103
City: KENNESAW GA 30144-5000
Phone: 404-421-7700
=======================================================
Ingredients
=======================================================
Cas: 78-93-3
RTECS #: EL6475000
Name: METHYL ETHYL KETONE
% low Wt: 78.
% high Wt: 88.
OSHA PEL: 590 MG/M3;200 PPM
ACGIH TLV: 590 MG/M3;200 PPM
ACGIH STEL: 885 MG/M3;300 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Name: QUATERNARY AMMONIUM
< Wt: 2.
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Effects of Exposure: IRRITATING TO EYES/RESPIRATORY SYSTEM. INHALATION: VAPOR
CONCENTRATIONS ABOVE RECOMMENDED EXPOSURE LEVELS MAY ACT AS AN ANESTHETIC
& CAUSE OTHER EFFECTS ON THE CENTRAL NERVOUS SYSTEM. SMALL AMOUNTS OF
LIQUID ASPIRATED INTO THE RESPIRATORY SYSTEM DURING INGESTION/VOMITING MAY
CAUSE BRONCHOPNEUMONIA/PULMONARY EDEMA. THERE IS NO EVIDENCE THAT EXPOSURE TO
METHYLETHYLKETONE ALONE CAUSES PROGRESSIVE/IRR EVERSIBLE NEUROTOXIC EFFECTS.
HOWEVER, SIMULTANEOUS OVER-EXPOSURE TO METHYLETHYLKETONE & TO N-HEXANE OR
2-HEXANONE OR TOLUENE CAN INCREASE THE RISK OF NEUROPATHY LINKED TO THEM.
Signs And Symptions Of Overexposure: IRRITATION, HEADACHE, DIZZINESS
=======================================================
Handling and Disposal
=======================================================
Waste Disposal Methods: DISPOSE OF IAW/LOCAL, STATE & FEDERAL REGULATIONS.
Handling And Storage Precautions: STORE <95F. KEEP THE PRODUCT IN ITS
ORIGINAL POLYETHYLENE CONTAINER. KEEP CONTAINER CLOSED. HANDLE CONTAINERS
W/CARE. OPEN SLOWLY IN ORDER TO CONTROL POSSIBLE PRESSURE RELEASE.
Other Precautions: STORE IN A COOL, WELL-VENTILATED PLACE AWAY FROM
IMCOMPATIBLE MATERIALS, IGNITION & HEAT SOURCE. THE FLOOR OF THE SHOP
MUST BE INCOMBUSTIBLE & ACT AS A RETAINER SO THAT SPILLED LIQUID WILL NOT
SPREAD OUT.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point: =-5.C, 23.F
Lower Limits: 1.8
Upper Limits: 11.5
Extinguishing Media: WATER SPRAY, FOAM, DRY CHEMICAL.
Fire Fighting Procedures: USE WATER SPRAY TO COOL FIRE-EXPOSED SURFACES/PROTECT
PERSONNEL. STOP LEAK IF POSSIBLE. IF LEAK/SPILL HAS NOT IGNITED, USE WATER
SPRAY TO DISPERSE VAPORS & TO PROTECT THOSE ATTEMPTING TO STOP LEAK. EI
THER ALLOW FIRE TO BURN UNDER CONTROLLED CONDITIONS/EXTINGUISH W/FOAM/DRY
CHEMICAL. TRY TO COVER LIQUID SPILLS W/FOAM.
Unusual Fire/Explosion Hazard: EXTREME HAZARD. LEAKS OF GAS/SPILLS OF LIQUID
CAN READILY FORM FLAMMABLE MIXTURES AT TEMPERATURES AT/ABOVE FLASHPOINT.
DON'T USE WATER AS AN EXTINGUISHER WHEN PRINTERS ARE ON FIRE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: WHERE EXPOSURE IS LIKELY TO EXCEED ACCEPTABLE CRITERIA
USE APPROVED RESPIRATORY PROTECTION EQUIPMENT.
Ventilation: ADEQUATE VENTILATION.
Protective Gloves: NATURAL/BUTYL RUBBER GLOVES
Eye Protection: SAFETY GLASSES
Other Protective Equipment: IMPERVIOUS CLOTHING
Work Hygienic Practices: REMOVE/LAUNDER CONTAMINATED CLOTHING/SHOES BEFORE
REUSE.
Supplemental Safety and Health: NOTE: THE FLASH POINT OF THE PRODUCT HAS NOT
BEEN DETERMINED. THE FLASH POINT INDICATED IS THAT OF THE SOLVENT W/THE
LOWEST FLASH POINT. MELTING/FREEZING POINT: -139F TO -103F. BOILING POINT:
158F TO 194F.
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Pres: <133 (METHYLETHYLKETONE)
Vapor Density: >1
Viscosity: <10
Solubility in Water: PARTIAL W/PRECIPITATE
Appearance and Odor: WHITE LIQUID W/STRONG CHARACTERISTIC ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: STRONG OXIDIZING AGENTS
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
Toxicological Information: PREGNANT WOMEN SHOULD AVOID HANDLING & EXPOSURE.
NO COMPONENT OF THIS PRODUCT HAS BEEN IDENTIFIED AS A CARCINOGEN BY IARC.
=======================================================
Ecological Information
=======================================================
Ecological: NO INFORMATION IS AVAILABLE.
=======================================================
MSDS Transport Information
=======================================================
Transport Information: TRANSPORT TEMPERATURE: <95F. KEEP THE PRODUCT IN ITS
ORIGINAL POLYETHYLENE CONTAINER. UN NUMBER:1210. PARTIAL EXEMPTION OF
APPLICATION: 500 KG. TOTAL EXEMPTION OF APPLICATION: 5 LITERS PER INNER CONTA
INER & 20 LITERS PER PACKAGE.
=======================================================
Other Information
=======================================================
Other Information: THE ATTENTION OF THE USER IS DRAWN TO THE RISKS BROUGHT UPON
BY THE MISUSE OF THE PRODUCT. THIS DATA SHEET DOES NOT EXEMPT THE USER FROM
KNOWING & APPLYING THE RELEVANT REGULATIONS. IT IS RESPONSIBILI TY OF THE
USER TO TAKE ALL PRECAUTIONS NECESSARY TO THE USE OF THE PRODUCT. THE
INFORMATION CONTAINED IN THIS PUBLICATION IS GIVEN IN GOOD FAITH & TO THE
BEST OF OUR KNOWLEDGE AT THE TIME OF EDITION.
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: 5137 KETONE INK FT107
Company: IMAGE INK JET PRINTING CORP
Street: 1650 AIRPORT RD STE 103
City: KENNESAW GA
Zipcode: 30144-5000
Health Emergency Phone: 770-421-7700
Label Required IND: Y
Date Of Label Review: 02/04/1999
Status Code: A
Origination Code: G
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.